2012 FORD FOCUS Complaints

Experienced abrupt electrical steering motor failure. Power steering remains inoperable and available for inspection. Occurred during normal driving without warning, and effort required to manually steer was too much for my wife necessitating an emergency stop to avoid collision with oncoming traffic while trying to execute a routine turn putting us and the other vehicle in danger of an offset collision. This appears to be a known issue in FORD steering units but has only been addressed in Fusion models as a recall. The component has yet to be inspected as Ford will not pay for the repair despite the obvious ongoing safety issue, the vehicle will remain off the road for now in the hopes a recall is issued.

Everytime I go to get fuel the car will not crank it makes a terrible noise then cranks but its slow. The pressure in tank causes it to stall out.

I purchased this car as a certified pre owned car from the Mazda dealership In mechanicsburg PA about two and a half years ago. The transmission failed and the car was unsafe to drive after 3 months from the purchase date. The Mazda dealership didn’t know how to fix the transmission as it’s a complicated process. They tried to send it to a ford dealership but they would not work on it. It took Mazda awhile to finish my transmission because they didn’t know how to fix it. Now the same exact problem is occurring two years later. I haven’t even put 40,000 miles on my car after the replacement of the new transmission. As I stated before the car is unsafe to drive and I need it for work. This brand new transmission should not be failing after only 2 years and 35,000 miles. Included files are from November 2022 when I purchased the car and from February and march 2023 when the transmission was fixed.

On Friday [XXX], I was at a stop sign waiting to turn right, when it was my turn to go my car would not move at all, forward or back, the regular lights on the dash board were still on. I put my blinkers on and had all cars go around me. I turned my car off and then back on, that's when the check engine light came on. After 8 minutes of turning the car off and on, I was able to move backwards and forwards I was able to drive. I stopped at AutoZone on the way to get my car scanned. I received a report with a bunch of p-codes. I made it home, I called Ford, they didn't have any immediate appointments. The closet Ford dealership to me says they don't work on cars over 10 years old. I made an appointment at Firestone for saturday morning, they got the same P-codes and said they were all transmission problems and recommended I go to a Ford dealership or a transmission specialists. on my way home from Firestone, first my car speed felt like it was speeding up on it's on and then my car slowed down tremendously and I has to pull over, again I put my blinkers on. After 5 minutes I was able to move again, I was close to home. My car moved so slow feeling like it would stop any time, i drove with my blinkers on and made it home. On Monday my car wouldn't start up at all. A Ford that would take my car didn't have an appointment for 2 weeks. So I made an appointment with AAMCO for Tuesday and I had my car towed there because it wouldn't turn on. My safety was put at risk because I could have been driving at normal speed and could've slowed down out of know where and a car could have slammed into the back or side of me. AMMCO says it my dual input clutch assembly, actuators, forks and TCM This is my first time ever seeing the check engine light on [XXX] Ford's TCM extended warranty expired [XXX]. I called Ford's corporate customer service for help with diagnosis and repair but they said there was nothing they could do. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2012 Ford Focus. The contact stated that while driving between first and second gear, the vehicle shuddered and lost motive power temporarily. The vehicle was taken to two independent mechanics, where the contact was informed that the TCM or the shift interlock actuator needed to be replaced. The contact stated that after the mechanic replaced the shift interlock actuator, the vehicle operated as needed temporarily, and the failure recurred. The vehicle was taken to the dealer to be repaired under a Class Action Lawsuit settlement; however, the dealer informed the contact that the vehicle was not covered. The dealer diagnosed that the transmission clutch was slipping, and the dealer determined that the transmission needed to be replaced. The vehicle was not repaired. The contact stated that the vehicle had failed to respond upon shifting to reverse(R) and failed to exceed first gear or 10 MPH. The check engine warning light was illuminated. The vehicle was not repaired. The manufacturer was notified of the failure and confirmed that the VIN was not under recall. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 67,000.

I own a 2012 Ford Focus with approximately 51,000 miles. The transmission warning light came on, and I was informed by a repair shop that the transmission control module (TCM) and gears need repair. This vehicle uses the PowerShift dual-clutch transmission (DPS6), which has been the subject of a class-action lawsuit and multiple extended warranties due to widespread failures. The car exhibits jerking, delayed acceleration, and loss of power, which create dangerous driving conditions, particularly when merging into traffic or crossing intersections. Ford informed me I am outside the warranty period and refused to assist, despite this being a well-documented, recurring safety issue for which they have admitted fault in other cases. I am reporting this issue because it poses a serious safety hazard, and I believe the TCM defect should be subject to a mandatory recall. Ford is shifting the burden of a known manufacturing defect onto consumers, and this needs to be addressed before someone is injured.

The contact owns a 2012 Ford Focus. The contact stated that while attempting to start the vehicle, the engine shuddered while idling, with the check engine warning light illuminated. The local independent mechanic was contacted; however, the vehicle was not diagnosed. The contact was advised that the failure might be attributed to coolant intrusion into the engine. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 100,058.

The contact's mother owns a 2012 Ford Focus. The contact stated that while his mother was driving at an undisclosed speed, the transmission was slipping, and the vehicle stalled. The check engine warning light was illuminated. The contact's mother pulled over and had the vehicle towed to an independent mechanic and the dealer, who determined that the Transmission Control Module (TCM) had failed and needed to be replaced. The vehicle was not repaired. The contact related the failure to Customer Satisfaction Program: 14M02 (Transmission Control Module Extended Warranty Coverage); however, the vehicle was not included. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 100,000.

The contact owns a 2012 Ford Focus. The contact stated that while driving 35 MPH, the vehicle jerked and the transmission unexpectedly downshifted. The contact was able to pull over to the side of the road. The message "Transmission Overheating" was displayed, and the check engine warning light illuminated. The contact turned off the vehicle and waited until the transmission had cooled down. The contact was able to restart the vehicle. The vehicle was taken to the dealer, where it was diagnosed that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 195,000.

I am reporting a recurring safety issue with the DPS6 dual-clutch automatic transmission in my 2012 Ford Focus (VIN: [XXX] ). The vehicle intermittently fails to shift beyond 3rd gear while in motion, resulting in loss of acceleration and inability to maintain safe highway speeds. The most recent incident occurred in July 2025 while my son was driving. The car would not upshift past 3rd gear, forcing him to pull off the road. We took the vehicle to a Ford dealership, which ran diagnostics and ultimately identified diagnostic trouble code P2832: “Shift Fork B Position Sensor Circuit Low.” This error points to failure of the clutch actuator assembly, a key component of the DPS6 system. The dealership linked the issue to internal transmission component failure but stated the original warranty repair had already been used and no coverage was currently open. Ford Customer Relationship Center advised us to have the dealer submit through the Specialty Recall Program and to file a safety complaint with NHTSA. This failure is consistent with the issues outlined in Technical Service Bulletin (TSB) 16-0109, which addresses shuddering, hesitation, and shifting failure in Ford’s DPS6 transmission due to actuator and clutch contamination. The vehicle previously underwent warranty repair for transmission issues, and this is a repeat failure tied to the same known defect. This defect affects drivability and safety, especially for younger or less experienced drivers. Ford has acknowledged the defect in class action settlements and internal bulletins, but is denying coverage in this case. I am requesting NHTSA investigate this ongoing pattern of failure and pressure Ford to address these safety risks before they result in serious injury. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)