2022 FORD MAVERICK Complaints

Accelerated to merge onto highway. Vehicle alerted to pull over safely when possible. Internal combustion engine shut off and vehicle "limped" in electric only mode until I could find a spot to park. This all happened while traveling at 70MPH on a busy freeway. Once I shut the vehicle off, I was able to start it again and travel to my nearest dealer. Dealer was unable to diagnose the issue but advised it was safe to drive home to our local dealer. Truck is currently at local dealer being diagnosed. One CEL of note was P0811 (clutch slippage). This truck is nearly brand new with fewer than 12,000 miles on the odometer. I have had similar Check Engine Lights with similar results of not being able to diagnose. However, this incident of power loss at highway speeds with my wife and 3 children in the vehicle was unacceptable.

Driving northbound on Bertelsen, Eugene, OR 97402. There is a transition from asphalt to concrete with a slight bump 60ft from the stop at the light on Roosevelt. I was traveling 35 and was slowed to 25 mph at that point while actively braking. I went over the transition when the car made a big bang noise like the hybrid system disengaged hard, the tires chirped like the locked up for an instant and then the brake pedal went hard and I rolled into the intersection unable to stop until about half way into the intersection. I called the dealership and they can't look at it for a month and a half and didn't seem to concerned about it.

The vehicle will not crank and has no power. I have been getting the deep sleep notification nearly everyday. The wiring harness seems to be the issue but dealership says they find nothing wrong. Had service 4 times for dead maverick and they have replaced the battery 3 times. The vehicle will only start if I jump it through the hood terminals. If it sits for more that 24-48 hours I have to jump start the vehicle. FordPass app is useless due to being in deep sleep mode all the time. Seems others are having the issue with the wiring harness and C1617e eyelet terminal.

The low braking system on the 2022 Ford Maverick Hybrid is irregular and unpredictable. In stop-and-go traffic (sub 10mph), the braking system can either give you too much or too little brakes, resulting in the vehicle's brakes automatically grabbing and producing a jarring stop. This can be noticed when pulling in to a parking spot, slowly moving to a stop at a red light or slowly driving through a parking lot. The safety risk is a wreck waiting to happen that could injure the passengers as well as nearby cars and/or pedestrians. In winter driving (which is due soon where I live), the lack of a reliable braking system could spell even more trouble. This issue seems to finally be acknowledged by Ford via SSM 51142 but not externally to the general public. Ford does not recognize this on their site and it took a lot of work to get the dealer to finally look into this and provide the SSM # above. Still the dealer has no confirmed date as to when the software update can be made to fix this issue. The vehicle has been inspected by my local Ford dealer but they of course say nothing is wrong and that I have to wait on Ford to make a decision on when the update is available. No warning signals or messages are displayed when this issue occurs. This issue has been present since I took receipt of the vehicle back on 5/13/22.

Maverick Hybrid brakes are inconsistent. Sometimes you can brake smoothly, sometimes you cannot and the brakes will grab suddenly and lurch. Using Adaptive Cruise is miserable because the truck lurches back and forth and feels like it can't transition between friction and regenerative braking. There are no warnings on dash, truck has 1,000 miles. It is dangerous because getting more braking force than you anticipated can lead to being rear ended and not getting the brake force you anticipate can cause you to rear-end someone else.

I recently purchased my 2022 Ford, Maverick and when slowing to a stop the brakes seem to grab and then suddenly stops as more pressure is applied to the brakes. This has also happened on multiple occasions when I pull into a parking space at speeds of about 5MPH or less when the brakes suddenly grab and the vehicle kinda jerks and can stop suddenly. I would say this has happened about 30-40 times so far. Not sure if it's a brake problem or something else. I will be bringing my vehicle to the dealership next week where I bought it, Tamiami Ford in Naples Florida, but I don't expect to get any co-operation from them as I have had issues with them from the very beginning but that is a story for another time.

Occasionally the brakes don't properly stop smooth at low speeds then suddenly lock up causing a hard stop and somewhat neck pain. Brought to dealer twice but they couldn't replicate the issue. Ford Motor Corporation was contacted by me. They are aware of the issue and working on a future software fix. They refer me to the local dealer who can't do anything until Ford comes out with a fix.

Brakes suddenly grab when coming to a stop at slow speed. Although control of the vehicle is maintained on dry pavement I am concerned that it would cause loss of control in icy road conditions. Also, when this occurs while creeping ahead in heavy traffic I'm concerned that the abrupt stop could cause a rear-end collision from the vehicle following me. I believe that the problem is inherent in the design of the vehicle and that there is nothing that needs to be fixed at the dealership service department. The effect seems to occur when braking force is transferred from the hybrid's battery regeneration mode to actually applying the brakes. The date cited below is the most recent occurrence. The problem has happened sporadically since the vehicle was new, March 2022.

Occasionally when braking at low speed, primarily when coming up to a turn, stop sign or traffic light the brakes lockup causing the vehicle to come to an abrupt stop. Even when not changing the amount of pressure being applied the brakes act like I have applied full pressure. Most of the time it hasn’t been a safety issue but there is potential in wet/icy conditions for the vehicle to slide. Also the issue could cause someone to rear end me as they are not expecting me to suddenly stop.

While driving , at times the transmission suddenly stops responding when gas pedal is pushed. The engine revs but the transmission does not engage and the truck drifts to a stop. This happens every once in a while, not predictably. If you turn off the engine and wait a few minutes the transmission seems to reset itself and then drives normally for a while. Very dangerous when driving in traffic at high speed, to suddenly lose power and come to a stop. So far I’ve been lucky enough to be able to get off to the side of the road onto the shoulder. The Maverick is in for service now and I’ve told them that other Maverick owners are reporting this on owners forums.