2014 FORD FUSION Complaints

Was driving lost power steering shut my car off turned it back on all the lights were gone off the dash and it had power steering again . Parked went to work the next day and drove home fine parked and then all the same lights came on again and has lost all power steering .

AdvanceTrac stopped working in my car due a sensor. Had to get it replaced by Midas. When I went to turn on my car and put it in drive it started making an awful grinding sound and would not move and gave me an error code that just said service AdvanceTrac. It was insanely expensive to repair and thankfully didn't happen while I was driving.

The contact owns a 2014 Ford Fusion. The contact stated that while his son was driving approximately 70 MPH, the check engine warning illuminated. The contact stated that the vehicle went into LIMP Mode, and his son was able to coast to the side of the highway. The contact drove out to his son's location and was able to clear the codes using a handheld scanner and the vehicle was able to be driven back to the residence. The contact stated that the failure was intermittent, and the vehicle was showing other symptoms. The contact stated that the vehicle was idling rough after a cold start and occasionally was blowing white smoke from the exhaust pipe. The contact stated that 2 years prior the vehicle exhibited the same symptoms, and the vehicle was taken to a dealer who diagnosed that there was coolant intrusion into the engine block, and the engine was replaced. The contact stated that the vehicle was under warranty at the time of the failure. The contact had taken the vehicle to an independent mechanic who diagnosed the vehicle and confirmed that there was coolant intrusion into the engine, and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline. The failure mileage was 86,825.

Coolant is leaking into the head gasket of the 2014 Ford Fusion Hybrid similar to the other 2014 Ford Fusion cars (they have a recall on them for this issue). Upon calling the nearest Ford dealership, I was told that the recall did not apply to my vehicle, even though the same recall has been made for other 2014 Ford Fusions (just not the hybrid specifically). The safety of the driver and passengers in the car is at risk due to the coolant fluid mixing into the engine oil, eventually causing a blown head gasket and potentially engine failure. This problem was identified within minutes of getting a routine oil change, as coolant was found in the cap of the head gasket. The vehicle has not been inspected by the manufacturer, police, or insurance representatives. There were no warning signs. The car notified me when I needed to change my oil, but otherwise, no dash lights came on and no notifications were sent to the dash.

On cold startup, a significant amount of white exhaust is sometimes observed coming out of the tailpipes. The exhaust has a sweet aroma and after checking the coolant levels, it appears that the coolant levels have dropped and the exhaust smoke is being caused by a coolant intrusion into the engine block. No warning lights have been observed and it only happens about half of the time.

The contact owns a 2014 Ford Fusion. The contact stated that while driving at an undisclosed speed, there was a loud clunking sound coming from the steering wheel while attempting to make a turn. There were several unknown warning lights illuminated. The contact stated that the steering wheel was difficult to turn. The vehicle was taken to the dealer, where it was diagnosed and determined that the electric rack and pinion had failed and needed to be replaced. The contact ordered the parts and had the dealer install the parts. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the dealer, where the same diagnostic was provided. The contact was informed that the electric rack and pinion needed to be replaced. The parts were ordered by the dealer. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the dealer, where the same diagnostic was provided. The contact was informed that electric rack and pinion needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 208,864.

The contact owns a 2014 Ford Fusion. The contact stated that upon starting the vehicle, the messages "Service - AdvanceTrac Off", "Hill start Assist Unavailable", and "Steering Assist Fault - Required" were displayed. The vehicle was towed to the dealer, where it was diagnosed that the steering rack had failed and needed to be replaced. The vehicle was not repaired. The contact referenced an unknown recall; however the VIN was not included in the unknown recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 78,000.

I am submitting this complaint regarding a complete loss of power steering on my 2014 Ford Fusion. The issue occurred without warning and was accompanied by multiple dashboard alerts including: “Steering Loss – Stop Safely” “Service AdvanceTrac” “Hill Start Assist Not Available” The steering became extremely heavy and difficult to turn, creating a major safety concern—especially while driving at low speeds or attempting to park. I have since researched this issue and found numerous reports from other 2014 Ford Fusion owners experiencing the exact same failure. While Ford issued a Customer Satisfaction Program (15N01) covering similar issues on 2011–2013 Fusion models, no such support appears to be available for the 2014 model—even though the symptoms and system design are identical. Dealers are quoting repairs in excess of $3,500 to replace the rack-and-pinion steering system, which is believed to be the source of the failure. Given the abrupt and dangerous nature of the malfunction, I am requesting that NHTSA investigate this issue as a potential safety defect and consider whether Ford should expand coverage or issue a formal recall for affected 2014 vehicles. This is a critical steering safety issue that could easily lead to accidents or injury if it happens at higher speeds or in traffic. I urge the NHTSA to take this seriously and evaluate Ford’s handling of this problem in 2014 Fusion models. Thank you for your attention to this matter. Sincerely, [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My brake fluid line ruptured and the dealer refused repair and told me that even if they did repair it I would take 2 days and wouldn’t provide a loaner/rental so I had took to a different shop that I had to pay out of pocket for and was done in an hour.and also this is a recall for my year make and model and isn’t on my vin

I left my car at Ford to do the recalls, they just called me telling me they won’t fix the brake light on because in Florida it doesn’t cover the repair, something about the humidity here. It doesn’t make sense for me, they were trying to charge me around 400 bucks to fix it. They will give me my car back without fixing the problem. My car is at Matthews-Currie Ford in Venice.