2015 FORD FUSION Complaints

The contact owns a 2015 Ford Fusion. The contact stated while driving 60 MPH, the vehicle was overheating. An alarm sounded and the message “HOT” was displayed. The contact stated that the vehicle cooled down as he released the accelerator pedal. The vehicle was taken to an independent mechanic where it was diagnosed that the bolts had backed out from the intake manifold causing coolant to leak into the engine, leading to spark plug failure. The vehicle was not repaired. The dealer was notified of the failure. The manufacturer was notified of the failure and referred the contact to the NHTSA hotline. The failure mileage was approximately 70,000.

The contact owns a 2015 Ford Fusion. The contact stated that upon acceleration, the steering wheel became difficult to maneuver. The power steering assist fault warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the steering rack needed to be replaced. The dealer was notified of the failure and the contact was informed that the vehicle was previously repaired under a recall. The contact referenced NHTSA Campaign Number: 19V6320000 (Steering). The manufacturer was notified of the failure and the contact was informed that the VIN was not included in the recall, but no further assistance was provided. The failure mileage was approximately 93,000.

The contact owns a 2015 Ford Fusion. The contact stated while starting the vehicle, the PUSH to START button was pressed; however, the vehicle failed to start. The vehicle was towed to the dealer to be diagnosed and the contact was informed that the PUSH to START button needed to be replaced. The vehicle was repaired. The manufacturer was contacted and stated that the vehicle was out of warranty and offered no additional assistance. The approximate failure mileage was 78,000.

Drove the car last on 1/18/2023, no issues with steering whatsoever; never saw a warning light on dash. Then on 1/19/2023, I had to go to work and attempted to make the trip. Upon turning the key the car started but the dash illuminated two warnings. [STEERING-ASSIST FAULT-SERVICE REQUIRED] [SERVICE ADVANCE TRAC] I had not experienced any issues prior to this. Now the cars steering is very difficult to steer. Apparently, some drivers have experienced this while driving, this could be very dangerous and investigated as this could be lethal in certain circumstances. There was a recall for bolts, to my best of knowledge this was fully completed by a local registered Ford dealership. This causes me worry and I think Ford should look into this or at the least perform a complimentary assessment of what is going on and offer some solutions to such an issue that apparently is not uncommon.

coolant intrusion - excessive coolant consumption, white smoke emitting from tailpipe, spike in engine temperature, engine sputtering and not running correctly.

The contact owns a 2015 Ford Fusion. The contact stated while driving approximately 60 MPH, the vehicle began to lose motive power. The contact depressed the accelerator pedal and the vehicle lunged forward and then lost motive power again. The contact stated no warning light was illuminated. The contact stated that the vehicle went into LIMP Mode. The contact exited the highway and drove to a dealer at approximately 25 MPH. The contact stated that the dealer diagnosed the vehicle and determined that coolant had entered the engine block and that the engine needed to be replaced. The dealer informed the contact that the engine was not the original engine and was a replacement. The contact stated that he was the second owner of the vehicle. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was 83,507.

The contact owns a 2015 Ford Fusion. The contact stated while operating the vehicle, the engine misfired, lost coolant, and overheated. The vehicle was taken to the dealer who diagnosed that the engine was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact also stated that the backup camera and tire pressure monitoring system were faulty. The failure mileage was 30,000.

When I went to stop at a stop sign, the brake pedal went all the way to the floor and the car went partially through the stop sign. I was able to pump the brakes and get relatively solid braking, so I drove the two blocks back to my home. Once home, I pumped the brakes approximately 10 times more and the low fluid light came on, indicating a brake leak. Since the brake reservoir was able to empty in approximately 12 pumps, the leak must be relatively severe. The car is approximately 8 years old, has about 125,000 miles on it, has always been serviced by the dealership. About 2 months ago the brakes were inspected and the rear brake pads and rotors were replaced. Thus, there is no reason for a severe brake leak such as this.

The contact owns a 2015 Ford Fusion. The contact stated that while operating the vehicle, a knocking noise was present coming from the front of the vehicle. The vehicle was towed to the local mechanic who diagnosed that the steering gear motor had completely separated from the rack and pinion. The contact indicated that the bolts securing the electric power steering gear motor attachment had failed due to corrosion. The power steering gear motor and bolts were replaced, and the failure was remedied. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 19V632000 (Steering). The failure mileage was 102,000.

The contact owns a 2015 Ford Fusion. The contact stated while driving approximately 25 MPH and making a left turn at an intersection, the vehicle stalled. The contact stated that the check engine warning light illuminated 10 minutes prior to the vehicle losing motive power and stalling. The contact placed the vehicle in park(P) and was able to restart the vehicle. The contact stated that the vehicle stalled again after driving for several miles. The contact stated that the failure recurred, and the vehicle was towed to an independent mechanic. The vehicle was diagnosed, and it was determined that engine failed the compression test on all four cylinders. Additionally, coolant was leaking into cylinder #1 and #2. The mechanic determined that the failure was related to TSB: 19-2139, NHTSA ID Number: 10168739 (Engine and Engine Cooling). The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 53,000.