2005 FORD FREESTAR Complaints

THE LEFT REAR CALIPER FROZE AND WORE OUT THE BRAKE AND ROTOR. THEN IN 2012 THE LEFT REAR CALIPER FROZE AND WORE OUT BRAKE AND ROTOR. AS WELL AS THE RIGHT REAR CALIPER. *TR

TL* THE CONTACT OWNS A 2005 FORD FREESTAR. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE VEHICLE STALLED AND WOULD NOT SHIFT INTO DRIVE OR REVERSE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO REPLACED THE TORQUE CONVERTER, THE BANNER KIT, AND VARIOUS OTHER COMPONENTS. THE TORQUE CONVERTER WAS REPLACED AT LEAST THREE TIMES. THE MANUFACTURER WAS NOTIFIED AND WOULD NOT OFFER ANY ASSISTANCE BECAUSE THE CONTACT INSTALLED AFTERMARKET PRODUCTS. THE FAILURE MILEAGE WAS 110,000 AND THE CURRENT MILEAGE WAS 120,000.

TL* THE CONTACT OWNS A 2005 FORD FREESTAR. THE CONTACT NOTICED THAT THE TRACTION CONTROL WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE ABS SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 49,000. THE DEALER REPLACED THE HYDRAULIC CONTROL UNIT AND ABS MODULE. UPDATED 06/22/12*JB

WAS ON A VERY BUSY HIGHWAY. THE FREESTARS DASH LIGHTS LITE UP AND WENT BACK OFF. AC CUT OFF THEN EVERYTHING STARTED WORKING AGAIN. ABOUT 30 SECONDS LATER THE FREESTAR DIED AT 65. I WAS ABLE TO COAST TO A STOP ON THE SHOULDER. AGAIN ON MAY 5 2012 THE LIGHTS STARTED FLICKERING AND THE AC STARTED TO BLOW HARD AND IT WOULD SLOW BACK DOWN THEN THE DASH LIGHTS ABS,BRAKE,BATTERY LIGHTS WOULD BLINK ON AND OFF THEN THE FREESTAR DIED AGAIN AT 70 MPH. BRAKES DIDN'T WORK I WAS GOING THROUGH A INTERSECTION AND HAD TO USE THE E BRAKE. FREESTAR HAS DONE THIS SEVERAL TIMES OVER THE LAST MONTH I JUST HIT THE HIGH SPOTS. IT HAS HAD TEST AFTER TEST AND I'M ALWAYS TOLD A DIFFERENT STORY! I JUST WANT MY VAN FIXED BEFORE SOMEONE GETS HURT OR KILLED. *TR

VEHICLE LOST ALL POWER ON I 95 IN SC DUE TO TORQUE CONVERTER. IT WAS TOWED TO FORD DEALERSHIP, WE RENTED A CAR TO DRIVE HOME TO NC, OVER 350 MILES AWAY. FINALLY AFTER 5 WEEKS, OUR VEHICLE IS NOW READY TO BE PICKED UP. HOWEVER, IT NEEDED A NEW TRANSMISSION, DUE TO METAL FLAKES IN THE TRANSMISSION. IT SEEMS EVERY CAR THAT HAS THIS PROBLEM WITH A FAILED TORQUE CONVERTER NEEDS A NEW TRANSMISSION DUE TO THE METAL FLAKES. READING THE BLOGS, TRANSMISSION SPECIALISTS ARE SAYING THAT THESE METAL FLAKES ARE FROM THE TORQUE CONVERTER WHICH IS HOUSED IN THE TRANSMISSION. FORD'S RECALL LETTERS WERE NOT SENT IN A TIMELY MANNER, WE HAD ONLY BEEN GONE FOR A WEEK ON A TRIP TO FL AND WHEN WE GOT HOME & PICKED UP THE MAIL, THERE WAS A RECALL LETTER. WE SURELY NEVER WOULD HAVE TAKEN THIS VEHICLE ON A TRIP HAD WE KNOWN THIS WAS POSSIBLE. FORD REFUSES TO PAY FOR ANYTHING. I WOULD LIKE TO SEE RESEARCH DONE AS FAR AS THE TORQUE CONVERTER AFFECTING THE TRANSMISSIONS. THANK YOU. *JS

ABS WARNING LAMP COMES ON, AS WELL AS THE POWERTRAIN MALFUNCTION WARNING LAMP, SPEEDOMETER FAILS TO REGISTER.......WAS TOLD AT LOCAL FORD DEALERSHIP THAT PCM/ CLUSTER WOULD HAVE TO BE REPLACED AT A COST OF $800-$1200... *TR ..WHEN PROBLEM BEGAN WOULD DO THIS UPON CRANKING, AND HAS GOTTEN TO THE POINT THAT VEHICLE NOW HAS THIS HAPPEN WHILE DRIVING. TRANSAXLE LIGHT IS ALSO ILLUMINATING.....WHICH JUST DISCOVERED MAY BE DUE TO PROBLEMS THAT ARE ALREADY COVERED IN ANOTHER RECALL.......VERY DISAPPOINTED IN OUR CHOICE IN THIS VEHICLE. AFTER INVESTIGATING THIS PROBLEM SEE THAT THE DESIGN FLAWS IN THIS VEHICLE SHOULD NOT BE IGNORED, THESE SYSTEM FAILURES ARE OF NO FAULT OF THE OWNERS AND CAUSE GREAT SAFETY CONCERNS TO THE OWNERS AND PASSENGERS WHO HAVE TO DEPEND ON THESE VEHICLES ON A DAILY BASIS.

VEHICLE LOST POWER WHILE DRIVING THROUGH A RESIDENTIAL AREA GOING UP A HILL. I WAS ABLE TO COAST BACKWARDS INTO A PARKING POSITION -- VEHICLE WOULD NOT GO IN FORWARD OR REVERSE. VEHICLE HAD TO BE TOWED AND TRANSMISSION REPLACED. *TR

WHEN DRIVING DOWN THE ROAD THE VAN WILL SUDDENLY LOSE ALL FORWARD MOMENTUM AND DRIFT MOMENTARILY UNTIL IT WILL JUST AS SUDDENLY RESUME FORWARD MOMENTUM AND CONTINUE LIKE NORMAL. WHEN THIS HAPPENS, THE RPMS DROP OFF LIKE THE VEHICLE IS STALLING OR FUEL STARVED (HOWEVER IT HAS NO HESITATION LIKE ITS RUNNING OUT OF GAS) NO WARNING LIGHTS COME ON AND THERE IS NO PATTERN TO WHEN OR HOW IT HAPPENS. HOWEVER, THE PROBLEM HAS BEEN GETTING PROGRESSIVELY WORSE AND NOW IT IS NOTICED THAT IT HAS A HIGHER TENDENCY TO DO IT WHEN IT IS RAINING OR THERE IS HIGH HUMIDITY. IT DOES IT AT ALL SPEEDS FROM 25MPH TO 70MPH. FORD DEALERSHIP HAS LOOKED AT THE VAN AND COULD NOT GET IT TO REPRODUCE THE PROBLEM WHEN THEY HAD IT. HOWEVER, THEY STATED THIS DOES NOT SOUND LIKE A TORQUE CONVERTER PROBLEM ADDRESSED UNDER SAFETY RECALL NOTICE 11S25/ NHTSA RECALL 12V-006. THIS IS A VERY DANGEROUS PROBLEM AND HAS ALMOST CAUSED SEVERAL ACCIDENTS AS I HAVE NO WARNING THE PROBLEM IS GETTING READY TO HAPPEN AND HAVE NO WAY TO NOTIFY OTHER MOTORIST OF MY SUDDEN AND QUICK DECELERATION. *TR

IN FEBRUARY 2012 I WENT TO FOR CHECK ENGINE LET THEY SAID IT WAS ERG VALUE. I FIX. THEN IN APRIL 14TH I WAS DRIVING DOWN FREEWAY AND MY VAN LOST ACCELERATION POWER I PUT HAZARDS ON AND MANAGE TO GET TO OTHER SIDE OF FREEWAY. MY CAR WOULD START BUT WOULD NOT GO IN FORWARD OR REVERSE. I HAD TO THEN GET TOWED SINCE WAS THEY WEEKEND AND I WAS THE MIDDLE OF NO WHERE I TOWED TO HOME. ALSO, THE WEEKEND NO FORD DEALERS/ SERVICE CENTERS ARE OPEN. *TR

THE VEHICLE FIRST LOST POWER AT 50 MPH BEGINNING 12/12/2011. THE VEHICLE WOULD NOT ACCELERATE ABOVE 50 MPH. TWO MECHANICS CHECKED THE VEHICLE AND SUSPECTED A TRANSMISSION TORQUE CONVERTER PROBLEM OR AN IGNITION SYSTEM COIL FIRING PROBLEM. THERE WAS NO OTHER INDICATION OF A TRANSMISSION PROBLEM SO I HAD THE IGNITION COIL, WIRES AND PLUGS REPLACED AT A COST OF $780 ON 1/13/2012. THE VEHICLE REMAINED DRIVABLE WITH THAT SERVICE. ON 2/24/2012 I WAS DRIVING IN NORMAL IN-TOWN TRAFFIC. DURING A RIGHT HAND TURN IN HEAVY TRAFFIC I LOST ALL FORWARD AND REVERSE POWER IN THE TRANSMISSION. I COULD NOT CONTROL THE VEHICLE'S FORWARD OR REVERSE POWER. THIS OCCURRED IN HEAVY TRAFFIC WITH NO SHOULDER OR DRIVEWAY AVAILABLE. I WAS STRANDED IN THE RIGHT HAND LANE OF TRAFFIC. I FELT EXTREMELY UNSAFE, TURNED ON THE VEHICLE'S HAZARD FLASHERS AND LEFT THE VEHICLE BECAUSE I WAS CONCERNED IT WOULD BE HIT AND CAUSE AN ACCIDENT, UNTIL THE TOW TRUCK ARRIVED. I HAD THE VEHICLE TOWED TO THE SHOP WHICH PERFORMED THE EARLIER IGNITION REPAIR WHO INFORMED ME THE PROBLEM WAS AN INTERNAL TRANSMISSION PROBLEM THEY COULD NOT SERVICE. I THEN HAD THE VEHICLE TOWED TO A HEAVY MECHANICAL SHOP WHICH RECOMMENDED A REBUILT TRANSMISSION AT A COST OF $3,200. I THEN HAD THE VEHICLE TOWED TO A TRANSMISSION SHOP WHICH REBUILT THE TRANSMISSION ON 2/24-4/1/2012 AT A COST OF $2,142. I RECEIVED THE SAFETY RECALL NOTICE 11S25 / NHTSA RECALL 12V-006 FROM FORD DATED MARCH 2012 ON 4/2/2012, MAILED ON 3/29/2012. IN ADDITION TO THE DANGER AND COST THIS DEFECT CAUSED ME, I AM UNSURE IF THE REPLACEMENT TRANSMISSION TORQUE CONVERTER IS ANY BETTER THAN THE ORIGINAL TRANSMISSION TORQUE CONVERTER, SINCE FORD STATES IN THE SAFETY RECALL NOTICE THAT REPLACEMENT PARTS ARE NOT CURRENTLY AVAILABLE.