2023 FORD MAVERICK HYBRID Complaints

1 month after sofware update car lost power while driving, pulled over, restarted and now getting check engine light and u1011, u1028, u1010 error codes.

Vehicle lost power while driving at highway speed. Pulled over and restarted vehicle. Vehicle proceeded to accelerate without driver input. Multiple warning lights/systems activated including: POWERTRAIN MALFUNCTION / REDUCED POWER; SERVICE ENGINE SOON WARNING; PRE-COLLISION ASSIST NOT AVAILABLE. Similar to issue described in NHTSA Campaign Number: 24V267000

Travelling around 60-70mph on the highway when a warning appeared saying there is a powertrain issue and engine issue. This forced my truck into low gear and I lost the ability to accelerate. This forced me to pull to the side of the highway with no acceleration capabilities which is highly dangerous. Multiple warning lights remained on the dashboard. This first event occured on Mar 10 2024, then happened AGAIN on April 12 2024.

The contact owns a 2023 Ford Maverick. The contact stated while driving at an undisclosed speed, the vehicle stalled. The contact was able to pull to the shoulder of the road, where the vehicle lost motive power. The contact turned off and restarted the vehicle. The contact then drove to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 3,500.

For no reason the truck would not start. No electric signal at all inside the truck either. Also the ignition and steering were locked. Called Ford to send out someone to jump the truck. It then started right away. Also took to the Ford dealer to have them check it out. They could find nothing wrong. I also have had a problem with the truck not starting after driving it and then parking it. The battery will not respond, igniton will not work, not able to shift it at all. Completely locked up. I have to try starting the truck another couple of times for the green READY to come on. This is concerning as I do not understand why the truck locks up. This has happened on at least four occasions since I purchased this truck at the end of June 2023

I had 2 recalls fixed about 3 weeks ago. Today I was driving & my Maverick malfunctioned. (Maybe it's what they call Limp mode.) Many alerts & icons started flashing, I was prompted to pull over & call a dealer. I pulled over, was able to take some pics but some icons were no longer showing. I tried restarting the vehicle after a couple mins = same thing. I shut if off waited a few minutes & it worked. Well, check engine is still lit & some of the safety features won't turn on. I have copilot 360, lane keeping, etc, but most of those features are still affected. I called the dealer & am waiting for a call back. Many other Maverick hybrid owners have told me this happened after their recall fix. I wish I didn't get the recalls fixed.

The contact owns a 2023 Ford Maverick. The contact there was a leak on the floor of the vehicle from underneath the windshield on the passenger’s side. The contact stated that there was mold forming underneath the floor mats. The vehicle was taken to the dealer where it was diagnosed that the cabin air filter was fractured and caused a leak. The vehicle was not repaired. The manufacturer was made aware of the failure and confirmed that the failure was a known issue; however, the repair was not covered under warranty or a recall. The contact was referred to the NHTSA Hotline to file a complaint. The failure mileage was 37,000.

225/60R18 100H Primacy A/S Tire Tire chunking at 800 miles and again at 3000 miles.

Driving no more than 40 mph, suddenly “gear shift will engage at low speeds” pops up. At this point there is no acceleration. Then when I get to stop at about 1mp it jerks me into an e-brake, immediately prompting “powertrain error”, “check engine”, “hill climb assist not available”, “collision warning not available”. This all started after the last recall was performed. This is now the second time this has done this. I am lucky it did not do this on the highway itself.

I was driving on the interstate and the gear shift light started blinking. Then I started getting warning lights on the dash: - Gear Selected Will Engage at Low Speed - Powertrain malfunction/reduced power - Pre-collision assist not available - Service engine soon warning - Hill assist not available The car then abruptly slowed down to 35 mph and continued driving at 35 mph even when applying gas. The vehicle would slow down when the brake was applied, however releasing the brake, caused the car to accelerate to 35 mph. The vehicle was inspected by a Ford dealership, however it was the next day, after the car had been turned off for multiple hours. The dealership did not find any active codes, so there was no "fix". Abruptly coming to a stop on the interstate is scary and life-threatening. Ford needs to fix this issue as there could have been a catastrophic accident, had other motorists not been paying attention!