2015 FORD FUSION Complaints

TRAVELING ON HIGHWAY AT 70 MPH WITH SUDDEN IMMEDIATE INABILITY TO MAINTAIN SPEED (LOSS OF POWER/ACCELERATION). VEHICLE NOT RESPONSIVE TO ACCELERATION REQUEST UNTIL BELOW 45 MPH AND BEHAVES ERRATICALLY (JUST STOPS RESPONDING AND CAR SLOWS). NO CHECK ENGINE LIGHT AND CAR OTHERWISE RUNS NORMALLY. ACCOMPANYING BEHAVIORS: BRAKE LIGHTS ARE CONSTANTLY ILLUMINATED (STUCK ON), EVEN WHEN NOT BRAKING AND ALSO WHEN CAR IS TURNED OFF AND KEY REMOVED. INTERMITTENTLY WHEN CAR IS STOPPED, MESSAGE "HILL START ASSIST NOT AVAILABLE" IS SHOWN. TOOK CAR INTO FORD DEALERSHIP WHO DIAGNOSED THE PROBLEM AND "FOUND BRAKE SWITCH ENGAGEMENT BUSHING MISSING FROM BRAKE PEDAL" AND OFFERED TO REPLACE THE "BRAKE PEDAL ASSEMBLY" AT A COST OF $1,062.35. FOUND SEVERAL FORUMS COMPLAINING OF THE SAME EXACT BEHAVIORS AND NOTING THAT THE OEM "BRAKE PEDAL STOP PAD" HAD BROKEN INTO PIECES. I ALSO REMEMBERED VACUUMING UP SOME PLASTIC PIECES FROM THE DRIVER FRONT FLOOR AREA NOT REALIZING WHERE THEY HAD COME FROM. THE "BRAKE PEDAL STOP PAD" ITSELF WHICH WOULD COST LESS THAN $5.00 IS NOT OFFERED BY FORD, SO PEOPLE ARE FINDING ALTERNATIVES WHICH MAY BE UNSAFE AND INCLUDE: "BRAKE PEDAL STOP PAD" NOT DESIGNED SPECIFICALLY FOR THIS VEHICLE, ZIP TIES, AND EVEN MAGNETS! OTHER FORD MODELS ARE AFFECTED AS WELL. SOME EXAMPLE FORUM LINKS BELOW. THIS SHOULD BE A RECALL. HTTPS://WWW.CARCOMPLAINTS.COM/FORD/MUSTANG/2015/BRAKES/SERVICE_BRAKES.SHTML HTTPS://WWW.MUSTANG6G.COM/FORUMS/THREADS/BRAKE-LIGHT-SWITCH-NEAR-PEDAL-FAILURE.122100/

FORD FUSION WITH 75000 MILES. REPAIR SHOP JUST DIAGNOSED MY ENGINE ISSUE AS A COOLANT LEAK INTO THE ENGINE BLOCK. THIS IS AN ONGOING PROBLEM WITH FUSIONS OF THIS AGE. REPAIR COST IS A REPLACEMENT OF THE ENGINE $8000.

I WAS IN THE DRIVE THRU OF A FAST FOOD RESTAURANT. WHEN I WENT TO PRESS ON THE BRAKE PEDAL, IT HAD NO PRESSURE BEHIND IT, AND I WAS JUST BARELY ABLE TO STOP THE CAR. I WAS ABLE TO GET THE CAR INTO A NEARBY PARKING LOT. I WAS JUST BARELY ABLE TO STOP THE CAR USING THE EMERGENCY BRAKE. MY CAR THEN SHOWED A LOW BRAKE FLUID WARNING ON THE DASH. SO I OPENED THE HOOD AND SAW THAT THE BRAKE FLUID RESERVOIR WAS COMPLETELY EMPTY. I HAD A FAMILY MEMBER COME PICK ME UP AND DRIVE ME HOME. I LATER CAME BACK WITH A BOTTLE OF BRAKE FLUID SO THAT I COULD TRY AND FIND THE LEAK. I DISCOVERED THAT THE DRIVERS SIDE FRONT BRAKE LINE HAS BEEN BLOWN OPEN, AND WAS LEAKING BRAKE FLUID AT A SUBSTANTIAL RATE. MY CAR IS STILL SITTING IN THIS PARKING LOT , AND I AM CURRENTLY MAKING PLANS TO HAVE IT TOWED TO A MECHANIC.

TL* THE CONTACT OWNS 2015 FORD FUSION. THE CONTACT STATED WHILE DRIVING AT 65 MPH THEN COMING TO COMPLETED STOP, THE VEHICLE STARTED VIBRATING. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE FAILURE REOCCURRED AFTER THE VEHICLE WAS TURNED OFF AND RESTARTED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT A LONG BLOCK ENGINE NEEDED TO BE REPLACED DUE TO COOLANT LEAKING TO THE SECOND CYLINDER. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (ELK GROVE FORD LOCATED AT 9645 AUTO CENTER DR, ELK GROVE, CA 95757) WHERE THERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED AS OF YET. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND FILED A CASE. THE FAILURE MILEAGE WAS APPROXIMATELY 116,000.

I WAS DRIVING AT APPX 30 MPH ON A CITY STREET, UPON STARTING TO STOP, I HEAR A LOUD NOISE AND I LOST THE ABILITY TO STEER MY CAR. THE BOLT THAT HOLDS THE POWER STEERING ASSIST MOTOR TO THE RACK AND PINION BROKE AND LEFT ME WITH NO STEERING CAPABILITIES. FORD ISSUED A RECALL (15S14) FOR THIS BOLT CORROSION PROBLEM. IT WAS REPLACED IN 2016, HOWEVER THE SAME EXACT PROBLEM OCCURRED AGAIN AND UPON INSPECTING BOLT IT WAS DETERMINED THAT IT WAS IN FACT CORRODED AND CRACKED 3/4 OF THE WAY BEFORE THE FINAL BREAK. THIS IS A SERIOUS SAFETY ISSUE WITHIN THE FUSION LINE OF CARS, THE RECOMMENDED "FIX" ACTION THAT WAS TAKEN IS NOT ADEQUATE TO MITIGATE THIS PROBLEM FROM FURTHER HAPPENING AND POTENTIALLY CAUSING SERIOUS CONSEQUENCES TO DRIVERS WHO ASSUME THIS ISSUE HAS BEEN "FIXED" BECAUSE THEY'VE TAKEN THEIR CAR IN FOR RECALL MEASURES. THIS ISSUE WILL CAUSE SERIOUS DAMAGE OR LOSS OF LIFE IF NOT REMEDIED BY FORD IMMEDIATELY.

IN JUNE 2020, WHILE DRIVING AND BRAKING FOR STOP SIGNS AND TRAFFIC LIGHTS, BRAKE PEDAL STARTED TO GET A LITTLE MUSHY, THEN THE NEXT TIME I STEPPED ON BRAKE I HEARD/FELT A "POP" AND BRAKES WERE FAILING AND BRAKE FLUID LIGHT CAME ON. I PULLED OFF AND A MECHANIC SAW THAT THE LEFT BRAKE LINE WAS BROKEN, UNSAFE TO DRIVE AND WOULD NEED REPLACING. TODAY AUG 19, 2020, AS I WAS STEPPING ON BRAKE TO SHIFT INTO GEAR, I HEARD THAT SAME "POP", MY BRAKE PEDAL WENT DOWN VERY FAST. I INSPECTED CAR AND FOUND BRAKE FLUID SPRAYED ALL OVER RIGHT FRONT WHEEL WELL AND BRAKE LINE WAS BROKEN, MAKING IT UNSAFE TO DRIVE. I AM VERY THANKFUL THIS DID NOT HAPPEN YESTERDAY WHILE DRIVING ON FREEWAY AND ALL OVER CITY STREETS AND UP AND DOWN HILLS. I HAVE REPAIR INVOICES FOR BOTH OCCURRENCES IN JUNE AND AUG, BUT AM UNABLE TO SCAN AND ATTACH AT THIS TIME.

STALLS OR WON'T START AFTER FILLING GAS TANK. SOMETIMES IT TAKES 5 TO 10 .MINUTES TO START. HAS STALLED NUMEROUS TIMES WHEN I WAS AT A INTERSECTION AND TRIED TO PULL OUT. GETS P1450 ERROR CODE..

TL* THE CONTACT OWNS A 2015 FORD FUSION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V177000 (LATCHES/LOCKS/LINKAGES) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT CONTACTED AUTONATION FORD CORPUS CHRISTI (ADDRESS: 6250 S. PADRE ISLAND DR, CORPUS CHRISTI, TX 78412; PHONE: (361) 444-0125) WHERE IT WAS CONFIRMED THAT THE PART WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

UPON NUMEROUS ROUGH START UPS MY FORD FUSION WITH A 1.5L ECOBOOST ENGINE, MY CHECK ENGINE LIGHT ILLUMINATED. I SCHEDULED DIAGNOSTIC SERVICE AT MY PREFERRED FORD DEALER AND THEY DISCOVERED MIS FIRINGS IN THE CYLINDERS. THEY INFORMED ME THIS IS A VERY COMMON PROBLEM WITH THE FORD 1.5L ECOBOOST ENGINE. THERE HAVE BEEN MULTIPLE TSBS ON THIS ISSUE WHICH REQUIRES A NEW ENGINE REBUILD. THERE ALREADY WAS A RECALL WITH THE 1.6L ECOBOOST ENGINE. I WAS JUST INFORMED BY THE DEALER THAT FORD WILL NOT COVER ANY EXPENSES RELATED TO THE REPAIR. THE CAR IS A 2015 WITH 68K MILES WITH ALL SCHEDULED MAINTENANCE PERFORMED BY FORD. THIS IS DISHEARTENING TO SAY THE LEAST WITH A COMPLETE PRODUCT FAILURE.

TL* THE CONTACT OWNS A 2015 FORD FUSION. THE CONTACT STATED THAT WHILE ATTEMPTING TO PLACE THE VEHICLE IN PARK, THE BRAKE PEDAL WAS DEPRESSED AND THE BRAKE HOSE FRACTURED WHICH CAUSED BRAKE FLUID TO LEAK FROM THE VEHICLE. THE FOLLOWING DAY THE CONTACT STATED SHE ATTEMPTED TO POUR ADDITIONAL FLUID IN THE RESERVOIR HOWEVER, SHE WAS UNABLE TO RESTART THE VEHICLE. THE VEHICLE MADE AN ABNORMAL NOISE AND WAS UNABLE TO BE DRIVEN. THE VEHICLE WAS TOWED TO FAIR OAKS FORD LINCOLN (2055 W. OGDEN AVE, NAPERVILLE, IL 60540). THE DIAGNOSIS WAS A RIGHT FRONT BRAKE HOSE RUPTURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 32,000. *LN THE MANUFACTURER OFFERED A DISCOUNT ON THE REPAIR BUT SAID THAT THE REPAIR WAS NOT COVERED UNDER THE EXTENDED WARRANTY. *DL