2005 FORD F-550 SD Complaints

TL*THE CONTACT OWNS A 2005 FORD F-550 SUPER DUTY. WHILE HAVING THE VEHICLE SERVICED AT AN AUTHORIZED DEALER FOR ENGINE FAILURES, THE CONTACT WAS TOLD THE FUEL TANK WAS RUSTING FROM THE INSIDE OUT. THE CONTACT WAS ALSO INFORMED THAT THE RUSTING OF THE FUEL TANK WAS CAUSING THE ENGINE FAILURES. THE VEHICLE WAS EXPERIENCING TROUBLES STARTING THE VEHICLE AS WELL AS A LOSS OF POWER WHILE DRIVING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 77,000.

1. 2005 FORD F550 DIESEL TRUCK STALLING, ROUGH IDLE, LOSS OF POWER COMPLETELY. 2. THE DIESEL FUEL TANK IS DELAMINATING AND HAS CAUSED $6,000 WORTH IN DAMAGES. MY TRUCK STOPPED WORKING COMPLETELY AND WAS TOWED TO A FORD DEALERSHIP HERE IN HAWAII FOR DIAGNOSIS. MY F550 IS CURRENTLY COVERED WITH A SUPER DUTY DIESEL ENGINE CARE WARRANTY THAT COST OVER $3,000 YET FORD WILL NOT REPLACE THE DEFECTED TANK THAT HAS CAUSED THOUSANDS OF PROBLEMS NATIONWIDE TO DATE. THE TANKS NEED TO BE RECALLED AND INDIVIDUALS NEED TO BE REIMBURSED. FORD HAS TAKEN AWAY FROM OUR ECONOMY AND ENDANGERED OUR ROADS. 3. FUEL FILTERS, FUEL TANK, FUEL INJECTORS, FUEL PUMPS, FUEL PRESSURE REGULATORS, AND FUEL SENDERS ALL NEED TO BE REPLACED. THEY ARE PLANNING TO REPLACE THE FUEL TANK WITH THE SAME MANUFACTURED TANK. IT HAS ALREADY BEEN DOCUMENTED THAT THE PROBLEM WILL REOCCUR AS MANY HAVE HAD TO REPLACE THE TANK MORE THAN ONCE. FORD BLAMES BIODIESEL YET I HAVE NEVER USED BIODIESEL. THIS IS MANUFACTURED DEFECT. NO OTHER DIESEL TANKS ARE HAVING THIS PROBLEM ON A DAILY BASIS NATIONWIDE. *TR

TL* THE CONTACT OWNS A 2005 FORD F550. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE ENGINE STALLED WITHOUT WARNING. THE FAILURE WOULD OCCUR ON AN INTERMITTENT BASIS. THE VEHICLE WAS TOWED TO THE DEALER WHO INFORMED THE CONTACT THAT SHE WOULD NEED TO REPLACE THE FUEL INJECTOR CONTROL MODULE AND REGULATOR. THE FUEL INJECTOR CONTROL MODULE AND REGULATOR WERE REPAIRED. THE FAILURE RECURRED INTERMITTENTLY FOLLOWING REPAIRS. THE FAILURE MILEAGE WAS APPROXIMATELY 123,981.

I OWN A FORD F 550 SD 2005, THIS TRUCK HAS HAD FUEL SYSTEM PROBLEM OFF AND ON SINCE I PURCHASED THREE YEARS AGO. BUT THIS PAST WEEK IT STARTED MISSING AND STOPPING ON ME IN TRAFFIC, I TOOK IT TO THE FORD DEALER AND I'M TOLD THAT THE FUEL TANK LINING IS COMING OFF AND DAMAGED THE FUEL PUMP, FILTERS AND INJECTORS, REPAIR TO COST $5,000. ALSO THAT THIS IS DUE TO THE EPA'S LOW SULFUR REQUIREMENT ON DIESEL FUELS. THIS MAY BE TRUE BUT FORD KNOW OF THIS WAY PRIOR TO THE START DATE OF THIS NEW FUEL AND STILL IS USING DEFECTIVE PARTS THAT THEY WILL NOT COVER UNDER WARRANTY OR A RECALL TODAY.... THIS PARTS FAILURE INCLUDE 2 FUEL TANKS, FUEL PUMP, FUEL FILTERS,AND INJECTORS ALL DAMAGED DUE TO A POOR TANK LINING OR COATING. *TR

TL* THE CONTACT OWNS A 2005 FORD F-550. THE CONTACT STATED WHILE DRIVING AT 65 MPH, THE VEHICLE BEGAN TO INDEPENDENTLY DECREASE IN SPEED. THE CONTACT ATTEMPTED TO ACCELERATE BUT THE VEHICLE WOULD NOT RESPOND. THE CONTACT THEN SWITCHED TO THE REAR FUEL TANK YET THE FAILURE PERSISTED. HE ATTEMPTED TO SWITCH BACK TO THE FRONT FUEL TANK HOWEVER THE VEHICLE STALLED. THE CONTACT CONTINUED TO SWITCH FROM THE REAR TO THE FRONT FUEL TANK AND EACH TIME HE WOULD SWITCH TO THE FRONT FUEL TANK, THE VEHICLE WOULD STALL. THE CONTACT STATED HE ATTEMPTED TO CHANGE THE FUEL FILTER HOWEVER IT WAS SEVERELY CLOGGED WITH WHAT APPEARED TO BE PAINT. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FUEL TANK, FOUR FUEL INJECTORS AND THE FUEL LINES THAT WERE CONNECTED TO THE ENGINE BACK TO THE TANK. THE DEALER ADVISED THE FAILURE WAS CAUSED BY DE-LAMINATION OF THE FUEL TANK. THERE WERE NO RECALLS FOR THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 95,400. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY INSPECTED THE FRONT FUEL TANK AND DISCOVERED THE COATING AND LINING WAS PEELING OFF INSIDE THE TANK, WHICH CAUSED FUEL SHORTAGE TO THE ENGINE. THE DEALER REPLACED THE FRONT FUEL TANK, FUEL FILTERS, FUEL REGULATOR, FUEL INJECTORS AND FLUSHED ALL THE FUEL LINES. UPDATED EVOQ 09/08/10*JB UPDATED 10/04/10. *LJ THE DEALER INSPECTED THE TANK AND FOUND THE LINING OF THE FRONT TANK PEELING OFF AND GETTING INTO THE FUEL TANK SYSTEM. THEY REPLACED THE FRONT TANK AND FLUSHED ALL OF THE FUEL LINES. ALSO, THE REAR TANK REVEALED PAINT FLAKING AND REPLACEMENT OF THAT TANK WAS REQUIRED. UPDATED 10/12/10

THE CONTACT OWNS A 2005 FORD F-550. SHE STATED THAT ON JUNE 1, 2010, WHILE DRIVING 20 MPH, THE ENGINE OVERHEATED AND CONTACT HAD TO STOP THE VEHICLE AND REPLACED THE COOLANT FLUIDS. THE DEALER AND MANUFACTURER WAS CONTACTED AND ADVISED THAT THEY WERE NOT ABLE TO REPAIR THE FAILURE BECAUSE IT WAS NO LONGER UNDER WARRANTY. THE FAILURE AND CURRENT MILEAGE WERE 50,000..MR

I AM CONTACTING YOU TO FILE A COMPLAINT WITH FORD MOTOR COMPANY REGARDING THE FUEL TANKS ON 450 AND F550 TRUCKS THAT WE OWN. I HAVE MORE THAN ONE VEHICLE THAT IS AND HAS BEEN AFFECTED BY THIS. THE FUEL TANKS ARE DEGRADING FROM THE INSIDE, CAUSING FUEL SYSTEM DAMAGE AND CREATING A HAZARD DUE TO THE FACT THAT AS LARGE AS THESE VEHICLES ARE THEY CAN BE DISABLED IN TRAFFIC. I DO UNDERSTAND THAT ANY VEHICLE COULD BE RENDERED DISABLED. HOWEVER THIS WOULD BE FOR A KNOWN CAUSE. FORD DEALERSHIPS ARE WELL AWARE OF THE PROBLEM AS ARE MANY TANK REPAIR FACILITIES IN NEW ENGLAND. I UNDERSTAND THROUGH RESEARCH THESE TANKS HAVE BEEN DEFECTIVE SINCE 1998. FORD IS TRYING TO SAY IT IS DUE TO BIO-DIESEL. IF YOU LOOKED INSIDE THE TANK, YOU WOULD SEE IT IS LIKE PAINT FLAKING OFF OF A WALL. THIS SITUATION HAS BEEN DOING DAMAGE TO PUMPS AND INJECTORS CAUSING BREAKDOWNS. FORD IS WELL AWARE OF THIS AND HAS DONE NOTHING TO RESOLVE IT TO THE BEST OF MY KNOWLEDGE. *TR

TL* THE CONTACT OWNS A 2005 FORD F550 SD. THE CONTACT STATED BECAUSE THE LINING IN THE FUEL TANK HAS BECOME LAMENTED, IT CLOGS THE FUEL FILTER. AS A CONSEQUENCE FUEL NOT ONLY LEAKS, BUT THE ENGINE INTERMITTENTLY STALLS. HE CONTACTED THE DEALER, AND WAS ADVISED BY A TECHNICIAN THAT HE WOULD HAVE TO PAY $900.00 TO REPLACE THE FUEL TANK. NO REPAIRS WERE MADE. THE FAILURE AND CURRENT MILEAGES WERE 74,000.

2005 FORD F-550 FUEL TANK LINER FAILURES. TANK LINER COMING APART CAUSING THE FUEL TANK NEEDING TO BE RELINED, AND REPLACING THE FUEL PUMP AND FUEL FILTER. *TR

WE OWN A 2005 FORD F-550 DIESEL TRUCK. WE ARE HAVING PROBLEMS WITH THE FUEL TANK DELAMINATING AND CAUSING THE FUEL FLOW TO STOP TO THE ENGINE. THIS IS A COMMON PROBLEM ON ALOT OF FORD DIESEL TRUCKS, FORD DOES NOT WANT TO TAKE RESPONSIBILITY FOR THE TANK DELAMINATION, CAUSING THE TRUCK TO STOP RUNNING. WE ARE HAVING TO PAY FOR THE REPAIR, EVEN THOUGH THE TRUCK IS STILL UNDER WARRANTY. THEY SAY THAT WE ARE RUNNING BIO-DIESEL THROUGH THE TRUCK AND THIS IS WHAT IS CAUSING THE LINER SEPARATION. *TR