2014 FORD FUSION Complaints

The contact owns a 2014 Ford Fusion. The contact stated that on various occasions while driving at approximately 30 MPH, the contact noticed a burning odor coming inside the cabin. The vehicle was towed to an independent mechanic where power steering fluid was added to the vehicle. The contact stated that while driving, the power steering became inoperable. The vehicle was steered to the side of the road. The vehicle was then towed to a dealer where it was diagnosed that the wiring harness burned causing the power steering to go out and a wiring harness needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was unknown.

Fuel tank: Tank leaked when it was filled. Most of the time in my driveway but occasionally in parking lots unstil the tank level was reduced to approximately 3/4 filled. In addition fumes would fill the air surrounding the car. The automobile is being currently repaired at an independent repair facility. No other inspection other than repair facility. Initially no warning light but as it progressed the "check engine light" lit. Inspected the removed gas tank at repair facility and the caused of the problem may be a design flaw. the tank design on my vehicle (all wheel drive) is such that it has two zones and each zone has a fuel pump. The retaining plates on the tank are made of metal and therefore due to New England winters and the position of the tank and the location of the tank the retaining plates rust. This resulted in the retaining plates to rust leaving pin holes in the retaining rings causing gas and fumes to exit the fuel system.

Car was purchased with less than 100,000k miles and within 2 weeks the the car was put into the shop for loss of power while driving and overheating. Had supposedly needed repair and within a week the car overheated again. Paid over 2,000 in repairs and tows due to issue. Car is towed to Ford was told coolant was in the entire and would need to be replaced over $7000. No way Ford should be able to sell calls with known issues and the consumer be responsible for outrageous repair fees. Ford customer service at corporate nor did the dealership offer any type of assistance with the exception of pay for it or start over for scratch which is impossible with today’s inflation. Ford knowingly sold a faulty product and they should be held accountable.

recall 19V632000 does not show up as a valid recall for my specific vehicle; however, it is at a Ford dealership now. the issue is bolts corroded, the steering gear motor is detached from the gear housing - just as described in the recall. My bolts disinigrated, corroded, and broke away. Can you please issue the recall to my specific vehicle

This is the 2nd time this has happed to me with this car. 2014 Hybrid Ford Fusion has Electronic Power Steering that is controlled by an electronic sensor. When I power steering went out (on my way to Las Vegas), I brought it to the Ford Dealer. They said I needed a new power steering column. After 3 days and doing nothing with my car, I lost my patience. To make me happy, they reset the error code and everything was magically fine - for 3 straight years! Was the power steering column bad? No! The sensor had to be cleared and reset. Now it locked up again. Looking for someone to clear this again. I am not spending $1,800 for this. This should be a recall issue for sure. 1000’s of instances!!! Stop delaying and make this a recall issue. The word “SAFETY” in NHTSA should mean something.

The contact owns a 2014 Ford Fusion. The contact stated that while operating the vehicle, the power steering assist failed, and the steering wheel became difficult to turn in either direction. Additionally, while operating the vehicle, the "Power Steering" and "Traction Control" warning lights remained illuminated. The vehicle was taken to the local dealer who diagnosed that the steering rack was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 15V250000 (Steering). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 150,000.

Power steering failing, will not correct itself to straight while driving without manual assistance, can stay locked in turned position.

Vehicle started indicating issues turning over to crank. I purchased a new key and key fob for the vehicle and got it programmed successfully I also replaced the starter with a brand new starter, issue still present in which vehicle is not turning on when I turn vehicle on to crank.

On my way home from work I turned into my driveway and my power steering just went out and when I went to start it up again ti see if it worked the steering wheel wouldn't even move. Sometimes it'll move but will be very very hard to turn when parked and other times it won't move at all. This is a known problem that needs to be fixed, luckily I wasn't on the road when it happened but plenty of other people have been and it's a couple thousand dollar fix. Whenever I start the car I get an alert saying power steering assist, uphill assist and advancetrak all require service which fits in line with everyone else's issues. I'm not sure why this hasn't been addressed yet but it should've been dealt with fat sooner. This is an error that could very easily cost lives if it were to happen on the road especially like the express way.

The Car seems to always have a strange issue with power. I have taken it for all services and recall but nothing has every fixed that issue. From talking to other Ford fusion 2013-2014 owners the transmission is bad on these cars from the start. It would be bad to loose or have the transmission go out on any major road people could get hurt. I am now getting p0744,p0741. I believe it is related to other issue suck as car clutch assembly malfunction causing high rev because car pop into wrong gears while driving. This should be a ford issue and google search and you will find everyone who own a ford fusion having this problem.