2015 FORD FOCUS Complaints

My vehicle is having issues regarding the clutch and transmission module. This issue has been going on every since I bought my vehicle new in 2015. The last time they fixed the issue (free) was in May of 2020. When I went to the dealership where I bought my car and where they have replaced this issue, I was told that they will have to charge me to diagnose the problem. I told them that they never charged me before and the issue it’s having is the same so why today are you charging me? They said that it’s because it could be the clutch issue that’s not covered. However they have fixed the clutch issue before in which that time was May 2029. The for recall for my vehicle is 18V169000 to be fixed up to 150,000 miles my vehicle has 102,000 miles. Another recall that I looked up is 18S07 which is regarding the clutch. Website https://www.cars.com/research/ford-focus-2015/recalls/ So why will they not fix my car when both recall # say they will be fixed at no charge to me.

Two part lug nuts experience swelling over time and make removal of the lugs very difficult and may result in the lugs not being adequately tight when the wheel is put back on. The dealer confirmed that this is a known problem and when they repair this issue, they use an after market lug that is not a two part lug, and therefore doesn't have the swelling issue. I was not aware of this problem till my most recent annual inspection and when I expressed surprise, the dealer mechanic stated that even though Ford is well aware of this issue, Ford will not cover this item and its the owner's problem.

My car‘s check engine light came on, then the whole car suddenly shut off while I was driving down the highway. After getting it restarted, I filled it with gas and after beginning to drive it, the car shut off again. I have run a code on the check engine light and it stated that the EVAP hose needed to be replaced. I called the dealership and they said that it was likely the CVP as this caused the same issue and multiple vehicles were having to have them replaced.

My vehicle began making loud rubbing noises when turning and then in addition, progressed to having trouble steering. I took it to a shop that advised me that I needed a new rack and pinion steering system. I took the vehicle home and when I went to get return to the garage to have it replaced, the car would not turn at all except with extreme force; I had to have it towed. I had to pay for an entire new rack and pinion steering (and labor) and for the front end to be aligned after. I checked and even though there are numerous complaints, there is no recall.

The contact owns a 2015 Ford Focus. The contact stated while her son was driving approximately 20 MPH and depressing on the accelerator pedal, the vehicle started to shudder. The contact stated no warning light was illuminated. The driver was able to continue driving to his destination. The contact took the vehicle to the local dealer, where it was diagnosed with needing the transmission clutch assembly to be replaced. The vehicle was not repaired. Upon investigation, the contact became aware that the vehicle was serviced under NHTSA Campaign Number: 18V169000 (Power Train) in 2019 under the previous owner. The manufacturer had been informed of the failure. The failure mileage was approximately 130,000.

While returning from vacation, my transmission failed with only a displayed message that the transmission was hot and to stop for 5 minutes. I immediately pulled off the highway and parked the car for 15 minutes. The message cleared and I proceeded to drive about another 15 miles and the car lost power to the transmission while in traffic on the interstate. I had to make a lane change and pull off the road. Fortunately I was close to a vehicle repair facility so I drifted to the facility. They immediately evaluated the problem and I was told the transmission had completely failed, which apparently is an issue that Ford was aware of during manufacture. This failure could have caused a crash because I had to switch lanes with perfect timing to prevent an accident. The repair facility contacted a Ford Technician about a mile away who came and tested/evaluated the transmission and confirmed that it had a total failure. From the first warning message until the complete failure was within a ten minute period after allowing the first warning message to clear from the 15 minute cooling period. I am still waiting on parts and repair bills as of 02/09/2022. They will be forwarded as received. This will be the 3rd transmission installed on this vehicle.

I was driving home from work when I got a "steering fault" notification, followed by very limited control over my vehicle's steering system. I was going between 55-65 miles, as I was on an expressway, and came very close to colliding with other vehicles on multiple occasions. I was able to make it home and then when I went to drive it to the shop for repairs, I received the "steering loss" notification and I could no longer move my vehicle. There are quite a few noted complaints about Ford's power steering assist failing with the Focus and many other models.

Vehicle looses all power while driving on freeway. Gas guage inaccurate, after filling gas and driving 150 miles it is out of gas without warning and will loose power under any operating condition. This has happened numerous times.

I started to notice a rubbing sound when I would turn the steering wheel. I also noticed when I turned the wheel to the right, there was a slight hesitating resistance. A week later, I was going down the highway about 70 mph, when a warning message popped up “power steering fault”. At that moment, the steering completely lost power and it was difficult to steer. Going at that speed on a busy highway was very dangerous. Without any power steering, in heavy traffic, I had to manually steer my way from the speed lane to the right outer lane to take the exit. I had to cancel mission, turn around and go back home, hoping to get back safely. I was put at risk and so were other folks on the road, that day. I haven't taken my car for repair yet.

The contact owns a 2015 Ford Focus. Four years ago, the contact stated that while driving at 40 MPH, excessive force was needed to steer his vehicle without warning. The vehicle was taken to a dealer and the rack and pinion were replaced. Recently, the contact stated that while driving at various speeds, an abnormal creaking noise would emit from the power steering without warning. The vehicle was towed to Woody Sander Ford (235 W Mitchell Ave, Cincinnati, OH 45232) and he was informed that the rack and pinion needed to be replaced. The manufacturer was notified of the failure and informed him that there were no recalls on the vehicle; the contact was then referred to the NHTSA for assistance. The vehicle was not repaired. The failure mileage was approximately 38,000.