2023 FORD MAVERICK Complaints

Vehicle stopped accelerating while doing an U turn with oncoming traffic. Had to pull over because the vehicle would not move.

Vehicle drivers front door is very hard to operate, very hard to shut, window wont roll all the way down. Vehicle makes popping noise when operating drivers front door. Door wont close all the way at times due to door check binding inside of door. Ford has had a customer satisfaction service repair for Escape model vehicles with similar problems. Ford reference for this action is 23B56. Due to the door not being able to close properly this vehicle will require repair and the vehicle taken out of service because it is not safe to drive with the door not latching properly. The spot welds are broken away from the door causing the door check and mounting bracket to be pushed into the door when closing, this causes the door to not be properly latched.

Truck shakes when accelerating and limits acceleration and safety. Belief is the CV axles failing.

Vehicle started shaking during acceleration above 40 mph. Felt like the wheels were going to come off. The issue is that the front axle drive shafts are very corroded and failing.

Vehicle information: Ford Maverick 2023 Hybrid, with roughly 37,000 miles, observed failure on [XXX]. The failed component/system is the A/C evaporator condensation drain system. The drain line became clogged, which I believe is a critical defect in either the design, component, or construction of the drainage system. The lack of a fail-safe in this system, instead of draining water outside of the vehicle, the condensation backed up and leaked directly into the vehicle's cabin onto the driver and passenger side footwells. The vehicle is currently at the dealership (Windward Ford), undergoing diagnosis/repair, and available for inspection upon request. The pooling of a large volume of water on both the driver and passenger side floorboards to include the path of where the water originates as it collects at the footwell, creates an unreasonable risk of safety failure due to the proximity of critical electrical systems; fire/short circuit risk, loss of vehicle control due to damage to electronic modules from water intrusion, as well as health hazard with prolonged saturation of pores material resulting to mold and mildew growth. The issue has been reproduced at the dealership (Windward Ford), and confirmed that the issue is an A/C evaporator drain clog, causing the leak, and the carpet and interior padding were saturated, requiring extensive cleaning and replacement. The failed component/system has been inspected by technicians at the dealership. The diagnosis and repair estimates are on file with the dealership. There were no warning lamp indicators or messages, just the damped smell, which was noticed a few weeks prior to the visual indicator of a water puddle in the floorboard. The odor is a direct result of the ongoing, hidden water leak and saturation of the carpet, indicating a slow, chronic problem caused by the defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The seat belt system is faulted and is showing the airbag light is on, when started it shows a red question mark on the drivers seat. Also shows a rear seat fault.

Receive "Has Entered Deep Sleep Mode" daily notification through the Ford APP. The dealership keeps telling me there isn't anything wrong with the battery, as it's test good. Even though the can see (an I've shown them) the notifications. It's being driven as it's my daily driver. It hasn't put me at risk at this time.

My entire front end is vibrating badly. I replaced all tires and did a front end alignment. It didn't fix the issue. I took it to the dealership for diagnosis and they said the axels are bad and a known issue on the make model and year.

I took my vehicle in to have the transmission looked at. The dealership told me that the problem was resolved. While driving down the road the transmission went into park in the middle of a two lane road. When the vehicle came to a complete stop I was stopped in the middle of the lane and the vehicle transmission would not shift out of park. After getting it to another shop where it is currently located I was informed that the transmission needs to be replaced and that this is a problem that they are seeing in several Ford vehicles. I contacted Ford who stated that there are no current recalls for this problem. Obvious safety concerns are not being able to control the vehicle when it shifts to park while driving as well as being stopped in the middle of the roadway where a collision is likely.

CV axles failed at 30,000 miles, repaired under warranty. Replaced axles have failed again at 60,000 miles, no warranty. No hard driving, simply highway miles. This seems to be common in these vehicles and need to be recalled for defective parts. This has caused me poor fuel mileage, damage to new tires, instability while driving, and possible unknown damage to transaxle.