2006 FORD FREESTAR Complaints

I AM EXPERIENCING PROBLEMS WITH MY 2006 FORD FREESTAR WHEN IT BECOMES WET. IF I GO THROUGH A CAR WASH OR DRIVE IN INCLEMENT WEATHER THE ENGINE LIGHT STARTS FLASHING AND THE ENGINE POWER STARTS BECOMING ERRATIC, BUCKING AND HESITATING. WHEN THIS FIRST STARTED HAPPENING I WOULD HAVE TO LET THE VAN SIT FOR A FEW HOURS AND THEN IT WOULD RUN FINE. THE LAST FEW TIMES IT HAS HAPPENED IT IS TAKING DAYS FOR THE MOTOR TO GET BACK TO NORMAL. I HAVE HAD IT AT A SHOP, THEY GAVE IT A TUNE UP. THE PROBLEM RECURRED AND TOOK IT TO A FORD CERTIFIED DEALERSHIP AND THEY RAN DIAGNOSTICS, CHARGED ME $100 AND TOLD ME I NEEDED A TUNE UP WHICH I JUST HAD DONE. TOOK IT BACK TO THE SHOP THAT DID THE TUNE UP AND THEY REPLACED THE EGR VALVES TO THE TUNE OF $700. RAN THE CAR THROUGH THE CAR WASH AND PROBLEM RECURS, THEY HAVE NOW REMOVED THE PCM MODULE LOOKING FOR MOISTURE WHICH THEY DID NOT FIND, ANOTHER $100. $900 LATER I AM STILL STRUGGLING WITH THE SAME PROBLEM AND NOBODY HAS ANY ANSWERS. UPON READING MANY COMPLAINTS ABOUT THIS SAME ISSUE ON THE WEB I AM NOW REPORTING IT TO YOU. FORD NEEDS TO RECALL THIS AND MAKE IT RIGHT. IT'S EXTREMELY DANGEROUS TO BE DRIVING IN INCLEMENT WEATHER AND START LOSING POWER TO YOUR CAR! WE ARE NOW HEADING IN TO THE WET WINTER MONTHS AND I'M SCARED TO DEATH TO DRIVE MY VAN. *TR

TL* THE CONTACT OWNS A 2006 FORD FREESTAR. THE CONTACT STATED THE VEHICLE FAILED TO ACCELERATE WHEN DRIVING UPHILL. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP AND THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 41,163.

VAN WAS ON CRUISE CONTROL. ENGINE REVED UP AND VAN SLOWED TO A STOP. EVEN ON MANUAL CONTROL (NOT ON CRUISE CONTROL) THE ENGINE WOULD SPEED UP, BUT THE VAN WOULD NOT MOVE. LUCKY THAT THERE WAS S SHOULDER TO STOP ON. SALE FORD SERVICE DEPARTMENT DIAGNOSED THE PROBLEM AS A TRANSMISSION DEPARTMENT. MANY, MANY PEOPLE HAVE REPORTED THIS SAME PROBLEM TO FORD MOTOR COMPANY.

AS I WAS DRIVING MY 2006 FORD FREESTAR ON A BUSY HIGHWAY, THE VEHICLE ACTED AS IF IT WENT INTO NEUTRAL AND I HAD TO COAST TO THE SIDE OF THE ROAD. THE VEHICLE WOULD NOT GO INTO FORWARD OR REVERSE GEAR AT ALL - IT WAS SIMPLY STUCK ON THE SIDE OF THE ROAD.THIS VAN HAS ONLY 69,000 MILES ON IT AND SHOULD NOT HAVE SUCH AN ISSUE AT THIS POINT! I HAVE HAD IT TOWED TO A MECHANIC WHO INFORMS ME THAT THE TORQUE CONVERTER AND POSSIBLY MORE WILL NEED TO BE REPLACED LEAVING ME OUT OF POCKET OVER $3,000.00. I HAVE RESEARCHED THIS PROBLEM AND AS I ENTERED "2006 FORD FREESTAR" INTO GOOGLE SEARCH IT SEEMS THAT THIS IS AN ONGOING PROBLEM THAT IS HAPPENING WITH THOUSANDS OF OTHER VEHICLES OF THE SAME YEAR/MAKE. WHY IS THIS NOT A RECALL FROM FORD? THIS IS A VERY DANGEROUS PROBLEM! I WAS TRAVELING AT A SPEED OF 72MPH IN HEAVY TRAFFIC WHEN THIS OCCURRED AND COULD HAVE BEEN KILLED! WHEN WILL THESE PEOPLE HAVE TO START DOING SOMETHING ABOUT THE FAULTY VEHICLES BEING MADE AND SOLD TO THE PUBLIC???? I DO NOT HAVE THE TIME OR MONEY TO REPLACE A TRANSMISSION AT 69,000 MILES ON A VEHICLE THAT OBVIOUSLY HAS A DEFECT FROM THE FACTORY! *TR

TL* THE CONTACT OWNS A 2006 FORD FREESTAR. THE CONTACT STATED THAT WATER PENETRATED THE HOOD, CAUSING THE TRANSMISSION AND THE ELECTRICAL SYSTEM TO FAIL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT WATER DAMAGED THE TRANSMISSION, INSTRUMENTAL CLUSTER, AND SMART MODULE. THE DEALER REPLACED THE TRANSMISSION. THE INSTRUMENTAL CLUSTER AND SMART MODULE WERE NOT REPLACED. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS REPLACED 105,000. THE VIN WAS UNAVAILABLE.

2006 FORD FREESTAR FAILED TO MOVE FORWARD IN GEAR WHILE DRIVING ON BUSY ROAD. THIS OCCURRED TWO DIFFERENT TIMES. MOST RECENT INSTANCE SAW ME AND MY 4 YEAR OLD DAUGHTER PLACED IN PERIL. I HAVE HAD TRANSMISSION REPLACED ONLY TO FIND THAT PROBLEMS MAY BE THE RESULT OF THE PCM FAILING AS A RESULT OF GETTING "WET" DUE TO A FAULTY SEAL ON THE BOX THAT HOUSES THE PCM. MOST RECENT INCIDENT NEARLY RESULTED IN OUR NEARLY BEING REAR ENDED BY A SEMI TRACTOR TRAILER AT 50 MPH. FORTUNATELY, I HAD THE PRESENCE OF MIND TO SHIFT TO NEUTRAL, RESTART VAN AND COAST OFF ROAD JUST AHEAD OF TRUCK. VAN STALLED AND WOULD NOT RUN. HAD TO LEAVE AT GARAGE OUT OF TOWN AND GET A RIDE HOME FOR MY AND MY 4 YEAR OLD DAUGHTER. *TR

I WAS DRIVING INTO A PARKING LOT, SLOWED MY SPEED, WHEN I PUT MY FOOT BACK ON THE GAS, NOTHING HAPPENED. THE ENGINE WOULD REV BUT THERE WAS NO MOVEMENT AT ALL. I TRIED ALL GEARS AND NONE WORKED. THIS HAS NOT HAPPENED WITH THIS VAN BEFORE. THE CAR IS BEING REPAIRED NOW. THE MECHANIC BELIEVES IT WILL BE ONE PART OF THE TRANSMISSION THAT NEEDS REPAIR AND NOT A WHOLE TRANSMISSION REBUILD. *TR

TL* THE CONTACT OWNS A 2006 FORD FREESTAR. THE CONTACT STATED THAT THE TRANSMISSION FAILED WITHOUT WARNING AND THE VEHICLE WOULD NOT ACCELERATE OR REVERSE. THE VEHICLE WAS NOT INSPECTED FOR THE FAILURE. THE CONTACT INSPECTED THE VEHICLE AND THEY THINK THE PUMP ON THE TRANSMISSION HAS FAILED. THE FAILURE MILEAGE WAS UNKNOWN, BUT THE CURRENT MILEAGE WAS 102,000.

JANUARY 2010 10:30PM WHILE DRIVING WITH MY FAMILY (HUSBAND, 2 KIDS-7/9 YRS OLD) AT 40MPH UP A STEEP HILL, THE TRANSMISSION DROPPED OUT OF DRIVE AND WOULDN'T SHIFT. ALL THERE WAS PARKL. SINCE I WAS ON A HILL I WAS ABLE TO BACK THE CAR INTO SOMEONE'S DRIVEWAY AND WAIT FOR A TOW TRUCK. TOWED IT TO THE LOCAL FORD DEALER AND WAS TOLD I NEEDED A NEW TRANSMISSION, THAT THE CURRENT ONE WAS UNFIXABLE. I SPENT $3500 ON A NEW TRANSMISSION. *TR

TL* THE CONTACT OWNS A 2006 FORD FREESTAR. THE CONTACT WAS DRIVING 30 MPH WHEN THE VEHICLE SHIFTED TO NEUTRAL WITHOUT ANY WARNING, CAUSING THE VEHICLE TO SUDDENLY COME TO A STOP AND THE CONTACT WAS UNABLE TO ACCELERATE OR CHANGE GEARS. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP WHERE THE MECHANIC DIAGNOSED THE FAILURE AS THE TORQUE CONVERTER AND ALSO ADVISED THAT THE TRANSMISSION WOULD NEED REPLACING. THE MANUFACTURER WAS CONTACTED WHO DID NOT OFFER ANY ASSISTANCE STATING THAT THERE WERE NO RECALLS ON THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 60,600.