2013 FORD FLEX Complaints

ELECTRIC POWER ASSIST STEERING (EPAS) COMPLETELY OUT AND WHEEL CAN BARELY BE TURNED. NO POWER STEERING. MY FLEX WAS SITTING ON THE TOP FLOOR OF A 7 STORY PARKING GARAGE. I STARTED IT UP TO MOVE DOWN TO GET A CLOSER PARKING SPACE NEXT TO THE FLOOR I WAS ACCESSING. I CANNOT AFFORD THE QUOTED STEERING COLUMN $3000 REPLACEMENT I WAS GIVEN. SOME RECALL IS OUT BUT DOES NOT INCLUDE ALL FORD MODELS WITH THIS APPLICATION, INCLUDING MINE. YOU CALL FORD FOR HELP OR ASSISTANCE AND THEY READ OFF THEIR GIVEN ANSWER... YOUR VEHICLE DOES NOT FALL UNDER THE RECALL.

THIS HAS BEEN HAPPENING SINCE JANUARY AND 3X ON 3/3/2020. WHILE DRIVING DOWN A CIRCULAR GARAGE FROM WORK THE VEHUCLE SHUT OFF AND POWER STEERING STOPPED ALMOST HEADING ME INTO THE CONCRETE BARRIER. IT HAS BEEN TWICE ON SIDE ROAD WHEN IT SHUT OFF AND STEERING WAS DISABLED AND ALL 3X NO WARNINGS. NOW FOR THE 5TH TIME AS I PUT CAR IN RWCERSE THE POWER STEERING SHUTS OFF WITH NO WARNING AND I BECOME DISABLED. HAVE TO WAIT AND RESTART CAR. ITS VERY DANGEROUS AND SEE COMPLAINTS ALL OVER FORDS BLOG AND FLEX FORUMS..VERY SCARY TO ALLOW MY DAUGHTERS TO DRIVE..PLEASE HAVE A RECALL OR ASSIST FINANCIALLY. THEIR TELLING OVER $2,800..THATS CRAZY..

TL* THE CONTACT OWNS A 2013 FORD FLEX. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 67 MPH, A LOUD POPPING NOISE OCCURRED AND DRIVER SUDDENLY LOST CONTROL OF THE STEERING CAUSING THE VEHICLE TO VIOLENTLY SWERVE WHILE ON THE HIGHWAY. AFTER STOPPING THE VEHICLE THE DRIVER OBSERVED THE REAR DRIVER SIDE TIRE WAS ANGLED SIDE WAYS. A TOW TRUCK WAS CALLED TO THE SCENE AND THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE REAR SUSPENSION TOE LINK HAD FAILED. THE VEHICLE WAS REPAIRED. DURING THE INCIDENT THE FRONT PASSENGER SUSTAINED A LEFT SHOULDER RE-INJURY WHICH REQUIRED MEDICAL TREATMENT. THE LOCAL DEALER ST. GEORGE FORD (145 HILTON DR. ST. GEORGE, UT) AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE VEHICLE WAS INCLUDED IN THE NHTSA RECALL CAMPAIGN NUMBER 20V072000 (SUSPENSION) BUT THE PARTS NEEDED TO REPAIR THE FAILURE WERE NOT YET AVAILABLE. THE CONTACT INDICATED THAT THE VEHICLE HAD EXPERIENCE THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 70,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

THIRD TIME HAVING THE FUEL PUMP REPLACED . PUMP FAILS EVERY 20-30K MILES. CAR WILL STOP RUNNING WHILE DRIVING ON ROADWAYS, UNABLE TO RESTART VEHICLE. HAD TO PULL OVER TO SIDE OF ROAD AND WAIT FOR TOW. 1ST TIME 36,000 MILES 2ND 53,000, 3RD 90,000. ALL REPAIRS WERE PERFORMED BY FORD SERVICE CENTER

DOOR AJAR INDICATOR ACTIVATES WHEN DOOR IS CLOSED. DOME LIGHT REMAINS ON AND SO DOES THE INDICATOR LIGHT. PASSENGER SIDE REAR DOOR. SAME PROBLEM HUNDREDS OF OTHERS ARE REPORTING.

2013 FORD FLEX. CONSUMER WRITES IN REGARDS TO ILLUMINATED POWER STEERING LIGHT. *LD THE CONSUMER STATE WHILE DRIVING THE POWER STEERING WENT OUT WITH A VERY SHORT NOTICE. WHILE ATTEMPTING TO STOP THE VEHICLE SLOWLY RAN OVER A CURB. THERE WAS NO DAMAGE. THE MANUFACTURER WAS NOTIFIED AND STATED THE VEHICLE WAS PREVIOUSLY REPAIRED FOR THE FAILURE. THE MANUFACTURER DENIED ANY ADDITIONAL ASSISTANCE. THE DEALER DENIED ASSISTANCE DUE TO THE CODE ONLY SHOWING THAT THE VEHICLE FAILED DUE TO IMPACT, AND NOT THAT THE PSCM FAILURE WAS THE CAUSE OF THE IMPACT.*JS

RECEIVED LETTER FROM FORD ADVISING THEY WOULD REPLACE DRIVER DOOR SENSOR DUE TO ISSUES THAT RESULT IN IT READING DOOR AJAR, RESULTING IN DOME LIGHTS STAYING ON AND BATTERY DRAIN. THE SAME ISSUE OCCURS ON OTHER DOORS, SPECIFICALLY ON MINE THE BACK DRIVER SIDE DOOR. THIS HAPPENS SPORADICALLY, WHILE DRIVING, WHILE PARKED, EVEN WHEN THE DOOR IS NOT UTILIZED.

THE SYNC SYSTEM STOPPED WORKING AND UNABLE TO FIND THE ERROR OR ISSUES. SEARCHED INTERNET AND APPEARS TO BE COMMON ISSUE WITH VEHICLE. THE RADIO WOULD MAKE A GLITCHING SOUND AND THEN CONTINUE TO PLAY UNTIL IT COMPLETELY STOPPED ABOUT 5 WEEKS AGO. THE VEHICLE WAS PARKED AND WHEN ATTEMPTING TO START CAR THE RADIO WAS DEAD

2ND ROW SEAT BELTS NOT WORKING OR BROKEN. DRIVER SIDE IS NOT LATCHING OR RETRACTING, SO NONE CAN USE THAT SEAT. PASSENGER SIDE THE BUCKLE COVER WONT STAY ON, AND IT HAS SOME SMALL SHARP OBJECTS THAT CAN CUT SOMEONE OR MY KIDS.

WHILE DRIVING MY 2013 FORD FLEX THE POWER STEERING DISAPPEARED AND I ALMOST LOST CONTROL OF THE VEHICLE. I PULLED OVER AND TURNED IT OFF, WHEN I STARTED IT BACK UP THE POWER STEERING RETURNED TO NORMAL. I STOPPED AT MY DESTINATION BUT WHEN I RETURNED TO LEAVE I FOUND THAT THE POWER STEERING WAS NOT RESPONDING. I DROVE IT HOME WITH GREAT DIFFICULTY. THIS REPEATED SEVERAL TIMES OVER THE NEXT TWO WEEKS, FUNCTIONING AT THE START OF THE DAY BUT FAILING AFTER THE VEHICLE WAS TURNED OFF. THE POWER STEERING FINALLY GAVE OUT ALTOGETHER. I CHECKED AND FOUND THAT THERE WAS A RECALL THAT WAS ANNOUNCED ON JUNE 02 OF 2015 FOR THIS EXACT ISSUE COVERING FORD FLEXES FROM 2010 TO 2013. I SCHEDULED AN APPOINTMENT WITH MY FORD DEALERSHIP TO GET THE ISSUE RESOLVED. I WAS TOLD THAT MY VEHICLE WAS MANUFACTURED A FEW MONTHS AFTER THE RECALL DATE, WHICH COVERED VEHICLES MANUFACTURED UP UNTIL FEB 28TH OF 2012. I CAN'T UNDERSTAND ONE, HOW DOES A RECALL COVER THE YEARS 2010 TO 2013 BUT HAS AN END DATE FOR ELIGIBILITY OF 2012?, THE RECALL WAS ANNOUNCED ON JUNE 02 OF 2015 AND MY VEHICLE SUFFERED THE EXACT SAME ISSUE OF THOSE THAT THE RECALL EXTEND TO. AS WELL AS WHAT WAS DONE TO REMEDY THE PART FAILURE AFTER THE JUNE 02, 2012 DATE THAT MY VEHICLE (SUFFERING THE SAME MALFUNCTION/FAILURE AND MANUFACTURED JUST OUTSIDE OF THE END DATE OF THE RECALL) WAS NOT INCLUDED IN THE RECALL? I HAVE FOUND THAT THE ISSUE IS WITHIN THE SEALED STEERING ASSIST ASSEMBLY ITSELF WITCH SUFFERS HEAT DAMAGE DUE TO THE PLACEMENT OF OTHER COMPONENTS. HEAT SHIELDING WITHIN THE UNIT HAS BEEN REPORTED TO BREAK DOWN, RESULTING IN THE INTERIOR COMPONENTS TO FAIL DUE TO EXCESSIVE HEAT EXPOSURE. *JS *JS