2018 FORD FOCUS Complaints

This is Safety issue because vehicle stalled and check engine light comes just before Christmas. Dealer reset check engine light and a few days later the vehicle was idling rough and check engine light came on again. There have been numerous recalls over several years for this problem identified in Fords recall notice 18S32A,B,C,D,E,F,G (Oct. 25, 2018). Car was purchased on Oct 19,2018. Ford issued a Delivery Hold on Oct. 25, 2018(1 week after purchase). Returned vehicle to dealer on 12/29/2021 who'd confirmed defective evaporative emission purge valve and need for Fuel Induction cleaning for a total of $857.60 which includes a $189.95 diagnosis charge. Dealer stated that the VIN # is not on the recall list. Contacted Ford recall department on 12/29/2021 who assigned case #CAS-347-49595-X1C1F4 and told me that i would receive a call back within 24 hrs. I never received a call. In addition to the recall this part is covered under the 8/80,00 mile emission warranty. Ford's TSB 17-0050 defines the part (#BVZ-9D289-E) as Evaporative "Emission" Cannister Purge Valve

The contact owns a 2018 Ford Focus. The contact stated that while driving at 60 MPH, the vehicle stalled. The failure nearly caused a collision. The vehicle was taken to an independent mechanic and diagnosed with canister purge valve failure. The canister purge valve needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that there was no recall associated with the VIN. The contact related the failure to NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline) however, the VIN was not included in the recall. The failure mileage was approximately 92,000.

The contact owns a 2018 Ford Focus. The contact stated while stopped at a traffic light, the transmission shuddered. After the brake pedal was released, the vehicle went into reverse. There were no warning lights illuminated. The vehicle was taken to the local dealer on several occasions to be diagnosed. The contact was informed that the shifter, seals, and clutch needed to be replaced. The vehicle was repaired however, the failure recurred. The manufacturer was notified of the failure and referred the contact to another dealer for assistance. No further assistance was provided. The contact was concerned about being in a crash while driving the vehicle. The failure mileage was approximately 14,100.

The contact owns a 2018 Ford Focus. The contact stated that while operating the vehicle, the power steering assist malfunctioned, and the steering wheel was very difficult to turn in either direction. The vehicle was taken to the local dealer and was diagnosed that the steering gear was faulty and needed to be replaced. The vehicle has been repaired. The local dealer and the manufacturer were notified of the failure, but no assistance was offered. The approximate failure mileage was 25,000.

The contact owns a 2018 Ford Focus. The contact stated that upon purchase of the vehicle from an independent mechanic, the vehicle would stall at various speeds as an unknown warning light would appear on the instrument panel. The contact took the vehicle to a dealer where multiple repairs were performed on the vehicle. A year later, the contact stated that a "vehicle overheating, pull over" warning message appeared on the instrument panel. The contact had to restart the vehicle to clear the message and resume normal driving. The contact had spoken to the manufacturer and was informed that there were no recalls on the vehicle. The vehicle had yet to be repaired. The failure mileage was approximately 1,000.

Suddenly, the vehicle will stall only after it's been fueled. I've read reports of this being common in lots of Ford vehicles with it having something to do with a fuel filter or emissions. The vehicle continues to run and drive but I fear it will continue to do worse. My only option currently is to leave the vehicle running while being fueled.

The contact owns a 2018 Ford Focus. The contact stated that upon depression of the brake pedal or while at a complete stop, the vehicle would vibrate without warning. The contact had taken the vehicle to the dealer on two occasions for the failure and both times, the contact had the clutch assembly, the seal gasket, and fluid replaced. Despite the repairs, the failure returned every 20,000 miles. Recently, the failure returned, and the contact was informed that the repair would not be covered under warranty. The manufacturer had been notified of the failure but provided no assistance. The vehicle was not repaired. The failure mileage was approximately 20,000.

The contact’s mother owns a 2018 Ford Focus. The contact stated while driving 20 MPH, the brake pedal was depressed, and the vehicle started shaking abnormally while coming to a stop. The vehicle also experienced the abnormal shaking while moving off from a complete stop, whenever the accelerator pedal was depressed. The contact stated that the failure recurred several times. The vehicle was taken to the local dealer to be diagnosed. The contact was informed that the TCM (Transmission Control Module) was faulty and needed to be replaced. The contact was informed by the dealer that the part was not available for the repair. An aftermarket replacement part was ordered to facilitate the repair; however, after installing the part, it failed to fix the vehicle. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 83,000.

The contact owns a 2018 Ford Focus. The contact stated while driving at various speeds, the vehicle would stall randomly. The contact stated that the check engine warning light was illuminated. The vehicle was taken to a local dealer but was not diagnosed or repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline) however, the VIN was not included. The manufacturer was informed of the failure but offered no assistance. The failure mileage was unavailable.

The check engine light came on a week and a half ago and after having someone do a diagnostic test it sent a code saying an emissions leak somewhere. The car will sputter and sometimes will not restart after fueling and has to be revved up a bit to get it going. The scary part is when it starts to sputter when at an intersection. I called the dealership that I bought this ford focus brand new in 2018 which has 20,000 miles now and the girl answering phones at Brandon Ford Tampa Fl. said my car would not be covered for my problem under warranty. I did not know until just checking online that this was actually one of 2 recall problems with the 2018 ford focus models. Would expect a little more from what is supposed to be the number one ford dealer in the south. I was blown off. Doubt my next new car will be a ford but I am waiting to hear back from you to see if I have any recourse here. Thanks for your time. [XXX] [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).