2020 FORD FUSION Complaints

The contact owns a 2020 Ford Fusion. The contact stated the vehicle was started and the check engine warning light illuminated. The contact had taken the vehicle to an independent mechanic where it was diagnosed and determined that there was coolant intrusion into cylinder #2, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not informed of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 68,000.

The contact owns a 2020 Ford Fusion. The contact stated while driving at an undisclosed speed, the front passenger's side low beam headlight failed to illuminate as needed. Upon inspecting the vehicle, the contact noticed that the front passenger's side low beam headlight assembly wiring harness was burnt, and there was light smoke coming from the wiring harness. The vehicle was taken to the local dealer, where it was diagnosed that the low beam headlight assembly needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 53,000.

The contact owns a 2020 Ford Fusion Hybrid. The contact was unable to charge the vehicle. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact called another local dealer, Ford of Smithtown (440 Middle Country Rd., St. James, NY 11780). The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The manufacturer offered a buyback. The failure mileage was approximately 45,541. Parts distribution disconnect.

The contact owns a 2020 Ford Fusion. The contact stated that while operating the vehicle, there was a ticking and knocking sound coming from the engine compartment. The vehicle was taken to the local dealer. The cause of the issue was not yet determined. The manufacturer was not contacted. The failure mileage was 79,000.

There was a recall on 2020 Ford Fusions in 2022 on flex plate. My car miles at 90,000 and I started to hear the ticking noise. I did my research and I seen that it has the same noise that my car is making now. I called the dealership and the dealership said that I had no active recalls on my car and that the recall was specific to certain cars. Even though my car wasn’t apart of the specific VIN. I had a mechanic check it out and it was the flex plate. I’m still having issues with my flex plate but they want me to come out of pocket , I never had a engine light or anything come on I just started hearing this loud noise and it progressively has gotten worse.

On Saturday, October 5th, 2024, at around 5AM I was sitting in the Starbucks parking lot outside of the Detroit Metro (DTW) airport when this issue began. I had just started my car and could feel it was sluggish and was making a significant amount of noise, which was present in park and neutral, but not so much while in gear, unless I was stopped at a stop sign or stationary. After getting home, and each day after when I started the vehicle to go to work, I could hear that the noise was progressively getting worse. So, I determined that it was not a fluke and took my car into a Ford dealership to have the oil changed and a full inspection done. They explained to me that the water pump had failed and was leaking, very slowly, but externally through the "weep hole". They were going to charge me $1,300 to repair. So, I called a local shop that I know is reputable and they confirmed the water pump leak but determined that the noise I was hearing was not the water pump, but actually a cracked flexplate. The noise originated near the starter, and the shop ran a camera through the inspection hole confirming this. After I found that the flexplate was cracked, I did not continue to drive it, but scheduled a repair to begin on Thursday, October 24th at the reputable shop I mentioned above. To complete the repair, they needed to drop the cradle, remove the transmission and support the engine. This in total cost me $1,729.60. The flexplate has not been inspected by the mfg., police, insurance, etc., as there was no need. I did not have an extended warranty and though my car is only 4 years old, it was beyond the warranty in miles. No lights appeared on the dash, and there were no error codes present. The flexplate cracking could have resulted in catastrophic failure of the engine or transmission, and I could have very well lost control of my vehicle. If I was driving on the highway during a failure, my safety as well as others would have been put in serious danger.

The contact owns a 2020 Ford Fusion. The contact stated that the hood latch was no longer functioning and the hood was not able to be raised. The contact stated that he had taken the vehicle to an independent mechanic who was unable to repair the failure. The manufacturer was informed of the failure and referred to the NHTSA Hotline. The failure mileage was approximately 103,000.

THE COMPONENT THAT HAS FAILED IS THE FLEXPLATE, TRANSMISSION FLUID PUMP, AND TORQUE CONVERTER. IT WAS EVALUATED BY FORD AND CONFIRMED THAT IT IS THE SAME ISSUE AS A PREVIOUS CSP THAT FORD ISSUED IN 2022/23, BUT I WAS NEVER NOTIFIED OF THE ISSUE. NO LIGHTS OR WARNINGS PRIOR TO THE ISSUE. IT BECAME NOTICEABLE ON OR AROUND 9/20/24.

The contact's husband owns a 2020 Ford Fusion. The contact stated that immediately after her husband had left the dealer after an oil change, the "Stop Safely Now" and "Check Engine" messages appeared on the instrument panel after an attempt to start the vehicle. Several attempts were made to restart the vehicle; after the vehicle was started, the vehicle was taken back to the dealer. The vehicle was scanned; however, the dealer failed to duplicate the DTC code received on the scanner. The battery was reset, and the messages were cleared off the vehicle. The contact stated that several days later, the contact's husband received a "Battery Preserve Mode" message through the Ford App about the vehicle. The following day, the contact's husband experienced the failure that had occurred after the oil change. The contact stated that after a successful restart of the vehicle, the messages disappeared. The contact called the manufacturer and was informed about NHTSA Campaign Number: 23V440000 (Electrical System) which the agent linked to the vehicle failure; however, the contact was then informed that the vehicle was not included in the recall. The vehicle was not repaired. The failure mileage was approximately 54,000.

The contact owns a 2020 Ford Fusion. The contact stated while driving 30 MPH, the vehicle hesitated and stalled while depressing the accelerator pedal. The check engine warning light was illuminated. The dealer was contacted and notified of the failure. The vehicle was diagnosed with an internal engine failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 65,000.