2023 FORD MAVERICK Complaints

On 1028/24, driving at approximately 55 mph in the right lane of a local highway, the front collision braking system engaged almost totally stopping my vehicle. There were no vehicles, animals, nor pedestrians in front of my vehicle. I was able to pull to the shoulder. The collection detection icon appeared on the screen, as well as the check engine light, and the wrench. Then a message saying collision warning system unavailable, then service vehicle immediately. The drive gear dial remained in drive (D) position and was flashing. From there, with my warning light activated, I was able to get the vehicle to go up to 25 mph in order to drive to the Ford dealership nearby. I was told by the service department that they operate on appointments only, I would "try to look at it soon." The Ford Pass App states a powertrain malfunction, pre-collision assist not available, and service engine soon warning. Even if the system resets itself when vehicle turned back on, it is totally unsafe to drive in traffic not knowing if these systems will unexpected fail again, causing an accident and injury. I understand that this problem has occurred with other drivers on this model in the recent past.

CV axles failed prematurely, at 20,000 miles. Wheels and steering column vibration at highway speeds.

The contact owns a 2023 Ford Maverick. The contact stated while driving approximately 65 MPH, there was a loud clucking sound coming from the front end of the vehicle. There were no warning lights illuminated. The vehicle was taken to the dealer and was diagnosed with a fractured front stabilizer and stabilizer link. The front stabilizer and stabilizer link were replaced, and the vehicle was repaired. The manufacturer had not been made aware of the failure. The failure mileage was 8,000.

This vehicle will reduce or cut throttle application/response relative to how many degrees the steering wheel is turning. When trying to pull out in traffic if you have the wheel turned beyond a set angle the throttle doesn't respond as expected and acceleration is greatly reduced. It will also cut the throttle if you pull out and then turn only to fully accelerate as the wheel is straightened out again. Two very dangerous examples I've experienced are 1: pulling onto a "freeway" that has a few side roads with perpendicular access. With the wheel turned the truck is very slow to accelerate when first pulling onto the expressway but suddenly will as the wheel is straightened. 2: When going across 2 lanes of traffic and making a turn to join traffic the truck will accelerate as expected across the first lanes, loose power as you turn, and then accelerate fully again as the wheel is straightened. While an argument could be made to just sit and wait until there is more time to join traffic, there are moments when being able to accelerate hard are necessary. This vehicle will either not accelerate or will reduce acceleration based on angles of steering. I believe this is a dangerous situation that most experienced drivers are not going to be expecting when they have to join fast moving traffic. Following web forums this is an issue other owners have experienced.

The plastic cooling system overflow expansion tank sign is stress cracking in the inlet tubing at approximately 8K miles. It has gotten worse with my odometer at 12K now. I have not contacted Ford regarding a warranty replacement because they would just replace it with the same defective part. I have further investigated this issue and found several documented cases with complete failure of the tank at a little as 20 K miles.

The contact owns a 2023 Ford Maverick. The contact received notification of NHTSA Campaign Number: 24V684000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

I started the Car and it made loud boom boom sounds like as if I was at a loud concert for about 10 seconds. That stopped but then loud static or electrical sound continued even after car was turned off. Re started and the sound continued. The initial sound shook me and wife. Where wife refuses to get back in. Also the initial sound wife said she smelt smoke. I faintly smelled a burnt wire smell. The next day while driving the system made more of the static/ electrical noise and didn’t stop until I parked and shut off system for about 10 min. I will be taking truck into dealer ship tomorrow.

Vehicle was travelling on freeway at freeway speeds suddenly without notable cause the vehicle electrical stopped, giving multiple warning in succession, cutting speed rapidly to 35 mph, with no acceleration pedal response and an automatic speed of 35 on battery power with the ability to break, but with no control of speed and only regulated by break pedal. Pulled vehicle to side of road and put in park, parking break automatically engaged. Vehicle had alarms on all automatic systems being off. Turning vehicle on and off did not effect response. After checking engine visually, was able to turn vehicle on with no alarms or issues. This has happened in both my Mavericks and almost led to a fatal collision in the 2022 Maverick.

The vehicle shakes during acceleration, specifically in the 40mph-65mph range. The shaking is worst around 55-60mph, especially—but not exclusively—when accelerating from a stop. The shaking does not occur at these speeds while coasting; acceleration prompts the issue. This is a known problem among 2022 Maverick owners, according to online forums including Maverick Truck Club, Reddit, and influencers on YouTube. Drivers widely report that the CV Axle is the culprit here, and report that replacing the CV Axle alleviates the shaking.

pre collision assist stops working or false alert when driving around 25-35 miles i had the truck for about 15 months and had many issues with the pre - collision sensor / camera. i took the truck to the dealer and could not duplicate the issue or fix it the sensor show and sound the alarm about crash and no car close in the front of the truck. some times the alert sound when a car is parked on the side and i am driving in a small street i have the alert recorded in the ford mobile App also rear brake locks without pressing the pedal on highway driving