2022 FORD MAVERICK HYBRID Complaints

While driving the vehicle, multiple error messages popped up on the dash and resulted in an immediate slow down and unable to accelerate by pressing the gas pedal. The car would then auto accelerate without pressing the gas pedal to 35 mph. Only thing that has recently happened was I had taken vehicle to dealer to perform some recalls.

The Maverick unexpectedly switched to limp mode and had engine failure while in motion. The Maverick would not go over approximately 25mph unless coasting faster on a downhill. On some uphills, it struggled to maintain 10mph. Turning the vehicle off and back on again did not alleviate the issue. Approximately two months ago, I started to have a check engine light on. It took the dealership two months to get my Maverick in for service. The service finally occurred this past Monday/Tuesday (13-14 May). Ford thought they fixed the issue which they had not. They also did the current recalls on the truck. This most recent highly dangerous issue happened after those recall software updates. The FordPass Alert: "The powertrain control module has detected the engine timing chains have exceeded 95% of their useful life and requires service now. The control system invokes a symptom of limited power." This is a common issue amongst Maverick Hybrid owners and Ford is not doing anything to fix the issue. Many Maverick owners are having it happen multiple times and at speeds up to 70 or 75 mph. it is preferable that Ford be forced to take responsibility and fix the issue before people are serious injured or killed. Thank you.

•My saga continues driving my Maverick hybrid to NY to visit my mom for Mother’s Day hoping the new Battery/Smart Junction Box that my Ford Dealer replaced on 4/9 was the culprit in the 2 shutdowns experienced on [XXX]. •[XXX] Maverick shutdown 3x driving on highway around 70 mph during 400-mile trip. Had to wait approx. 20-minutes each time for engine to cool off and reset from electric mode to continue on. NY Ford dealer diagnosed on 5/13 and reports: U1010 is present , Hybrid Powertrain Control Module is suspected to be bad They said it would take a few days to get a new PCM from Ohio warehouse. I couldn’t wait and had to return to MD for work on 5/14. •[XXX] Shutdown 4x driving on highway around 70 mph during 400-mile return trip. Had to wait approx. 20-minutes each time for engine to cool off and reset from electric mode to continue on. Fortunately, no accidents and I was always able to find a safe spot on the side of the road to pull over to and wait for 20 minutes or so. •[XXX] Received Ford Safety recall notice 23S27 for Software to repair 2022-2023 Mavericks to update the Powertrain Control Module (PCM) free of charge (parts and labor). Note NY Ford Dealer recommended replacing PCM vs. repairing or updating it. Is there a definitive way to test which is best, replace or repair? •[XXX] Just found this at Check for Recalls: Vehicle, Car Seat, Tire, Equipment | NHTSA dated May 3, 2024 Manufacturer Recall Number 24S33 Both I and the NY Ford Dealer were unaware of this recall, 24S33 or they could had tried updating my PCM. Thanks Ford! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Rubber filler tube that connects to gas tank is leaking! I see many people online with the same issue! The leak is coming from the connection where the hose clamp is not the tank!!! The clamp is tight!

While driving on the highway my car randomly went into limp mode rapidly and nearly caused an accident. I do know the code was U1011. It is a PCM fault stating the PCM and the engine has lost connection. It has been noted to turn on and off randomly and cannot be replicated until it reappears. Dealerships have been giving the run around that it goes away so it’s not a problem. Everyone to include me is having the problem after getting a recent PCM update recall done. My local ford deal shops even say they can see the fault happens, but will not do anything to solve the issue. This fault puts me and everyone in the road as risk randomly sending my car into limp mode without warning or signs.

The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: 24V293000 (Exterior Lighting, Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that long after the vehicle was parked or turned off, the vehicle made a clicking noise coming from the engine compartment. There were no warning lights illuminated. The contact received a recall notification letter stating that the remedy would not be available till the third quarter of 2024. The dealer was contacted. The manufacturer was made aware of the issue. The approximate failure mileage was 24,000. Parts distribution disconnect.

On [XXX] my husband was traveling on [XXX] in Pennsylvania between mile markers [XXX] and [XXX], on cruise control driving 75mph. As he was starting up a steep incline, the Maverick (without warning) started to lose speed, went into LIMP mode (power to engine failed ) and the dashboard lit up with several different errors. He was in heavy traffic and had to swerve to the left median to pull over to safety, narrowly avoiding an accident. He did a vehicle inspection to ensure all fluids were still intact, wires were secure, etc. and did not detect anything wrong. He let the Maverick sit for 15 minutes and started the vehicle. The Maverick started with no issues, so he assumed it was a fluke and continued driving to reach his destination of Upstate NY from West Virginia. Before he could reach the NY border, his Maverick suddenly went into LIMP mode again while traveling up another incline on cruise control (also at 75mph). This time he was able to swerve to the right median to avoid causing an accident. He followed the same steps as before, and the Maverick turned on again without issue. He continued his drive to NY and was able to successfully make it without using cruise control. He brought it to our local Ford Dealership in Hagerstown, MD (the Ford dealerships in NY did not have capacity to assess the Maverick as we were only in NY for a couple of days). Our local Ford Dealership was not able to find anything wrong with the Maverick and said because they could not generate the same errors there was nothing they could do. We did show the the history of the errors as it's all contained on the Ford App, but they dismissed it as they couldn't figure it out. This happened again on [XXX] driving down [XXX] between mile markers [XXX]-[XXX], in a construction zone. He was thankfully able to pull over, narrowly avoiding getting rammed by a semi truck behind him. Our dealership refuses to help us fix the error. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Drove my car home and parked in my driveway with no issues. 9 hours later when I was about leaving for work, started the car but car won't start. I jumpstarted the car then all of a sudden the (Drive) Shift knob light was flashing, warnings started flashing, hill start assist not available, service vehicle soon, pre collision assist not available, service advance Trac, and parking brake applied automatically and total loss of power. When I pressed on the gas, it wouldn’t go and no throttle response. When I let off the brake and was NOT pressing the gas, it would start to accelerate all on its own up to about 28/29 mph all on its own, acting like it was in cruise control

I found mold under my front passenger floor mat. There has been a water leak since u had purchased the vehicle. As of now the dealership has not successfully discovered the source. Vehicle has been in and out of the dealership since Feb 22, 2024.

I was driving down the freeway and my truck when into reduced power mode, displaying " Powertrain malfunction/Reduced power, engine service soon, and precollision assistance not available". This ended up slowing me rapidly from 65 down to under 20 miles. I almost had a semi slam into the back of me missing me by inches.