2018 FORD FOCUS Complaints

I am adding a major update to my safety recall complaint because this dealership just tried to pull an illegal financial ambush on me.After my 2019 Focus started stalling out on the highway right after they did Recall 18V735, I brought it back. I explicitly told them in writing on our text thread: 'I do not authorize any standard diagnostic fees, parts, or repair charges.' I just wanted them to show me proof that they didn't pinch a wire or glitch the software during the recall work.Instead of showing me proof, they sent me a text message today saying my vehicle was 'ready for pick up' just to lure me down to the lobby. When I got there, they slapped an unauthorized invoice for $988.82 in front of my face for parts and labor. They did nearly $1,000 worth of work after I told them 'no' in writing, clearly trying to quietly fix their botched recall mistake under the table and force me to pay for it.When I showed the advisor the texts proving I denied the charges, the staff panicked and couldn't answer who authorized the job. I refused to sign it or pay it, and I walked out. My car is currently stranded on their lot because they are holding my keys hostage over unauthorized bills on a federal safety recall file. I have already escalated this to Ford Corporate under Case # CXH-0831-1568-S8L7B8

The plastic gas tank was warped by heat and a faulty purge solenoid. The warped gas tank is a known issue for the 2018 Ford Focus and other versions of the car are covered by the recall, but my VIN apparently was not despite experiencing the same issue at less than 50,000 miles. The warped gas tank caused a dangerous car shutoff in traffic.

The ford focus I drive is constantly shuddering and having trouble selecting gears. The problem has been consistent since I bought the vehicle and I have read that this is a common issue with the ford focus transmission. I bought the vehicle for my sons first car and I can’t even let him drive it

The vehicle was serviced for NHTSA Recall 18V735 (Canister Purge Valve/Fuel Tank stalling hazard). Immediately upon pickup from the dealership, the vehicle began severely stumbling and stalling while driving on the highway. It died while driving on the street. The dealership's diagnostic paperwork confirmed an 'O2 sensor logic error causing the vehicle to stall' right after they performed the mandatory computer software flash and valve replacement. The dealership is refusing to verify if their technician damaged the adjacent wiring harness or glitched the software flash, leaving the vehicle an active highway stalling hazard. As for my experience, The car died in Clear Lake by Baybrook Mall. Extremely high traffic, almost got hit. (Yelled at by several drivers). Constant stalling happened in Baytown. Scariest incident was going over the very tall Fred Hartman bridge. My 10 year old daughter and I felt sure it was about to die and we were going to roll backward down the bridge becauseit kept dropping power. We took the ferry home because we were so scared.

I had an oil pressure light come on while driving and it was followed by the car shutting off and not starting back up. It was towed to a mechanic who told me the timing belt broke while driving and the car requires a new engine. The car was the towed to a ford dealer who confirmed his diagnosis. The car has the 1.0l ecoboost engine and manual transmission. I saw that there is an open investigation on this exact problem and a recall would be greatly appreciated. I'm shocked they are allowed to use a wet timing belt and not a chain.

Last July my car was overheating and breaking down as I was driving on I4 to work one morning which it overheated and broke down which was the precursor the last time My engine blew in December 2024 which the engine was already repaired January 2022 (Dumphy Ford,Pa), December 2022 (Tropical Ford, Fl) then I got notices there is a recall with the oil pump and belt since February 2023 however the remedy parts were not available and kept getting notices that the parts would be in by fall 2024 then it kept getting pushed back when they would be available, meanwhile my car broke down again July 2024 which the engine needed to be replaced and was covered because oil and coolant was leaking into the engine due to the recall and they still didn’t have parts available and then car broke down again December 2024 which Tropical Ford covered because the recall parts were still not available. So in July 2025 they attempted to fix it and I picked it up and it overheated again and they kept it till September 2025 and fixed a bunch of things like transmission, recall and other things and now the car began to overheat again and took it to [XXX] and now they are saying the engine is blown again… I believe the recall failed and I shouldn’t have to pay for the 5Th engine replacement INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The vehicle's transmission control module is not working. The Ford Focus vehicle put my family and I at risk because we would be driving along in the Ford vehicle then all of a sudden it would slow down abruptly in traffic as it loses power. We've only had the vehicle 7 years and it is one of the most expensive problems to have with the car. Many reports online state that transmission control modules and transmissions in general are known complaints for 2018 Ford Focus cars. A diagnostic was performed by a Ford dealer's service center. It was determined the part needs to be replaced. This is very dangerous. I would like for this to be repaired without causing any additional expenses to my family as the Ford company is aware that more than few models have this problem before reaching 7 years or 100,000 miles

I replaced my canister purge valve prior to TSB or recall (18S32). Once I received the letter for reimbursement, I sent my paperwork to the dealer that performed the work (Pierre Ford Seattle on 01/05/25). They said they were going to reimburse me for the work that they did but did not. I went back to the dealer on 04/22/26 with my paperwork again. They made a copy and said they were going to submit my reimbursement. After a week or two they said that the recall reimbursement program had expired earlier this year.

This is the 2nd time the transmission has went on this vehicle. First time was 12/2022 when my son was on his way home from [XXX] to [XXX] from school. Towed to Ford in MA. Ford stated there was a recall on the TCM. Vin did not fall under the recall. Thank god we had Mechanical breakdown with Geico. Had transmission repaired. April 29, 2026, car will not go in reverse or forward once again! RIDICULOUS!!! Cant afford to get a new transmission. Vehicle does not even have 90K on it. If Ford is going to put out a recall, like they did years ago on this issue, they should put it out for ALL and not just certain models. We have always purchased Fords, but I am getting a little sick and tired of recalls not being all ALL the models for that year. Who can afford a new car nowadays?? Thank the [XXX] no one was injured while my son was driving. Ford needs to do something about this issue ASAP! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving, the transmission went into limp/safety mode and became difficult to control. Diagnostic scan confirmed codes P0806 (Clutch Position Sensor A Circuit Intermittent) and P2872 (Clutch A Stuck Engaged). The failure is electrical — wiring harness damage near the clutch position sensor. This has happened multiple times. The vehicle is a 2018 Ford Focus SE with DPS6 PowerShift transmission. Repair estimates range from $1,500 to $2,600. The manufacturer has declined goodwill assistance despite this being a known defect on this model.