2006 FORD RANGER Complaints

WHILE DRIVING ON THE TCH IN NEWFOUNDLAND, I HEARD THIS UNUSUAL BANG OUT OF THE REAR OF MY FORD RANGER. I LOOKED IN THE REAR VIEW MIRROR AND SEEN SOMETHING COME FROM BENEATH THE REAR OF MY TRUCK. I PULLED OVER AS DID THE VEHICLE TRAVELING BEHIND ME. THE SPARE TIRE ASSEMBLY HAD RUSTED OFF WHICH LET THE TIRE LOOSE AND FALL OFF. THE TIRE NARROWLY ESCAPED THE VEHICLE BEHIND ME. AFTER CLOSER INSPECTION ON THE TRUCK , THE MAIN FRAME HAD COMPLETELY CRACKED OFF AS DID THE SPRING HANGER. I CONTACTED FORD RELATIONS AND THERE WAS NOTHING THEY COULD DO. THIS IS TOTALLY UNSAFE OF FORD TO IGNORE THIS PROBLEM WITH THIS FORD AS IT ALMOST CAUSED A FAMILY OF 3 AN ACCIDENT. I HAVE TAKEN CARE OF THIS TRUCK AND HAVE HAD IT UNDER COATED EVERY TOO YEARS. THERE IS ONLY 85000 KILOMETERS ON THIS TRUCK AND THE FRAME IS COMPLETELY RUSTED OUT. MY PROBLEMS HAVE BEEN DOCUMENTED. *TR

ROUGH IDLE NOTICED WHILE STOPPED AT AN INTERSECTION. CATASTROPHIC MISFIRE UPON ACCELERATION THROUGH AN INTERSECTION. TRUCK WAS ONLY ABLE TO "LIMP" 5 OR LESS MILES PER HOUR. CHECK ENGINE LIGHT HAD BEEN TURNING OFF AND ON HOWEVER DIAGNOSTICS SHOWED MISFIRE FOR UNKNOWN REASONS. SPARK PLUGS AND WIRES HAD BEEN REPLACED TWICE WITHIN A YEAR AS WELL. DEFECTED HEAD MANUFACTURED BY FORD. *TR

I HAVE A 2006 FORD RANGER THAT I PURCHASED NEW (ITS MY SECOND RANGER I HAD A 1996 THAT I TRADED IN. I REALLY LIKE RANGERS BUT HAVE RUN INTO A MAJOR PROBLEM WITH RUST ON MY RANGER. THE SPRING SHACKLES RUSTED AND BROKE ON BOTH SIDES LAST WEEK. I TOOK MY BED OFF TO REPLACE THE SHACKLES AND FOUND THE BRACKETS WERE ALSO RUSTED OUT. THE FRAME IS VERY RUSTY AND THERE IS RUSTED HOLES THROUGH ON THE DRIVERS SIDE REAR FRAME. I HAVE NOT GOT TO THE FRAME UNDER THE CAB OR FRONT OF TRUCK YET. IS THERE A RECALL OR CAN I EXPECT HELP FROM FORD. THE SAFETY FACTOR OF THE FRAME CONCERNS ME. *TR

TOOK MY TRUCK IN TO HAVE WHEELS CHANGED. WHEN PUT ON THE LIFT, I HEARD TO SOUNDS FROM THE SUSPENSION. BOTH SPRING SHACKLE HANGERS AND BRACKETS WERE RUSTED. THE SHACKLES ACTUALLY FELL APART. I HAVE REMOVED THE BED AND FOUND EXTENSIVE RUST OUT ON THE FRAME . THE DRIVER SIDE REAR FRAME IS BASICALLY GONE FROM RUST OUT. *JS

TL - THE CONTACT OWNS A 2006 FORD RANGER. THE CONTACT STATED THAT THE FRAME WAS COMPLETELY CORRODED. THE VEHICLE WAS TAKEN TO THE DEALER. THE CONTACT MENTIONED THAT BOTH DRIVER AND PASSENGER SIDE REAR SPRING RAIL, MOUNTS AND SHACKLE WERE RUSTED PREVENTING HIM FROM PASSING STATE INSPECTION. THE TECHNICIAN VERIFIED THE FAILURE AND STATED THAT THE FRAME NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 36,508. PM

FORD VEHICLE LOST POWER AND STOPPED RUNNING WITH FULL TANK OF FUEL. WOULD NOT RESTART, HAD TOWED TO REPAIR SHOP. REPLACED FUEL PUMP FOR $606.99. DROVE ABOUT A MILE AND SAME THING HAPPENED AGAIN. FOUND THAT THE FUEL INERTIA SHUT OFF SWITCH NEEDED RE-SETTING. BOUGHT A FUEL PUMP I DIDN'T NEED. THIS HAS HAPPENED MULTIPLE TIMES THIS YEAR AGAIN. FORD DEALER SAID I NEEDED A FUEL PUMP. (35,000 MILES) AGAIN, NO WAY. THE REPLACEMENT PART (INERTIA SWITCH) MOVES THE SWITCH FROM PASSENGER FLOOR AREA TO SIDE KICK PANEL. THE DESIGN CHANGE SHOWS DESIGN FLAW. FORD SHOULD REPLACE FOR NO COST. VERY DANGEROUS WHEN ENGINE DIES.

OF THE TWO REAR CROSS MEMBERS THAT SUPPORT THE GAS TANK ONE SIDE HAS COMPLETELY ROTTED TWO INCHES OF METAL AWAY. THE FORWARD ONE IS NEAR FAILURE THE REAR ONE COMPLETELY FAILED ONE SIDE.WILL PUT SOME SORT WEB STRAP SYSTEM SO THE TANK DON'T FALL OUT TILL WE GET WARMER WEATHER AND REMOVE THE BED TO INSPECT FRAME RAIL. A FRIEND OF MINE HAD TO REPLACE THE WHOLE REAR FRAME ASSEMBLY. THE REAR SPRING SHACKLES ARE NEAR FAILURE. *TR

PURCHASED THIS VEHICLE IN 2007 WITH 8K MILES AND HAD SOME RUST ON THE FRAME. NOW, 2013 I HAVE 24K MILES AND THE FRAMES IS COMPLETELY CORRODED AND MY BRAKES ARE FAILING DUE TO THE RUST. HAVE ALREADY SANDED THE FRAME AND PAINTED, BUT THE RUST COMES BACK. THIS A BIG SAFETY CONCERN BECAUSE PARTS CAN BREAK WHILE DRIVING. *TR

I WAS DRIVING DOWN THE ROAD AND I HIT A BUMP AND MY SPARE TIRE FELL DOWN AND OUT OF THE TRUCK ONTO THE HIGHWAY. I STOPPED IMMEDIATELY AND RETRIEVED MY WHEEL OF THE HIGHWAY AND SAW THAT IT WAS STILL CONNECTED TO PART OF THE MOUNT. THE NEXT DAY I DROVE TO A REPAIR SHOP TO PUT THE TRUCK ON A LIFT TO LOOK AT THE DAMAGE AND REALIZED THAT THE ENTIRE FRAME HAD ROTTED UNDER THE TRUCK. I LEFT THE REPAIR GARAGE AND WAS HEADING HOME WHEN I HIT A POTHOLE THE ENTIRE DRIVER SIDE FRONT FRAME ROTTED AND THE WHEEL FELL PARTIALLY OFF THE TRUCK, SO I HAD THE TRUCK TOWED TO MY OFFICE PARKING LOT AND PARKED IT, BECAUSE IT IS NOT DRIVABLE ANYMORE. I CONTACTED FORD THEY TOLD ME TO HAVE IT TOWED TO A LOCAL DEALERSHIP AND THEY WOULD SEND A REP OUT TO LOOK AT IT. SO I DID AND THE REP NEVER CAME OUT AND THEY TOLD ME TO HAVE IT REMOVED, THAT THE REP CALLED THEM AND SAID THEY WOULD NOT REPAIR ANYTHING, SO THE TRUCK STILL SITS ROTTED AND PARKED, AND REMEMBER IT ONLY HAS 17,900 MILES ON IT, THANK YOU. *TR

RUNS ROUGH AT STOP. HESITATES WHEN ACCELERATES. COULD CAUSE ACCIDENT AT INTERSECTIONS. VALVE RECESSION PROBLEM AS DESCRIBED IN FORD ISSUED TSB. *TR