2018 FORD FOCUS Complaints

My vehicle broke down on the side of a major highway at nighttime. We would not find out later that it was both the engine and turbo that needed to be replaced. We purchased the vehicle brand new in 2018 and purchased the maintenance plan with it. Vehicle was maintenance by Ford only and to their standards as recommended yet the vehicle still died with less than 84k miles on it. In fact two weeks prior the vehicle had an oil change. When we finally received the diagnosis of needing a new engine the mechanic stated this is an issue with the 3 cylinder Fords that the company has not addressed yet. My friend who has the exact same car just had hers break down for the same reasons but at 67k miles. The difference is she purchased the extended warranty and we purchased the maintenance plan so hers is being covered 100% and she is being provided a loaner vehicle. Ford refused to cover all of the repair costs even though this issue was clearly a manufacturer issue. They actually kept lowering the assistance amount as time went on. They refused to provide a loaner or reimburse any of the hundreds of dollars we spent on towing. We were without the vehicle for several months and Ford could care less and suggested several times to get a rental even thought we expressed we could not afford it due to costs we already put into the car but especially because we are still paying on the original vehicle loan as well as insurance. Fords customer service was the worst I ever experienced and in every aspect we dealt with them all the way to corporate.

There is currently a recall on 2018 Ford Focus however the dealer claims my VIN is not included. Three weeks ago my check engine light came on I went to a gas station they checked it it states it was a small evaporative leak. It went off, IT came back theee days later. I went to the auto shop they said it was a gas filler neck issues. They fixed it the light went off then a day later came back on. I took it to the shop they said there is a safety recall issue with a deformation of the plastic gas tank due to the CPV which causes the deformation. The dealer refused to fix my car claiming the recall does not included my VIN. Even though what the recall stated is EXACTLY what is wrong with my car.

The contact owns a 2018 Ford Focus. The contact stated while starting the vehicle, the vehicle was jerking. While driving approximately 30 MPH and shifting into 3rd gear, the vehicle jerked. The check engine warning light was illuminated. After restarting the vehicle, the vehicle operated as designed. The vehicle was taken to the local dealer where it was diagnosed that the clutch needed to be replaced. The vehicle was not repaired. The manufacturer was notified and referred the contact to NHTSA. The failure mileage was approximately 114,000.

Engine, and computer that controls check engine and low oil pressure lights. Car started ticking, had appt but not until may 18th dealership where I bought it. On Friday April 15th when I turned car off and got out smelled burning smell. Husband lifted hood and let cool down for an hour, when to go check fluids and no oil, looked under neath no leaks. Have video of all and everything. No alert senor came on to say low oil pressure, or check engine especially since it was bone dry no oil. Bought car with 11800 or so miles on it 6 weeks before. When bought car had oil in it. At 13510 miles no oil. Safety was at risk because it could have caught fire with running it with no oil in it, until app time of May 18th 2022. Took to key scales ford where car was bought, and confirmed no leaks, no oil, no warning lights. Was towed to them on Monday April 18th, was inspected wensday April 20th. No warning lights what so ever came on at all. Car information stated no warnings no messages. Again I have video taken from Friday April 15th when we found car to have no oil. Ford after 2weeks finally decided to replace engine but no answer on computer for warning lights as of now. Engine on back order.

My vehicle is a 2018 Ford Focus st and I am not the first person to have this problem. My vehicle casually lost 3rd and 4th gear synchronizer out of the blue and I had to purchase to synchronizers to replace them. Among pulling the transmission apart and splitting the case open. My mechanic and I identified that 3rd and 4th gear synchronizers had metal tabs on them to keep them in position and they snapped off on every side, so there being a total of six tabs broken, three per synchronizer as you see in the photos. I am not the first person to have this issue so I would ask if you would please review this issue and look deeper into it to possibly come up with a solution.

Every time I fill up my has tank my car stalls. And after 3 or 4 tried with me giving it gas it will start and idle super high. I have even switched to a higher grade gas and it happens with all grades. And if it doesn't stall right away it will cut off shortly after putting it in drive.

I purchased this vehicle used in 8/2021 and within 6 months, I have an inoperable vehicle with a hefty car loan of over $15,000 to payoff monthly. I can’t afford another car and I should not be responsible for paying for a car due to defective parts from the manufacturer that is causing other damage to my vehicle. I haven’t had the use of my vehicle since this time. This is unfair and unacceptable. The component that failed/malfunctioned was the double clutch on the transmission. The vehicle is available for inspection upon request. This poses a safety risk because the vehicle ultimately can lose control, it jerks, slow drags/stalls, gets hot while in traffic which will which eventually shut off preventing me from moving the vehicle out of traffic. This can put me and my passengers in danger of getting hit in the event of a collision from oncoming traffic resulting in eminent danger of getting seriously injured or killed. The problem has been reproduced at an independent service center, Gray’s Garage in Dover, TN. The problem is a known issue on Ford Focus 2016 – 2018 manual transmissions vehicles and associated with recall NHTSA CAMPAIGN ID: 18V845000. It is evident that this issue is also present with 2018 Ford Focus automatic transmission vehicles. Car was inspected by certified mechanic in Dover, TN and I was advised the double clutch was broken and it messed up the transmission. The issue first appeared on 2/14/22, I was stopped at a traffic light with my foot on the break. When moved feet off break just before beginning to accelerate, I heard a noise. The car began to jerk until I got to 15 mph speed and then it downshifts or slow drags. The car alerted me that the transmission hot and to pull over, turn the car off for 5 minutes to let it cool off. I kept trying the steps on multiple occasions this day and the result was the same every time I come to a stop it happens. I was basically stranded, unable to drive any distance with a non-functioning car.

The contact owns a 2018 Ford Focus. The contact stated while driving approximately 45 MPH, the check engine warning light illuminated. The contact continued to drive. The vehicle was taken to an independent mechanic where it was diagnosed that the emission system had failed. The canister purge valve and the vapor vent valve were replaced; however, the failure recurred while driving. The vehicle was taken back to the independent mechanic where it was diagnosed that the canister vent valve and the canister vent solenoid needed to be replaced; however, the failure persisted. The vehicle was taken back to independent who provided the same diagnostic; however, the vehicle was not repaired. The vehicle was then taken to the dealer where it was diagnosed that the canister vent valve and the canister vent solenoid needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA. The failure mileage was approximately 25,509. Vehicle had an issue with the Canister Purge Valve, canister vent solenoid and also other issues related to a recall that is on this type of vehicle. Our VIN number was not included with the recall, but it is the same thing that they are saying in the recall that happened to our Ford. The car only has 25817 miles. Warranty ran out on years but not mileage.

The contact owns a 2018 Ford Focus. The contact stated that after refueling the vehicle, the vehicle would stall after being started. The vehicle had to be started several times before being able to accelerate. The fuel gauge was occasionally inoperable. The check engine warning light was illuminated on the instrument panel. The vehicle was taken to the local mechanic which diagnosed the failure to be an evaporative emission control system. The contact related the failure to NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline). The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 61,000.

The contact owns a 2018 Ford Focus. The contact stated while driving 70 MPH on the highway, the vehicle stalled and then stopped independently. The check engine warning light illuminated on the instrument panel. The vehicle was restarted and driven safely to an independent mechanic. The vehicle was diagnosed with canister purge value failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 70,555.