2015 FORD FUSION Complaints

My backup camera has started to glitch like the other 2015 fords that are in recall. The screen will get green lines through it, go black, flip horizontal/vertical, flash on and off, it creates more of a distraction than assistance and makes it very hard to back in/out of tight spaces. I have not taken it to the dealership. Right before the other recall was released I called the dealership and told me I’d have to get a whole new camera installed and pay out of pocket. Has not been inspected No warnings or other symptoms prior

The trunk of the car randomly opens even when in motion sometimes enough to block my rear window and often when I can’t safely pull over right away. This keeps happening over and over. It is not just one incident on one day but multiple incidents over multiple days.

The contact owns a 2015 Ford Fusion. The contact stated while driving at an undisclosed speed, there was heavy white smoke coming from the exhaust pipes before the vehicle shut off unintendedly. The contact stated that there was a leak coming from the catalytic converter and the check engine warning light was illuminated. The vehicle was taken to an independent mechanic who discovered a blown head gasket due to coolant intrusion into the cylinders. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that there were no recalls on the vehicle. The contact was provided a case number and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 134,000.

The vehicle exhibited sudden loss of steering. Broken bolts on steering rack were discovered and vehicle was taken to dealer. Dealer bluespringsford.com refuses to fix vehicle under recall.

The engine (1.5L EcoBoost) has suffered a failure due to coolant intrusion into cylinder 3, which has led to repeated engine misfires. Trouble codes P0303 (misfire cylinder 3) and P0316 (misfire on startup) were found. The vehicle is currently available for inspection, and a diagnosis was performed by two Ford-certified mechanics using a borescope, confirming the presence of coolant in the combustion chamber. The misfires cause rough running, hesitation, and potential stalling, especially during startup and acceleration. This creates dangerous situations in traffic, such as loss of power while merging or crossing intersections, increasing the risk of a collision. Both technicians concluded the engine has coolant intrusion and recommended a short block replacement as the only viable fix. I was quoted approximately $10,000 for the repair. The vehicle has been inspected by the manufacturer (Ford), but despite acknowledging this is a known issue with the 1.5L EcoBoost engine in various Ford models, they are unwilling to assist with covering the cost of the repair in my case. The Check Engine Light initially came on intermittently and then became constant. Symptoms such as engine misfires, rough idling, and hard starts appeared around the same time, several weeks ago, and have progressively worsened since.

To keep it short. This is 1 of 3 Ford vehicles that I had to pay to have every lug nut replaced! They are 'swollen' is the term used. Prior to this, I replaced 1 lug in my 45 year driving history and that was because it broke off. I have called Ford and Lincoln and they are aware of the problem but say there is not program in place for a resolution. My complaint was escalated I was told. Hahaha. Their hand needs to be forced. They are not going to willingly do the right thing going forward nor address refunds! They have 'escalated' all 3 of my issues. I would imagine that there is a fourth coming at some point when my daughters car needs to go into the shop. $250+ a car is a joke and an expense nobody needs. Please help. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

In March of 2022 the engine failed on the vehicle. When I took it in for repairs, at the dealership where we purchased the car, I was told the engine needed to be replaced because coolant had leaked into the motor. I was told when the repairs were made I would not have this problem anymore. Three years later the same issue has occurred again and I took the vehicle back to the same dealer. This time they are trying to blame maintenance; saying there is sludge in the motor. The problem with this is the oil was recently changed (within 3500 miles) and the mechanic at the dealership did not identify any sludge or coolant in the oil. The dealership was told by the service engineer not to repair the motor. I looked on line and there reddit forums from people across the country having the same problem. What they are saying is the same thing the dealer told me. Ford is blame the customer claiming lack of maintenance. This is just a talking point because what everyone is being told is the same. Ford needs to be place under investigation. Law suits against Ford are documenting Ford knew the ecoboost engines had defects from the start and do not have a way to fix the design flaw and are refusing to make amends. Additionally these lawsuits are documenting the band aid repairs Ford is doing is simple to push the problem off and later not claim responsibility when the same malfunction occurs. The owners of Ford cars with ecoboost engine are out tens of thousands of dollars and have endure hardship inflicted by Ford that go beyond the vehicle damages. Ford should be placed under federal investigation and I believe it is possible criminal conduct may have occurred given the position Ford has taken in and its continued failure to make amends.

The contact owns a 2015 Ford Fusion. The contact stated that while driving at an undisclosed speed, there was an engine misfire. Additionally, the vehicle stalled and lost motive power. No warning light was illuminated. The contact stated that after several attempts, the vehicle restarted. The vehicle was driven to the residence. The contact stated that an independent mechanic inspected the vehicle and became aware of white smoke coming from the exhaust pipe. The vehicle was diagnosed with coolant intrusion and engine failure. The vehicle was not repaired. The dealer was made aware of the failure. The manufacturer was made aware of the failure. The failure mileage was approximately 149,000.

The contact owns a 2015 Ford Fusion. The contact stated that coolant would evaporate from the engine without warning. The contact stated that no warning lights or visible signs of a leak were present. The vehicle was taken to an independent mechanic and the mechanic was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was provided a case number. The contact was then referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 90,000.

Over the course of 3 weeks I started to notice a strong smell of gasoline after filling my fuel tank that lasted for about the first quarter of the tank. I did look around the car and under it to see if I could observe a leak, but saw nothing upon visual inspection. After about 3 weeks I observed a very strong smell of gasoline when I walked out to the car in the morning and observed gasoline on the rim of the passenger side tire as well as on the ground by the tire. At that point I looked up recalls on the 2015 fusion and did find one on the fuel system but was advised that it is not active on my vin. I took my car to a local shop where they found that both fuel senders were wet and leaking thus causing the fuel leak.