2023 FORD MAVERICK Complaints

While driving, the vehicle will suddenly flash a message about gear selection being unavailable until speed is reduced, followed by error messages about collision-assist disabled, ESC disabled, hill-start assist disabled, and service messages. Check engine light and service lights also come on. No response to throttle inputs, once vehicle decelerates to around 1-2 mph electronic parking brake is automatically applied leading to an abrupt stop. Parking brake can then be removed and vehicle put back into drive, however all drive mode selection is disabled and again there is no response to throttle inputs - truck will accelerate on its own up to above 30 mph (do not know top speed as all areas this occurred were 30mph or less, had to ride brakes to maintain speed limit as vehicle was attempting an uncontrolled/uncommanded acceleration). This has happened 3 times, and first occurrence happened after recalls 23E07, 23E09, and 23C41 were completed. Any attempts to clear faults or exit this limp mode condition fail unless the vehicle is turned off and allowed to sit for 5-10 minutes, at which point faults still remain in system however vehicle is no longer in limp mode with functionality now restored to previously disabled systems. Recorded faults from last occurrence on April 05 2024: SOBDMC DTC U1011:86-AF SOBDMC DTC U1028:00-26 PCM DTC U1010:00-AF OBDII DTC U1011-P ABS DTC U0401:00-2F ABS DTC U0131:00-2E ACM DTC U0255:00-28 IPMA DTC U0418:86-AF In my situation all 3 failure events occurred in a low-traffic, low-threat environment. 1st happened when turning onto a 30 mph road and accelerating in low traffic, able to safely pull over. 2nd happened when turning out of my driveway and began to accelerate, again able to safely pull over. 3rd happened when leaving spot in parking lot, able to safely pull over into another spot.

The powertrain suddenly stopped and did not allow for acceleration. I was put in Risk because this was during a drive in the streets and it happened all of a sudden. I have seen this problem reported multiple times on Reddit.

While driving vehicle at highway speed, error message stating “Gear Selected will Engage at Low Speed” and the vehicle lost all ability to drive at highway speed. Note: no buttons had been unintentionally selected, and it happened twice within a short period of time. Pulling to a safe location while in a rolling deceleration, the vehicle slammed on its brakes at about 5mph. It then showed error messages related to “advancetrac” “front collision avoidance” and “hill start not available” the vehicle would also only move in all electric mode. After turning off the vehicle and it sitting for a few minutes, it cranked and drove normally other than check engine light is still on. Same incident occurred ~1000 miles previous to this incident

1 month after sofware update car lost power while driving, pulled over, restarted and now getting check engine light and u1011, u1028, u1010 error codes.

Vehicle lost power while driving at highway speed. Pulled over and restarted vehicle. Vehicle proceeded to accelerate without driver input. Multiple warning lights/systems activated including: POWERTRAIN MALFUNCTION / REDUCED POWER; SERVICE ENGINE SOON WARNING; PRE-COLLISION ASSIST NOT AVAILABLE. Similar to issue described in NHTSA Campaign Number: 24V267000

Travelling around 60-70mph on the highway when a warning appeared saying there is a powertrain issue and engine issue. This forced my truck into low gear and I lost the ability to accelerate. This forced me to pull to the side of the highway with no acceleration capabilities which is highly dangerous. Multiple warning lights remained on the dashboard. This first event occured on Mar 10 2024, then happened AGAIN on April 12 2024.

The contact owns a 2023 Ford Maverick. The contact stated while driving at an undisclosed speed, the vehicle stalled. The contact was able to pull to the shoulder of the road, where the vehicle lost motive power. The contact turned off and restarted the vehicle. The contact then drove to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 3,500.

For no reason the truck would not start. No electric signal at all inside the truck either. Also the ignition and steering were locked. Called Ford to send out someone to jump the truck. It then started right away. Also took to the Ford dealer to have them check it out. They could find nothing wrong. I also have had a problem with the truck not starting after driving it and then parking it. The battery will not respond, igniton will not work, not able to shift it at all. Completely locked up. I have to try starting the truck another couple of times for the green READY to come on. This is concerning as I do not understand why the truck locks up. This has happened on at least four occasions since I purchased this truck at the end of June 2023

I had 2 recalls fixed about 3 weeks ago. Today I was driving & my Maverick malfunctioned. (Maybe it's what they call Limp mode.) Many alerts & icons started flashing, I was prompted to pull over & call a dealer. I pulled over, was able to take some pics but some icons were no longer showing. I tried restarting the vehicle after a couple mins = same thing. I shut if off waited a few minutes & it worked. Well, check engine is still lit & some of the safety features won't turn on. I have copilot 360, lane keeping, etc, but most of those features are still affected. I called the dealer & am waiting for a call back. Many other Maverick hybrid owners have told me this happened after their recall fix. I wish I didn't get the recalls fixed.

The contact owns a 2023 Ford Maverick. The contact there was a leak on the floor of the vehicle from underneath the windshield on the passenger’s side. The contact stated that there was mold forming underneath the floor mats. The vehicle was taken to the dealer where it was diagnosed that the cabin air filter was fractured and caused a leak. The vehicle was not repaired. The manufacturer was made aware of the failure and confirmed that the failure was a known issue; however, the repair was not covered under warranty or a recall. The contact was referred to the NHTSA Hotline to file a complaint. The failure mileage was 37,000.