2013 FORD FUSION Complaints

The steering locked up while driving. I was unable to turn the steering wheel. My self and my brother were in the vehicle. At this time, I am contacting the dealer to look at the unit. It will not turn and is stuck in my driveway. I am being told the electronic steering rack may have failed. Why does this not break way and allow some turning like the old hydraulic models? If I had been driving highway speeds, this would have been a serious accident.

The contact owns a 2013 Ford Fusion. The contact stated that after her daughter had parked and exited the vehicle, she informed her mother that the windshield wipers had failed. An independent mechanic was contacted. The vehicle was taken to an independent mechanic to be diagnosed; however, the diagnostic result was unknown. The vehicle was not repaired. The contact had been using a spray bottle to clear the windshield. The contact related the failure to NHTSA Campaign Number: 26V117000 (VISIBILITY); however, the VIN was not included in the recall. The manufacturer was notified of the failure and opened a case. The contact was referred by the manufacturer to the NHTSA Hotline to report the failure. The failure mileage was 92,000.

The transmission shift cable bushing at the transmission end of the shifter cable has completely degraded and detached, which is a component available for inspection upon request. This failure caused a significant safety risk as the gear shifter inside the cabin moved freely while the transmission remained in its last gear, creating an immediate rollaway risk and preventing the vehicle from being shifted into Park. The safety of others was put at risk because the vehicle could not be secured and could have moved in an unintended direction. This specific problem has been confirmed by a Ford dealership, yet the dealer refused to perform the necessary repair under Recall 22S43 (NHTSA Campaign 22V413), claiming the VIN was not covered despite the vehicle exhibiting the exact failure and being within the recalled model year and assembly plant range. Prior to this total failure, there were no warning lamps or messages, though the instrument cluster occasionally showed a gear position that did not match the physical shifter before the bushing finally disintegrated. The vehicle has not yet been inspected by the manufacturer or insurance representatives.

I own a 2013 Ford Fusion SE with a 1.6L EcoBoost engine. Prior to the incident, the vehicle displayed a “Check Charging System” warning and the engine overheated. After parking the vehicle and shutting it off, a fire started under the hood in the engine compartment. The fire occurred shortly after the overheating warning and while the vehicle was not running. The fire appeared to originate in the engine bay area and caused significant damage. There were no prior accidents or modifications to the vehicle.

My vehicle has this issue and is not in the recall notice. Due to the on going issue we parked the vehicle and have not drove it. The affected cars have an engine block heater that may crack and develop a coolant leak, causing it to short-circuit when the block heater is plugged in, increasing the risk of fire. Customers with affected vehicle may notice coolant spots on the driveway or garage floor, a loss of cabin heat, overheating, smoking or a warning indicator for low coolant levels. No accident or injury has been reported linked to the malfunction, according to Ford.

1. My car began to produce white smoke after a burning smell. Then caught fire under the hood in engine area. The car is buried in snow/ice, not available to access. 2. The car caught fire. 3. The problem has not been reproduced nor confirmed by anyone (dealer/independent service center) 4. No, due to weather conditions. (Blizzard) 5. Only the burning smell and white smoke.

The power steering module/rack, passenger side air bag Safety is a risk due to steering not working properly/ seat belt constantly locking Yes Yes others inspected Seat belt sensor has been on several months Service steering assist/Lane keep system malfunction service required and steering assist fault - all came on when it got cold and steering won’t work now

Rear view camera intermittently works. Blackout when reversing. Car is in reverse camera starts then stops

UNKNOWN - I was driving the car on a highway, there were no alerts and my engine light was not on, and my car started smoking and within 5 minutes my car was completely on fire. After the fire was put out, the whole front of the car was gone and then engine looked melted.

I had multiple electric power steering failures. the first in 2022, and the second in June of 2023. In 2023 we did a complete replacement that cost over $3000.