2023 FORD MAVERICK HYBRID Complaints

Windshield chip at day 4 of ownership, full on crack requiring replacement week 4 of ownership. Windshields are clearly subpar, owners on 3rd and 4th replacement windshields already. Dont know if it's the glass or the vehicle design, but there's a problem here.

The truck shudders when turning off the ICE and switching to electric. It has progressively gotten worse since around 5000 miles. Group research on online forums suggests this is the damper on the flywheel. Because it's progressively getting worse, even at 8000 miles, I am concerned it will leave me stranded when the whole transmission blows apart. It makes an awful noise that sounds like grinding when the shuddering occurs. It does not happen every time the engine turns off, but the entire transition between electric and ICE is extremely rough.

We were traveling across the country from CA, MN , KY, WV, VA, PA, NY, MN, WY, ID, NV. CA. 21 July 2023. RR passenger window rolled down and will not roll up -taken to Greenbrier Ford in Lewisburg,WV. They verified “RRWindow won’t roll up. Took door panel apart & tested for power. Both wires going to up circuit & down circuit for RR window gets 12V, either way you push or pull switch. Should only get power one way. Unsure of cause. Will need further diag. Got window to roll up.” 24 July 2023. RR passenger door lock stopped working/stopped functioning. RR door would not lock when key pushed. 29 July 2023 . Dome light/running lights/headlights stopped working. they then would function intermittently. 1 Aug 2023. Took truck to Kimber Lake Ford in Pine River MN. Had Oil changed. They checked for computer codes but nothing came up. They suspected it might be the central computer. Didn’t have time to do more than that. 11 August -bluetooth connection malfunctioned. could not get a plugged in phone synch with music or phone calls. 11 August. called Folsom Lake Ford for appt on 24 August. .

Vehicle will not accelerate faster after stopping. Runs at less than 5 mph for 3-4 minutes and will accelerate afterwards. If stop again it will continue stalling during acceleration. Very unsafe in traffic. Rear end collision would take place as the driver id that vehicle is not aware of the stalling.

When I am driving my car and the car goes from the gas engine to the electric engine (at slow speeds. Usually under 40mph) the steering wheel and car will shack or vibrate. Sometimes really violently or sometimes just a little. Now my car makes a really bad rattling sound like metal is bouncing around. Ford saids it’s normal. I have driven other hybrid and never experienced this to this extent. It was scary at first. I thought something happened to my car or I hit something.

Whenever I press the brake pedal the brakes GRAB. It is not smooth, and is very uncomfortable, and even dangerous!

The contact owns a 2023 Ford Maverick. The contact stated while driving 80 MPH, the transmission inadvertently shifted into neutral(N) and the vehicle lost motive power. Additionally, the instrument panel lights flickered. The contact related the failure to NHTSA Campaign Number: 23V380000 (Engine). The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 1,500.

Engine shudders when switching from gas to electric mode. The sound is terrible and only started recently. The 2022 model apparently has the same problem. Sounds like running over a rumble strip. Concerned it may shut off while driving or otherwise. Happens at idle and while driving.

Just took delivery of this new vehicle. The windshield is pitted and this leads to difficulty in cleaning the windshield with the wiper fluid and wipers as a result of the increased surface area and surface roughness. In addition, when the sun is low in the sky visibility is affected by the pitting causing excess refraction.

Brakes of 2023 Ford Maverick Hybrid are grabby when attempting to slow down to below 6-10 mph , especially when the roads are wet. Even with slight wetness on the ground, the brakes behave like this, leading to unpredictable stops and jumping of vehicle in common scenarios such as drive-thrus, stop-and-go traffic, and parking lots. Local Ford dealer attempted to replicate the issue when it was sunny and dry and was unable to do so. As such, they refuse to do any further testing and are saying that "this is how the hybrids are". I will visit the dealer again when it is rainy.