2004 FORD FREESTAR Complaints

EVERYTIME I STOP AT EITHER A STOPLIGHT OR STOP SIGN IT STALLS OUT. THE BATTERY LIGHT COMES ON AND THEN GOES BACK OFF. I AM ABLE TO RESTART IT BACK UP AND CONTINUE IT ON. I HAVE HAD THE ELECTRICAL COMPUTER FIXED AND HAD A FULL TUNE UP DONE AND IT STILL STALLS OUT.

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. THE CONTACT STATED THAT THERE WAS AN ABNORMAL NOISE ASSOCIATED WITH THE TORQUE CONVERTER. THE VEHICLE WAS NOT DIAGNOSED BY AN INDEPENDENT MECHANIC OR A DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE. *BF UPDATE 8/23/18*JB

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY SERVICED PER NHTSA CAMPAIGN NUMBER: 12V006000 (POWER TRAIN). WHILE DRIVING 30 MPH, THE VEHICLE LOST POWER TO THE DRIVE TRAIN. THE VEHICLE WAS TAKEN TO EIDE FORD (800 E BISMARCK EXPY, BISMARCK, ND 58504) WHERE IT WAS DIAGNOSED THAT THE TORQUE CONVERTER FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DECLINED TO ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 130,999.

WENT TO INVESTIGATE THE WATER LOGGED CARPET IN THE REAR OF THE VAN. REMOVED INTERIOR PLASTIC PANELS ON DRIVERS SIDE OF VAN. THE SEAT ANCHOR MECHANISM FELL OUT OF THE WHEEL WELL UNTO THE TIRE. VERY FORTUNATE I WAS IN THE GARAGE AND NOT TRAVELLING DOWN THE FREEWAY.

I JUST PURCHASED THIS VEHICLE TODAY. ONCE I DROVE ON THE HIGHWAY TO GET HOME THE TRANSAXEL WARRING LIGHT STARTED FLASHING. AS I LOOKED THAT UP I FOUND THAT THERE WAS A RECALL FOR TORQUE CONVERTER OUTPUT. AS I READ THINGS I SEEN OTHERS HAD SAME ISSUE AND IT WAS THIS THAT CAUSED THE ISSUE.

WHILE DRIVING MY 2004 FORD FREESTAR MINIVAN, AT APPROXIMATELY 45MPH (MILES PER HOUR), THE VEHICLE BEGINS TO SHUDDER AS IF I AM DRIVING OVER RUMBLE STRIPS AND WHEN CLIMBING SLIGHT OR STEAP INCLINED HILLS THE SHIDDER WORSENS. I PURCHASED THE VEHICLE ISED FROM A CAR LOT. I HAVE MOTICED THAT ALL OF THE FORD FREESTAR ROUMS STATE THAT THERE IS A RECALL ON THE TORQUE CONVERTER. I LOOKED UP MY VINFOR RECALLS AND IT STATES THAT THERE ARE NO RECALLS FORNMY VEHICLE. I WONDER IF THE ORIGINAL RECALL HAS ALREADY BEEN TAKEN CARE OF BY THE PREVIOUS OWNER AND THE REPLACEMENT PART IS FAULTY AS THE MS.AZOSE V. FORD MOTOR COMPANY CLASS ACTION LAWSUIT STATES IT IS. ANY INSIGHT ON THIS MATTER WOULD BE EXTREMELY HELPFUL. THANKS

WHILE IN MOTION THE VEHICLE TRANSAXLE LIGHT COMES ON. THE VEHICLE STICKS IN FIRST GEAR WHILE IN MOTION OR IT SLIPS FROM THE STATIONARY POSITION AND WHEN IN REVERSE. THE TRANSMISSION SHOP STATED IT WAS THE TORQUE CONVERTER.

THE VEHICLE LOSES POWER AS I AM DRIVING IT ON A CITY STREET. IT ALSO HAPPENED ON THE HIGHWAY, SO I DON'T USE THE HIGHWAY ANYMORE BECAUSE OF THE LOSS OF POWER.. WHEN THE SPEEDOMETER NEEDLE GOES OVER 2 RPM , IT STALLS EVEN MORE AND JERKS.

IT WAS RAINY DAY AND MY WIFE WAS PICKING MY DAUGHTER FROM SCHOOL. IT HAPPENED IN THE SCHOOL ZONE. THE CAR WAS IN MOTION. KIDS CROSS ROAD AS IT WAS END OF SCHOOL DAY. SAFETY OF PASSENGERS AND OTHER PEOPLE WAS IN DANGER. I HAVE REPLACED IN FEB 2016 CONTROL UNIT AND HCU SPENDING $2400 +. AT THAT TIME IT HAD ENGINE LIGHT ON. IT HAS AGAIN CAME BACK ON 10/24/2017. JUST TO NOTE, IN 2010, SPEND $1600 + ON THE CAR BECAUSE OF ISSUES IN THE VEHICLE. HAD ABS LIGHT ON, NORMAL DRIVING. THE CAR HAS ONLY AROUND 45000 MILES. RAIN WATER IS CAUSING ISSUES. IF GOOGLE SEARCH DONE "FORD FREESTAR CHECK ENGINE LIGHT AFTER RAIN", IT HITS LOTS OF RESULTS. FORD KNOW THE ISSUES. FORD EVEN HAD FOLLOWING SERVICE BULLETIN. TECHNICAL SERVICE BULLETIN (TSB 06-14-10.) THESE MINIVANS ARE SAFETY HAZARDS. WHAT WOULD IT TAKE TO GET SOMETHING DONE, RECALL OR GET THESE MINIVANS OFF ROADS ? FORD IS NOT TAKING RESPONSIBILITY. PLEASE FORCE THEM TO OWN THE RESPONSIBILITY WHICH THEY ARE NOT WILLINGLY TAKE. I HAVE DOCUMENTS FOR THE REPAIR THAT WAS DONE. IN 2016, WHEN CHECK ENGINE LIGHT WAS ON, I WAS ON HIGHWAY DRIVING 50 MILES AN HOUR AND IT WAS RAINY. CAR WAS SHAKING AND SEEMED LIKE LOSING POWER. THANKS, ANIL

LIKE MANY OTHERS WHO HAVE COMPLAINED ABOUT ELECTRICAL PROBLEMS ON THE FORD FREESTAR, I HAVE TO ADD MY COMPLAINT REGARDING MY 2004 FORD FREESTAR. FIRST OF ALL, WHEN I BOUGHT MY VAN USED ABOUT 4 YEARS AGO, I DID RESEARCH ON IT, AND LEARNED ABOUT THE ISSUE OF WATER GETTING INTO THE PCM. SO I TOOK THE VAN TO A FORD DEALERSHIP - CAMPBELL FORD IN NILES MICHIGAN - AND ONE OF THEIR MECHANICS DRIED AND SEALED THE PCM, ALONG WITH THE AREA AT THE BASE OF THE WINDSHIELD THAT IS PRONE TO LEAK. THAT WAS TWO YEARS AGO (THIS VAN ALSO HAD THE TORQUE CONVERTER WORK DONE BY THE PREVIOUS OWNER). SO HERE'S THE PROBLEM I'M HAVING NOW: WHEN DRIVING, OCCASIONALLY FOR NO APPARENT REASON, MY RADIO GOES DEAD, NO TIME, NO DISPLAY, NO MUSIC, AND THEN THE BRAKE AND ABS LIGHT APPEAR ON THE DASH, ALONG WITH THE BATTERY LIGHT AND AIRBAG LIGHT. THIS LASTS FOR A FEW SECONDS, AND THEN EVERYTHING RETURNS TO NORMAL (SOMETIMES THE BATTERY LIGHT STAYS ON PERMANENTLY). WHEN THIS HAPPENS I LOSE NO POWER AND THE VAN DRIVES LIKE NORMAL. THAT MIGHT OCCUR 4 - 5 TIMES / OUTING. I REPLACED THE BATTERY A FEW DAYS AGO AND THIS HAS MADE NO DIFFERENCE.