2004 FORD FREESTAR Complaints

TORQUE CONVERTER OUTPUT SHAFT FAILURE THE TORQUE CONVERTER OUTPUT SHAFT MAY FAIL, RESULTING IN A SUDDEN LOSS OF MOTIVE POWER WITH NO WARNING. VEHICLE WAS IN MOTION AND JUST STOPPED WORKING ON CITY STREET.

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. AFTER SWITCHING FROM REVERSE INTO DRIVE, THE VEHICLE WOULD NOT ACCELERATE PROPERLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. CLASSIC FORD OF SMITHFIELD (1698 E. BOOKER DAIRY RD, SMITHFIELD, NC) AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 53,535. THE VIN WAS INVALID.

TORQUE CONVERTER OUTPUT SHAFT ,,,, NO WAY FOR MOTOR TO ENGAGE THE TRANSMISSION ,, VAN ENGINE RUNS BUT NO POWER TO TRANSMISSION TO MOVE THE DRIVE TRAIN OF VAN ... DRIVING ON THE HIGHWAY ,, TAKE EXIT STOP FOR RED LIGHT , LIGHT TURNS GREEN PRESS GAS PEDAL ENGINE REVS UP BUT NO POWER TO TRANSMISSION TO MOVE FORWARD ... SETTING IN MIDDLE OF TRAFFIC STRANDED ,,, CARS TRUCKS ZOOMING BY ,,, TERRIBLE PREDICAMENT...

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. THE CONTACT STATED THAT THE BACK SEAT NEAR THE REAR WHEEL WELL BECAME DETACHED AND THE CONTACT SMELLED AN EXHAUST ODOR. THE CONTACT STATED THAT THE VEHICLE EXHIBITED THE SAME SYMPTOMS AS LISTED IN NHTSA CAMPAIGN NUMBER: 13V081000 (SEATS). THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 168,867.

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. WHILE REVERSING INTO THE GARAGE, THE VEHICLE FAILED TO GO FORWARD OR BACKWARD. THE CONTACT NOTICED A PILE OF RUST ON THE GROUND AND REALIZED THAT THE REAR OF THE VEHICLE WAS ENTIRELY CORRODED. THE VEHICLE WAS TAKEN TO LIBERTY FORD OF MAPLE HEIGHTS (5500 WARRENSVILLE CENTER RD, MAPLE HEIGHTS, OH 44137, (216) 662-3673) WHERE IT WAS DIAGNOSED THAT THE THIRD ROW SEAT LATCH STRIKER MOUNTING BRACKETS WERE CORRODED THROUGH AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 13V081000 (SEATS). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. WHILE CLEANING THE VEHICLE, THE CONTACT FOUND THAT THE REAR WHEEL WELL AND THE THIRD ROW SEAT LATCH THAT WAS ATTACHED TO THE VEHICLE'S SUBFRAME WERE CORRODED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 13V081000 (SEATS). THE FAILURE MILEAGE WAS 142,019.

MY 2004 FREESTAR OVERHEATS AFTER 70 MPH. REPLACED THERMOSTAT AND FANS. DOES THIS WITH AC TURNED OFF. I TURN TO HEAT ON TO COOL IT DONE. I DROVE 2100 MILES WITH WINDOWS DOWN. THIS HAPPENS ON THE HIGHWAY AND GOING UP LONG STEEP GRADE.

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. WHILE THE VEHICLE WAS IN FIRST GEAR, IT HESITATED WITHOUT WARNING WHEN ACCELERATING. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 150,449.

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A LOSS OF POWER WITHOUT WARNING. INTERSTATE FORD (125 ALEXANDERSVILLE RD, MIAMISBURG, OH) STATED THAT THERE WERE NO RECALLS ATTRIBUTED TO THE VIN. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE HAD BEEN PREVIOUSLY REPAIRED PER NHTSA CAMPAIGN NUMBER: 12V006000 (POWER TRAIN). NO FURTHER ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. WHEN THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR AN INSPECTION, THE VEHICLE FAILED THE INSPECTION DUE TO EXCESSIVE CORROSION OF THE FRONT FRAME. THE CONTACT CALLED L. B. SMITH FORD-LINCOLN, INC. AT 717-761-6700 (LOCATED AT 1100 MARKET ST, LEMOYNE, PA 17043) WHERE IT WAS DIAGNOSED THAT THE FRAME NEEDED TO BE REPLACED. THE CONTACT TOOK THE VEHICLE TO TWO DIFFERENT INDEPENDENT MECHANICS TO OBTAIN SOME ESTIMATES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER STATED THAT THERE WAS NO RECALL AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 118,000.