2005 FORD F-450 SD Complaints

TL* THE CONTACT OWNS A 2005 FORD F-450 SD. THE CONTACT STATED THAT THE BRAKE LIGHTS, TURN SIGNALS AND THE HAZARD LIGHTS WERE INOPERABLE. THE DEALER ADVISED THE CONTACT TO REPLACE THE WIRING HARNESS. THE MANUFACTURER INFORMED THE CONTACT THAT HIS VIN WAS NOT INCLUDED IN THE RECALL UNDER NHTSA CAMPAIGN ID NUMBERS: 11V352000 (EXTERIOR LIGHTING:BRAKE LIGHTS) OR 11V352000 (EXTERIOR LIGHTING:TAIL LIGHTS). NO REPAIRS WERE PERFORMED. THE CURRENT AND THE FAILURE MILEAGES WERE 121,000.

TL* THE CONTACT OWNS A 2005 FORD F-450 SD. THE CONTACT WAS DRIVING 45 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED HOME AND THE DEALER WAS NOTIFIED WHO INFORMED HIM TO CHECK THE FUEL FILTER DRAIN PLUG AND THEN DRAIN THE FUEL OUT. THE DEALER STATED THAT IF HE SHOULD NOTICE PAINT FLAKES, WHICH WOULD BE THE LAMINATION OF THE INSIDE OF THE FUEL TANK, HE WOULD HAVE TO REPLACE THE FUEL TANK, PUMP AND CLEAN OUT THE FUEL LINES. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 85,000.

TL* THE CONTACT OWNS A 2005 FORD F-450. THE CONTACT WAS DRIVING 5 MPH WHEN A NOISE EMITTED FROM THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TRANSMISSION FLY WHEEL BOLTS, CAUSED DAMAGE TO FLY WHEEL, TORQUE CONVERT AND THE BOLTS WERE REMOVED IN ORDER TO CORRECT THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, AND THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 97,105 AND THE CURRENT MILEAGE WAS 97,600. THE CONSUMER STATED HE HEARD A VERY UNUSUAL, LOUD NOISE EMANATING FROM THE REAR OF THE ENGINE COMPARTMENT. HE HAD THE TRUCK TOWED TO A LOCAL FORD DEALER FOR REPAIRS. THE MECHANIC VERIFIED THE NOISE COMING FROM THE BELL HOUSING AREA. HE REMOVED THE TRANSMISSION AND FOUND THE FLYWHEEL BOLTS LOOSE, WHICH CAUSED DAMAGE TO THE FLYWHEEL AND TORQUE CONVERTER. THE FLYWHEEL, TORQUE AND BOLTS WERE REPLACED WHICH RESOLVED THE PROBLEM. UPDATED 11/10/11

TL* THE CONTACT OWNS A 2005 FORD F-450 SD. THE CONTACT STATED THAT THE FUEL TANK WAS DELAMINATING AND CAUSING FUEL TO BECOME CLOGGED. THE DEALER WAS CONTACTED AND DENIED ANY ASSISTANCE WITH REPAIR TO THE VEHICLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 45,000 AND THE CURRENT MILEAGE WAS 70,000. THE VIN WAS UNAVAILABLE. THE CONSUMER STATED THE VEHICLE WAS REPAIRED, BUT NOT AT A FORD DEALERSHIP, SINCE THE REFUSED TO ACKNOWLEDGE THE FUEL TANK DELAMINATED INTO THE FUEL AND THEN PLUGGED THE FUEL FILTER MORE THAN ONCE. UPDATED 08/26/11

MY 2005 F-450 BEGAN LOSING POWER. I TOOK IT IN TO A DEALERSHIP TO GET IT FIXED,(STILL UNDER WARRANTY). THE PROBLEM IS THAT THE FUEL TANK IS COMING APART INSIDE. THE TANK IS LINED INSIDE WITH A SHEET OF ALUMINUM. THE ALUMINUM IS COMING APART INSIDE THE TANK AND CLOGGING THE FUEL SYSTEM. SO THE DEALERSHIP SAID I NEED A NEW FUEL TANK, FUEL PUMP, INJECTOR PUMP, AND NEW FUEL INJECTORS. THIS TANK IS DEFECTIVE. THIS HAS BEEN A PROBLEM IN THESE TRUCKS SINCE 1999-2008. FORD KNEW THIS WAS HAPPENING. FORD HAS HAD THOUSANDS OF COMPLAINTS ABOUT THIS PROBLEM. NOW THE DEALERSHIP WANTS TO CHARGE ME $4200.00 TO FIX, EVEN UNDER WARRANTY. DEALERSHIP SAYS FORD WILL NOT COVER THERE DEFECTIVE PART. I'M THE ONLY ONE WHO DRIVES THIS TRUCK, ALWAYS USE PUMP FUEL NO BIODIESEL EVER.

WE HAVE A FORD 2005 F-450 RACK BODY TRUCK. IN 2007-08 WE PAID A FORD DEALERSHIP APPROX.$4000 TO REPLACE FUEL TANK, FUEL PUMP AND INJECTORS ON SAID VEHICLE. JUST THIS WEEK, A DIFFERENT FORD DEALERSHIP INFORMED US THAT THE ORIGINAL PROBLEM HAPPENED AGAIN AND WE WOULD INCUR SIMILAR EXPENSES BECAUSE FORD DOES NOT CONSIDER THIS A DEFECT ON THEIR PART BUT A PROBLEM WITH THE FUEL. *TR

TL* THE CONTACT OWNS A 2005 FORD F-450 SUPER DUTY. THE CONTACT STATED WHILE DRIVING 60 MPH AND TOWING UPHILL, THE VEHICLE BEGAN TO STALL AND INDEPENDENTLY DECELERATED TO 30 MPH. THE CONTACT WAS BARELY ABLE TO MAINTAIN CONTROL OF THE VEHICLE. THE DEALER PERFORMED A DIAGNOSTIC TEST WHICH DISCOVERED A FAULTY FUEL INJECTOR THAT NEEDED REPLACING. THE DEALER REPLACED THE FAULTY FUEL INJECTOR AND AFTER THE REPAIRS THE CONTACT STATED THAT SEVEN MORE FUEL INJECTORS MALFUNCTIONED. THE CONTACT CALLED THE MANUFACTURER REGARDING NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM:WIRING) BUT WAS ADVISED HAT HIS VIN WAS NOT INCLUDED IN THE RECALL. THE CONTACT STATED THE MANUFACTURER SHOULD EXTEND THE RECALLS BECAUSE THERE WERE NUMEROUS COMPLAINTS ONLINE REGARDING THE DEFECTIVE FUEL INJECTORS. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 130,000.

10/5/2010 BRIGHTON,MI MY TRUCK STARTED TO BLOW WHITE SMOKE AND THE ENGINE STOPPED RUNNING WHILE DRIVING DOWN THE ROAD. I HAD IT TOWED TO MY DEALER AND WAS TOLD IT HAS A DELAMINATION PROBLEM IN THE FUEL TANK AND THE CAUSE WAS FROM BIO-DIESEL CONTAMINATION AND I WOULD NOW NEED TO REPLACE OR RESEAL THE TANK AND INSTALL A NEW FUEL PUMP ALONG WITH ONE NEW INJECTOR AT A COST OF $2643.00 PLUS TAX. I HAD THE REPAIRS DONE BECAUSE I NEED THE TRUCK FOR WORK I ALSO SAVED THE OLD PARTS. HOPEFULLY FORD(IF THEY WANT TO SELL ME ANOTHER TRUCK IN THE FUTURE) WILL PARTICIPATE IN THIS REPAIR. *TR

TL*THE CONTACT OWNS A 2005 FORD F-450. THE CONTACT STATED THAT THE FUEL TANK WAS CORRODED FROM THE INSIDE OUT WHICH CAUSED THE VEHICLE TO STALL WHILE THE CONTACT WAS TRAVELING 40 MPH. THE DEALER REPAIRED THE VEHICLE AND STATED THAT THE CAUSE WAS BECAUSE OF THE ADDITIVES OR BIO DIESEL IN THE DIESEL FUEL. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 55000.

SEPT. 9, 2008 - TRUCK STARTED MISSING CHANGED FUEL FILTER WHEN IN SHOP FOR NORMAL SERVICE MARCH 18, 2009 - TRUCK STALLED AND WOULD NOT START, TOWED TO SHOP, DID DIAGNOSTICS , REGULAR SERVICE, AND PUT ON FUEL REGULATOR OCT. 12, 2009 - TRUCK MISSING AND OVERHEATING, REPLACE FUEL FILTER AND RADIATOR TANK AUG. 11,2010 - TRUCK MISSING AGAIN WOULD NOT START , SMOKING, TOWED TO CAUTHORNS,, THEN TO FORD GARAGE. WARRANTY WORK COMPLETED ON TRUCK, THEY THOUGHT HEAD GASKETS BLOWN, REPLACED EGR COOLER AND OIL COOLER, CLEANED TURBO, , REPLACE FUEL FILTER AND REPLACED BATTERY. AUG. 17, 2010- VEHICLE TOWED TO CAUTHORNES AUTO FROM FORD GARAGE TO HAVE FUEL TANK REPLACED DUE TO PEELING AND SLIVERS IN TANK. SEEING AS HOW THIS IS THE THIRD TRUCK WE HAVE HAD TO HAVE THE FUEL TANK REPLACED ON WE HAVE SAVED THE OLD FUEL TANK AND HAVE IT ON HAND AT OUR SHOP FOR INSPECTION. *TR