1989 FORD F350 Complaints

IN RESEARCHING PROBLEM ON THE INTERNET I FOUND A NUMBER OF NEWSPAPER ARTICLES INDICIATING NTSA HAD REOPENED THEIR INVESTIGATION INTO THIS PROBLEM. COULD NOT LOCATE ANY DATA ON YOUR SITE. ANY STATUS ON PROBLEM OR RECALL??

THIS PROBLEM HAPPENED AFTER THE IGNITION SWITCH WAS REPLACED DURING A RECALL. FORD CONTINUES TO SCREW ITS CUSTOMERS AND THE GOVERNMENT BY NOT COMING UP WITH A FIX. FOR THE STEERING COLUMN TO GET SO HOT HIGH AMPS. MUST BE SENT TO THE STEERING COLUMN. IS THERE A DEFECT IN THE WIRE HARNESS? I HAVE FOUND OVER THE YEARS THAT FORD REPAIRS ARE UNRELIABLE AND LEAVE THE CUSTOMER WITH AN UNSAFE VEHICLE. *AK

I WAS EAST BOUND ON INTERSTATE 8 EAST OF ALPINE, CA PULLING A TRAILER UP A 6% GRADE. I NOTICED SMOKE FROM THE REAR OF THE TRUCK. I PULLED ONTO THE SHOULDER OF THE ROAD TO INVESTIGATE. THE SPARE TIRE HAD SHIFTED IN ITS MOUNT NEAR OR AGAINST THE TAIL PIPE. THE TIRE HAD IGNITED AND WAS IN FLAMES. IT IS MOUNTED AGAINST THE BOTTOM OF THE REAR FUEL TANK. I EXTINGUSHED THE FIRE, AND REMOVED THE TIRE FROM THE TRUCK. I HAVE BEEN INFORMED OF 3 OTHER INCIDENTS OF THIS OCCURRING ON OTHER FORD PICKUP TRUCKS SINCE THIS INCIDENT. IN ALL FOUR INCIDENTS, THE TRUCKS WERE PULLING TRIALER UP HILL. MY CONCERN IS THE POSSIBILITY OF THE BURNING SPARE TIRE IGNITING THE FUEL IN THE REAR FUEL TANK. I CAN PROVIDE THE VIN NUMBER LATER IF YOU STILL NEED IT. *AK

HEADLIGHT SWITCH MELTED THE WIRING HARNESS. CONSUMER HAS NOTIFIED THE OWNER AND MANUFACTURER. *AK

AS I TRAVEL THE COUNTRY AND ENCOUNTER OTHER FORD TRUCK OWNERS WITH DUAL FUEL TANKS I FIND MANY OF THEM ALSO HAVE PROBLEMS WITH REAR FULE TANK LEAKING. FUEL THEN FALLS ON REAR TIRE AND CAN CAUSE FIRE OR RUIN TIRE. I NOTICED WHEN SEARCHING YOUR DATABASE COMPLAINTS OF THIS NATURE WERE INVESTIGATED AND CLOSED IN 1991 WITHOUT RECALL. CASE # PE91090 (TIRE) AND PE 94004 (BRAKES). ANY WAY I CAN OBTAIN DETALIS OF THESE STUDIES? *AK

GREASE ON REAR BRAKE SEALS, THEY FAILED WHILE DRIVING. OIL WOULD GET ONTO BRAKES. COULD SEE OIL DRIPPING. BRAKES WOULD LOCK UP. REAR BRAKES NOT EFFECTIVE AT ALL, ESPECIALLY WHILE TOWING A TRAILER. WILL HAVE DEALER CHECK OUT SEALS. *AK

ALTERNATOR AND WATER PUMP ARE DESIGNED TOO FAR APART; THIS CAUSES THE BELT TO MOVE UP AND DOWN, HITTING THE AIR PUMP AND WEARING THE BELT AWAY. WHEN IT BREAKS, IT TANGLES IN OTHER BELTS, CAUSING THEM TO JUMP OFF AND SHRED THEMSELVES. VEHICLE LOSES POWER STEERING/BRAKES AND WATER PUMP. *AK

ALTERNATOR BELT IS TOO LONG AND FLOPS AROUND, HITTING THE AIR PUMP AND EVENTUALLY IS CUT IN HALF, WHEN THIS HAPPENS THE BRAKES FAIL WITH. THE OWNER HAS REPLACED THE COMPONENT EIGHT TIMES IN THE SIX YEARS OF OWNERSHIP.

THE DRIVER SIDE FIRE WALL BROKE LOOSE AND WOULD NOT LET THE CLUTCH SAFETY SWITCH ENGAGE.

WHILE DRIVING, CLUTCH PEDAL SAGGED, USED EXCESSIVE FOOT PRESSURE TO MOVE CLUTCH, DEALER NOTICED CRACKED FIREWALL (STRUCTURE) WHILE REPAIRING CLUTCH. DEALER SAYS HAVE A KIT TO REPAIR IT BUT OWNER MUST PAY. *AK