2015 FORD FUSION Complaints

Steering Rack was faulty in the car, causing there to be no powersteering which makes the vehicles extremely hard to maneuver while in motion. hill assist and traction control warnings popped up and vehicle makes electronic like noises as you turned the wheel. Vehicles has been taken to an independent service center and issue has been confirmed. Looking at various forums, message boards, and speaking with my mechanic this is not an uncommon issue with Ford vehicles.

2015 1.5L Ecoboost misfiring/running rough/coolant level low. While driving highway speeds engine began to lose power and shutter ultimately shutting down causing significant lose of braking and steering. Prior to this incident the check engine warning light came on and after having it scanned, code 0302 (misfire in cylinder #2) had caused the warning light. I replaced all four coil packs and cleaned the spark plugs because they only had about 30k miles on them from recently being routinely replaced. Light came on again when this incident occurred and once the vehicle was able to be scanned again it displayed codes: P0300 (random misfire), P0301 (misfire in cylinder #2), P0304 (misfire in cylinder #4) and P1450 (unable to bleed fuel tank vacuum). The car is no longer able to be driven. As soon as I started researching online what the issue could be it became very apparent that I was not the only individual(s) to encounter this exact same problem. After spending hours upon hours reading all of the reports involving Ford and the 1.5L Ecoboost, I assumed that my troubles were over. However, that was not and still isn't the case. Ford has admitted to a "design flaw" in the engine block of the 1.5L and even redesigned it. They also issued a number of TSB's (Technical Service Bulletin) detailing the symptoms, solution and parts. What they did not and to date have not done is issue a recall or offer to repair the thousands of engines that are affected by their "design flaw". I rely solely on my 2015 Fusion to commute to and from work in order to make a living. I still owe $4,807.18 on the car, following the TSB it will cost another est. $6-$8k to repair, but the problem I am facing now is I can't get to and from work to earn a living because the 2015 Ford Fusion 1.5L Ecoboost is not able to be driven due to "coolant intrusion". WHY ARE MANUFACTURERS ALLOWED TO FATTEN THEIR WALLETS BY CHEATING CONSUMERS AND NOT HELD ACCOUNTABLE FOR THEIR ACTIONS???

2015 FORD FUSION. CONSUMER WRITES IN REGARD TO REIMBURSEMENT FOR REPAIRS RELATED TO NHTSA SAFETY RECALL 22V-011. THE CONSUMER STATED THE BRAKES WOULD NOT TURN OFF. THE FAILURE CAUSED THE BATTERY TO DRAIN.

This car will randomly shut off while driving at any speed on hot days. The display will say "Transmission not in Park" then the instrument cluster will go dark and the engine shuts off. There is no check engine light and there are no ODB codes presented. I have to wait some amount of time, which varies, before it will turn on again. It has also not turned on from sitting for more than eight hours on two hot days. This is very much a safety issue and searching the Internet I find it is not uncommon with Ford Fusion and Escape vehicles with no discernible solution being presented. My auto shop has looked at the vehicle and replaced the fuel flow sensor but it did not fix the issue. I have replaced the key ignition switch and immobilizer ring and pulled every fuse and cleaned the contacts with no resolution.

The contact owns a 2015 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle started to lose motive power while accelerating. The contact stated that the hill start assists warning light illuminated. The contact stated that after parking and turning off the vehicle she became aware that the brake lights were still illuminated, causing the battery to become drained. The contact stated that she had to disconnect the battery while the vehicle was parked to stop the battery from being fully drained. The contact stated that she then took her vehicle to an independent mechanic who diagnosed and determined that the failure was caused by faulty brake light switch. The manufacturer was notified of the failure and referred the contact to the NHTSA for assistance. The approximate failure mileage was 132,000.

As I was driving, it felt as if my car had turned off or had no fuel, but no engine lights came on and i had fuel in my tank. Also all my electrical stuff stayed on, only lost power on the accelerator. My safety and others safety was put at risk because there were no warning signs i just had no "Go power" and no one around me knew my car had no power which could lead to an accident, serious injury or death; if on highway traveling at high speeds and it randomly dies. I took my car to a mechanic and they stated everything was perfectly fine they did a full diagnostic and the computer didn't show any errors in operation. This happened 3 times in one day at random times, i could put the car in park and re-start and it ran fine. however i did have to hold the key forward longer for the engine to turn over.

Driving along around town and the power steering suddenly went out causing the car to steer very hard.

The contact owns a 2015 Ford Fusion. The contact stated while driving and making a turn in the driveway, the steering wheel locked. There were no warning lights illuminated. The contact turned off and restarted the vehicle; however, the failure persisted. The vehicle was towed to the dealer where it was diagnosed that the steering gear box bolt was fractured. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was approximately 71,000.

My car has approximately 97,000 miles on it. For the last 6 months, I've been getting alerts on my dashboard ("Service Advance Trak", "Hill Start Not Available", and one or two others). This happens at slow speeds and fast also when turning. When these alerts start, I lose power steering. I've also noticed that when I apply brakes at slow speeds, the ABS engages for a few seconds. I was told by the dealer that I needed a new battery but that was not the issue. I was driving with my kids in the car and it happen mid driving on the highway. I almost got into a serious accident but was able to gain control in enough time to steer out the way. This is a very dangerous issue and I see that it has been recalled but only on vehicles up North due to possible salt and water erosion with the snow. Now the dealership is suggesting to replace it costing 1800. This is absolutely ridiculous.

The contact owns a 2015 Ford Fusion. The contact stated while driving approximately at 70 MPH and turning slightly into the right lane, the steering began to shudder. The contact was unaware of any warning lights being illuminated. Additionally, when the contact applied the brake pedal, it traveled to the floorboard. The contact lost control and went off the highway, crashing into a ditch. The contact had the vehicle towed to a collision repair shop. The vehicle was not taken to a dealer and was not diagnosed. The vehicle was repaired for collision damage only. A recall notice for NHTSA Campaign Number 22V011000 (Service Brakes, Hydraulic) was received however the contact was uncertain if his failure was related to the recall. The manufacturer had not been informed of the failure. The failure mileage was approximately 100,000.