2020 FORD FUSION Complaints

The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The center console display unit acts as though "ghost fingers" (internet term) are continuously exercising the display, since at least December 2023. If on climate, it will turn the climate controls on and off, and if on phone, it will attempt to delete phone contacts. The only screen that is safe to leave the display at, is navigation, so that it continually flickers and moves the map around the state, country and world. I cannot turn off the steering heater, or change climate direction to vent or floor without accessing the climate screen while driving. I have had to unpair my phone, and so 911-assist is no longer available. Periodically while driving, the screen will switch over to climate controls, and then I have to switch it back, pressing navigation multiple times until it responds, while driving. These actions make driving the vehicle UNSAFE. The dealer acknowledged an internal bulletin in January, that said a software update was needed to address this known issue, but none was available. They have been unwilling to provide any of that in writing. Please contact me for a 165Mb video of the the screen, which includes my attempts to access screen functions.

The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2020 Ford Fusion. The contact stated that while starting the vehicle, there was a rattling noise coming from the front end near the driver’s side close to the transmission. The vehicle would start moments after the failure had occurred. The rattling was more pronounced while the A/C system was running. The contact stated that while depressing the accelerator pedal, the rattling sound was noticeable. Additionally, while driving at various speeds, the transmission felt as though it was slipping while changing gear. The contact stated that while inspecting the engine, underneath the hood was hotter than normal. The check engine warning light was illuminated. The vehicle had been taken to the dealer where it was diagnosed that the transmission flex plate had failed. The failure was linked to NHTSA Campaign Number: 10218899 (Power Train). The vehicle had not been repaired. The manufacturer was made aware of the failure, and it was confirmed that the VIN was not under recall. The contact was referred to the NHTSA Hotline to file a complaint. The failure mileage was 117,000.

The contact owns a 2020 Ford Fusion. The contact stated while operating the vehicle, there was a loud knocking sound coming from the engine compartment and the battery had failed. The vehicle was taken to the local dealer who diagnosed that the transmission flex plate had failed. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 102,864.

I am aware of the recall on the ford fusion plug in hybrid and for that reason I do not plug it in. We are supposed to use this as a regular hybrid until the fix comes out. That said, my car turns off randomly in traffic. All the warning lights turn on and the car fully shuts down and has to restart. This happens without warning, while in traffic. Last week it happened 3 times on one single drive home from picking up the kids from school. This is not supposed to happen if we aren’t plugging it in, but it’s happening and ford said they think it’s related to the recall (they’re holding on to it for the next five days and I’m on my own for car rental fees). Totally unsafe to just stop working in traffic, even when not using EV mode. This is going to hurt someone.

The entire media display gets stuck off or will freeze up, when I place the vehicle in reverse the rear camera comes on but parking assist, the rear sensors and cross traffic sensors won't work. Once I place the car in drive the display will either stay all blue or shut completely off. I cannot adjust the climate control, use GPS, or use the media. I have to shut the car off and then after about 10 minutes there is a bunch of clicking noise under the dash and after it stops clicking I can restart the car, the display will sometimes begin to work and if it dossent then I have to shut off the car again and go through the motions again. It has started to be more and more frequently, at first it was maybe once a week and now it is happening at every start.

The contact owns a 2020 Ford Fusion Energi. The contact received notification of NHTSA Campaign Number: 23V440000 (Electric System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Five months after buying our 2020 Ford Fusion Energi plug-in hybrid, Ford issued a recall stating that it was unsafe to plug it in. Now, going on 10 months later, Ford still has not corrected this safety issue. They continually say they're working on it, but I paid for a car that I didn't get. This car is not a plug-in hybrid if life-threatenting risk of fire or "loss of motive power" means I can't plug it in.