2015 FORD FUSION Complaints

Spent savings on my kid’s car. Now Needs New Engine I bought my kid a 2015 For Fusion from my best friend. It was under 100k miles. I purchased it in December. She had checked out, regular oil changes. She never had issues aside from the brake light. I paid $8000. With tax, tag, title and insurance start, it was over $9000 We take it in January took to my mechanic whom I have been using almost 20 years, very reliable and honest, for oil change and to fix the wiring of the brake light. That cost a few hundred. March the AC went out. That was about $1400. Then took in for next oil change and had to get rear brakes done, which was prepared for that one, it was time. That was a few hundred. Then the car starts shaking, take it back, they replace a coil pk and some other stuff. That was almost $300. I am almost $13000 in, it has taken my emergency savings. Breaks down again, told no compression in cylinder three. After he takes it a part, the piston is burnt up and has caused damage to the cylinder. It needs a new engine. I have to order the engine, which is $2700 to $3100 and my mechanic is gonna do it for $1800, which includes the additional parts like timing belt. I talked to ford as everyone I talk to say it is super rare to have to replace the engine under 100k miles. My mechanic said he read up on this car and the 1.5/6 turbo engines have a tendency to burn up. I think Ford should be responsible for this obvious defect. Not sure how to go about it. Ford told me that I have to have it looked at by the Ford dealership. The dealership said they could run a diagnostics & see if Ford will do anything but I have to bring them the car put back together. It took my mechanic 6 hours to break it down. He said he would have to charge me if he had to put back together. I dont know what to do. My Reddit Post has tons of similar comments: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I noticed the coolant level keeps getting low. There was a large amount of white smoke coming from the exhaust. It sounds like water in the dash. Now the car is barely drivable. No warning lights have come on.

The contact owns a 2015 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle seemed to shift improperly, after which the contact heard an abnormal rattling noise coming from underneath the vehicle. The vehicle was taken to the dealer, who diagnosed a failure with the transmission flex plate. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 22N12. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was unknown.

The contact owns a 2015 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2015 Ford Fusion Energi. The contact stated that while driving at 55 MPH, the driver slammed on the brake pedal, the vehicle veered towards the left, and crashed into the guardrail. The vehicle was uncontrollable. There were no warning lights illuminated. There were no reported injuries, fire, police report or air bag deployment. The contact was able to continue to driving. The contact called the local dealer, but the vehicle was not diagnosed or repaired. .The manufacturer was not contacted. The failure mileage was approximately 167,000.

Power steering went out and has a recall for it on the website but under the car doesn't, have it but it went out all of sudden

1. The Ford dealership in Glendale, CA refused to do the brake pedal recall, but it shows as complete. The car was bought at this dealership and never had work done to the brake pedal. (NHTSA CAMPAIGN ID: 23V162000). 2. The car burns oil way quicker than it indicates. This has happened twice to me now where I had to replace the entire engine because I completely ran out of oil before I was due for a change. I check my oil religiously after that because there are no signs of leakage. I checked my oil [XXX] after having my oil changed on [XXX] and its bone dry I have only driven under 3000 miles. I still have over 2000 miles until im suppose to change my oil and its only been 2 months. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2015 Ford Fusion. The contact stated while driving 45 MPH, the steering wheel began to wobble continuously. The contact received notification of NHTSA Campaign Number: 19V632000 (Steering). The contact stated the vehicle was taken to a dealer where it was diagnosed as a failure with steering gear motor which needed to be replaced. The vehicle was repaired but the failure persisted. The manufacturer was made aware of the failure. The failure mileage was unknown.

The contact owns a 2015 Ford Fusion. The contact stated while driving 20 MPH, the vehicle began to hesitate upon depression of the accelerator pedal with the check engine warning light illuminated. The contact initially drove the vehicle home and was later able to drive the vehicle to a local dealer. The contact was informed by the dealer that there was a crack in the engine cylinder short block and that the engine needed to be replaced. The manufacturer was notified of the failure. The vehicle had been repaired. The failure mileage was approximately 35,000.

I took my vehicle into dealer because the steering was not smooth. It appeared to be hanging up and at times difficult to maintain control of the vehicle. The problem was diagnosed by the dealer as being “internal” to the steering rack. The vehicle only has 26,000 miles on it. A search of recalls was completed on the vehicle and two recalls were completed for “corrosion” to the steering box. One recall in 2015 and one in 2018. These recalls were performed on vehicles operating in states such as my own (Northeast Ohio) where road salt could cause the corrosion. I suspect that the corrosion entered my steering rack and is affecting the steering of the vehicle. Since two recalls were done involving the steering mechanism, maybe the whole mechanism should be replaced, as how can we be certain that the corrosion was limited to just the outside of the mechanism.