2007 FORD FIVE HUNDRED Complaints

THE PAINT IS BUBBLING UP ALL ALONG THE LOWER EDGE OF THE HOODLINE. THERE ARE NO CHIPS VISIBLE, IF YOU TOUCH THE BUBBLE , THE PAINT FLAKES OFF & EXPOSES THE RUST UNDERNEATH THE PAINT. DEALERSHIP SAYS THIS IS NOT COVERED AFTER THE 3YR/36,000 MILE WARRANTY OR THE 5YR/ UNLIMITED RUST THROUGH WARRANTY. WAITING TO GET QUOTE TO RE-PAINT THE HOOD. *TR

TL*THE CONTACT OWNS A 2007 FORD FIVE HUNDRED. THE VEHICLE EXPERIENCED A FLAT TIRE AND THE CONTACT ATTEMPTED TO REPLACE IT WITH THE MECHANICAL JACK THAT CAME EQUIPPED WITH THE VEHICLE. ONCE THE VEHICLE WAS LIFTED FROM THE GROUND, THE JACK AND TOOTH GEAR FAILED. THE VEHICLE DROPPED TO THE GROUND, BUT WAS NOT DAMAGED. THE DEALER IS REPLACING THE JACK, BUT THE CONTACT BELIEVES THAT ALL OF THE JACKS MAY BE DEFECTIVE. THE CURRENT AND FAILURE MILEAGES WERE 7,000.

FAILURE OF THE HEATING ELEMENT FOR DRIVER'S SIDE SEAT. DEALERSHIP TESTED AND FOUND HEATING ELEMENT HAS INTERMITTENT FAULT. REPAIRED WITH FORD PARTS, UNDER WARRANTY ON 11-12-07. HEATING ELEMENT FOR DRIVER'S SIDE SEAT FAILED AGAIN 2-12-09. BROUGHT INTO DEALERSHIP AND WAS TOLD THE PART IS NOT COVERED UNDER WARRANTY. AT THE COST OF APPROXIMATELY $679, DID NOT HAVE SEAT FIXED. *TR

HAVE 2007 FORD 500 HAD A FLAT TIRE ON RT. REAR. TOOK CAR TO DEALER TO FIX. THEY SAID IT WAS CAUSED BY A CRACKED WHEEL. POSSIBLY HITTING BUMP IN ROAD. IT HAS 18444 MILES RARELY DRIVEN AND HAS NEVER HIT A BUMP VERY HARD OR AT ALL. BUMPER TO BUMPER WILL NOT COVER THE COST, AND WE BELIEVE THIS IS A FAULTY WHEEL FROM FACTORY. PLEASE HELP. *TR

IT STARTED OUT AS A LOUD THUMP THAT ROCKED THE CAR WHEN SHIFTING INTO GEAR... THAT HAS CONTINUED BUT NOW IT ALSO WHEN ACCELERATING HESITATES THEN YOU HEAR THE THUMP AND THEN IT WILL ACCELERATE. I HAVE HAD THIS AT MY DEALERSHIP 3 TIMES NOW AND THEY REFUSE TO FIX IT. THEY CONTINUALLY SAY THE CANNOT "RECREATE" THE PROBLEM. I ALSO HAVE A AIRLEAK IN THE CAR THAT IS SO LOUD YOU CANNOT HEAR THE RADIO WHEN DRIVING ON A INTERSTATE. THEY ARE BLAMING THAT ON THE ANTENNA ON THE OUTSIDE OF THE CAR. I HAVE LESS THEN 20,000 MILES ON THIS CAR AND A EXTENDED WARRANTY. I HAVE NO IDEA WHAT TO DO TO MAKE THEM FIX IT. I WORRY ABOUT THE SAFETY OF THIS, I HAVE A NEWBORN AND AM AFRAID IF IT IS THE TRANSMISSION, WHICH IT SOUNDS LIKE, THAT IT COULD SEIZE UP AND POSSIBLY CAUSE A ACCIDENT. *TR

2007 FORD FIVE HUNDRED WITH 35750 MILES DEALER STATES THE CAR NEEDS REAR BRAKES AND REAR ROTORS. THE REAR BRAKES PADS ARE SHOT AND THE ROTORS ARE GROOVED. DEALER STATES THIS IS NOT COVERED UNDER WARRANTY UNDER THE FORD CAMPAIGN OF 07N10. DEALER STATES THIS CAMPAIGN ISSUE EXISTED ONLY WITH FORD FIVE HUNDRED MANUFACTURED ON OR BEFORE NOVEMBER 28, 2006. OURS SUPPOSEDLY WAS BUILT FEBRUARY 2007. FORD STATES THIS PROBLEM WILL NOT EXIST ON ANY FORD FIVE HUNDRED'S MANUFACTURED AFTER THE DATE OF NOVEMBER 28,2006. *TR

CAR HAS DEVELOPED A NOISE IN FRONT END. A KNOCKING WHEN TURNING WHEEL AT SLOW SPEEDS. THE FORD DEALER HAS PUT NEW STRUTS, BEARING PLATES AND LINK PINS ON CAR. STILL HAS NOISE. I DROVE A NEW ONE SAT AND IT DID NOT DO THIS. THE DEALER TALKED TO FORD ABOUT THIS AND WAS TOLD " RELEASE THE VEHICLE AS NORMAL AND CHARACTERISTIC OF DESIGN IF NOISE IS THE SAME AND ALSO MINIMAL" IF A NEW ONE DOES NOT MAKE THIS NOISE, WHY DOES MINE? MY WIFE IS CONCERNED SOMETHING IS GOING TO HAPPEN TO THE STEERING. *TR

I HAVE A 2007 FORD FIVE HUNDRED WITH CONTINENTAL P215-60R17 TIRES. ON DEC 14, 2007, AFTER MY TIRES HAD BEEN ROTATED AT TOWN EAST FORD IN MESQUITE TEXAS, I NOTICED A LARGE BUBBLE IN THE RIGHT FRONT TIRE ALONG THE SEAM OF THE TIRE. SAID TIRE ID# DOT CODE A3KT 3MT 3906.THE TIRES HAD APPROX 21,250 MILES AT THE TIME. THEY HAVE BEEN ROTATED AT LEAST 4 TIMES SINCE I PURCHASED THE CAR AND I CAN SHOW THAT THE TIRE INFLATION IS CHECKED REGULARLY WHEN I GET THE OIL CHANGED. TOWN EAST FORD TOLD ME THE TIRE WAS NOT COVERED UNDER WARRANTY AS IT WAS CONSIDERED ROAD HAZARD. ORIGINALLY I WAS TOLD IT WAS DUE TO POTHOLES, THEN LATER THAT IT WAS DUE TO A NAIL THAT CAUSED LOW TIRE PRESSURE. I WAS NEVER INFORMED OF A NAIL, NOR DID THEY SHOW ME THE DAMAGE. I CONTEND THE TIRE IS FAULTY; I HAD TO REPLACE THE TIRE AT MY OWN COST. I AM CURRENTLY SENDING CORRESPONDENCE TO TOWN EAST FORD, CONTINENTAL TIRE, NHTSA, AND FORD MOTOR COMPANY. *TR

VEHICLE MISSING SIDE CURTAIN AIR BAGS FRONT AND REAR ALTHOUGH LISTED ON USED CAR DEALER STICKER. *JB

TL*THE CONTACT OWNS A 2007 FORD FIVE HUNDRED. DURING AN INSPECTION, THE CONTACT REALIZED THAT THE PLATE NUT WAS NOT PLACED DEEP ENOUGH INTO THE PANEL, WHICH PREVENTED THE FUEL FILLER NECK FROM BEING SECURELY FASTENED TO THE FENDER. THE DEALER STATED THAT THE FUEL FILLER NECK ADAPTER WAS NOT SECURELY ATTACHED. THE DEALER ATTEMPTED TO TIGHTEN THE BOLTS, HOWEVER, IT CREATED A LARGER GAP. THE CURRENT MILEAGE WAS 1,500 AND FAILURE MILEAGE WAS 500. THE CONSUMER STATED THERE IS A STILL A 1/8" GAP BETWEEN FUEL FILLER AND NECK ADAPTOR AND RIGHT REAR FENDER PANEL. THE DEALER STATED REAR MUFFLER HANGER HAS CORROSION. UPDATED 10/18/07 *TR