2004 FORD FREESTAR Complaints

I WAS STOPPED AT A RED LIGHT. I THEN PROCEEDED TO CROSS THE INTERSECTION WHEN THE LIGHT TURNED GREEN AND MY VAN JUST STOPPED WITHOUT ANY WARNING. HAD IT TOWED AND WAS TOLD I NEEDED A NEW TRANSMISSION AND TORQUE CONVERTER. *TR

2004 FORD FREESTAR. CONSUMER STATES THAT THE PARTS FOR THE TORQUE CONVERTER OUTPUT SHAFT RECALL ARE NOT AVAILABLE. *KB THE CONSUMER STATED HE EXPERIENCED LOSS OF POWER WHILE DRIVING. *JB

REQUEST UPDATE STATUS ON SAFETY RECALL NOTICE 11S25 NHTSA RECALL 12V-006, WORN SPINES IN TRANSMISSION TORQUE CONVERTER. I CONTACTED FORD CUSTOMER RELATIONSHIP CENTER PER THEIR MARCH 2012 RECALL LETTER. I WANT TO TAKE MY 2004 FREESTAR TO A LOCAL SAN ANTONIO DEALER TO IMPLEMENT THIS RECALL BEFORE ANY FATAL ACCIDENTS OCCUR WITH MY VEHICLE. FORD REPRESENTATIVE STATED THEY HAD UNTIL 2ND QUARTER 2012 TO BEGIN THIS RECALL. MY LOCAL DEALERS REFUSE TO EVEN CHECK MY TRANSMISSION OR ORDER REPLACEMENT PARTS UNTIL THEY RECEIVE A SECOND LETTER FROM FORD CORPORATE HEADQUARTERS. BECAUSE IT IS NOW 3RD QUARTER 2012, FORD MOTOR COMPANY IS IN NON-COMPLIANCE WITH YOUR RECALL. IF POSSIBLE, PLEASE PROVIDE ME WITH AN UPDATE STATUS (IF ANY) ON THIS RECALL AND NOTE THE INACTION AND INSENSITIVE RESPONSE BY FORD MOTOR COMPANY REGARDING THIS VITAL SAFETY RECALL. THANK YOU FOR YOUR TIME AND ASSISTANCE. *TR

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. THE CONTACT STATED THAT THE REAR WHEEL WELLS WERE COMPLETELY RUSTED. THE VEHICLE WAS TAKEN TO THE DEALER TO BE REPAIRED AND THE CONTACT WAS INFORMED THAT THE DEALER WOULD NOT TOUCH THE VEHICLE TO AVOID THE LIABILITY. THE RUST HAD DAMAGED THE LUGS FOR THE SEAT BELT ANCHORS. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 120,000.

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. THE CONTACT STATED THAT HE RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER 12V006000 (POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER). AN AUTHORIZED DEALER WAS NOTIFIED AND THE CONTACT WAS INFORMED THAT THE PARTS NEEDED TO COMPLETE THE RECALL REPAIR WERE NOT AVAILABLE AND POSSIBLY WOULD NOT BECOME AVAILABLE FOR APPROXIMATELY THREE YEARS. THE MANUFACTURER WAS NOTIFIED AND PROVIDED NO ASSISTANCE. THE CONTACT STATED THAT THE PARTS WERE SUPPOSED TO BE AVAILABLE AT THE CURRENT TIME AND WAS NOT BEING HONORED WITHIN A REASONABLE TIME FRAME. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 08/08/2012 *JS

UPON EXITING THE FREEWAY ONTO SECONDARY STREET THE VEHICLE STALLED OUT COMPLETELY. WE LOST ALL DRIVING FUNCTION, POWER STEERING ETC IN AN INSTANT. LUCKILY IT WAS LATER IN THE EVENING AND NOT MUCH TRAFFIC WAS BEHIND US AS THIS ROAD IS TYPICALLY VERY CONGESTED. WE WERE ABLE TO GLIDE INTO A TURN LANE AND OFF OF THE MAIN ROAD. THE VEHICLE WOULD NOT START AND HAD TO BE TOWED. LOCAL FORD DEALER CONCLUDED THE PCM SHORTED OUT AND THERE WAS A BLOWN IGNITION COIL. WE HAD CAR TOWED FOR SECOND OPINION AS WE COULD NOT BELIEVE THAT AT 40,000 MILES THE ENTIRE COMPUTER THAT CONTROLS THE ENGINE WOULD SHORT FOR NO APPARENT REASON. OUR REGULAR AUTO SHOP AGREED THAT THE PCM HAD SHORTED CAUSING IGNITION COIL TO FAIL AND BOTH HAD TO BE REPLACED RESULTING IN $1200 IN FEES/SERVICES AND A WEEK WITHOUT OUR VEHICLE SINCE THE PART (ACCORDING TO THE SERVICE SHOP) SHOULD NEVER GO BAD AND THEY DON'T KEEP THEM IN STOCK. WE FEEL AS IF FORD SHOULD BE HELD RESPONSIBLE FOR THEIR FAULTY MANUFACTURING AS WE DID NOTHING TO AID IN THE FAILING OF THIS PART AND MINIMAL MILEAGE/ WEAR AND TEAR HAS OCCURRED TO THE VEHICLE. WE WERE MERELY A FAMILY DRIVING HOME (WITH TWO TODDLERS) FROM A FATHER'S DAY DINNER WHO ENDED UP AT SIGNIFICANT SAFETY RISK WHEN OUR VAN JUST STOPPED MOVING, THANK GOODNESS FOR THE SLOW TRAFFIC FLOW THAT EVENING! *TR

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THERE WAS SEVERE HESITATION AND THEN IMMEDIATELY THE TRANSMISSION COMPLETELY LOSS POWER. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE TECHNICIAN REPLACED THE TORQUE CONVERTER UNDER THE NHTSA CAMPAIGN ID NUMBER 12V006000 (POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER). TWO WEEKS AFTER THE REPAIR WAS PERFORMED, THE TRANSMISSION WOULD NOT FUNCTION IN THE REVERSE GEAR. THE VEHICLE WAS TAKEN BACK TO THE DEALER BUT THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 95,000. THE VIN WAS NOT AVAILABLE. UPDATED 8/6/12 *CN UPDATED 08/16/2012 *JS

WE WERE RETURNING HOME FROM WEEKEND TRIP WHEN I NOTICED RUBBING NOISE AND HOT RUBBER SMELL COMING FROM REAR OF VAN. TWO CHILDREN IN REAR SEAT SAID SEAT WAS VIBRATING BADLY. I AM A STATE CERTIFIED MASTER MECHANIC SO I PULLED OVER TO INVESTIGATE. I FOUND THAT BOTH REAR SEAT STRIKERS HAD RUSTED LOOSE AND THE SEAT PUSHED THE METAL AND STRIKER AGAINST THE LEFT REAR TIRE. I FEEL THIS COULD HAVE BEEN A VERY DANGEROUS SITUATION IF THE METAL RUBBING ON THE TIRE HAD CAUSED A BLOWOUT. THE CHILDREN IN THE REAR SEAT COULD HAVE BEEN SERIOUSLY INJURED FROM THE TIRE AND FROM THE SEAT NOT BEING SECURED. *TR

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. THE CONTACT STATED THAT THE VEHICLE WAS USED AS A TAXI AND A CUSTOMER COMPLAINED THAT THE REAR SEATS WERE LOOSE. THE CONTACT THEN NOTICED THAT THE REAR SEATS WERE OUT OF PLACE AND THE REAR DRIVER'S SIDE WHEEL WELL WAS RUSTED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR REPAIR SHOP FOR REPAIR. THE MANUFACTURER WAS NOTIFIED AND REFERRED THE CONTACT TO NHTSA. THE FAILURE AND CURRENT MILEAGES WERE 269,359.

3RD ROW SEAT WOULD NOT LATCH ON THE DRIVER SIDE OF THE VEHICLE. UPON INSPECTION, IT WAS DETERMINED THAT THE ANCHOR USED TO ATTACH THE SEAT HAS COMPLETELY RUSTED AND IS NO LONGER FUNCTIONING. THE RUST IS FROM THE TIRE WELL AND THE TIRE IS VISIBLE FROM INSIDE THE VEHICLE. THE 3RD ROW SEAT IS NOW UNUSABLE AND UNSAFE. *TR