2004 FORD RANGER Complaints

TL* THE CONTACT OWNS A 2004 FORD RANGER. THE CONTACT WAS DRIVING 50 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THAT THE FUEL PUMP SHUT OFF SWITCH NEEDED BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 90,000 AND THE CURRENT MILEAGE WAS 92,000.

TL* THE CONTACT OWNS A 2004 FORD RANGER. THE CONTACT STATED THAT THERE WAS A HOLE BURNT THROUGH THE WIRING HARNESS. THE CONTACT WAS INFORMED OF THE FAILURE WHILE HAVING A THERMOSTAT REPLACED BY AN INDEPENDENT MECHANIC. THE CONTACT WAS ALSO INFORMED THAT THE FAILURE COULD CAUSE A FIRE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE FAILURE WAS NOT COVERED BY WARRANTY. THE FAILURE AND CURRENT MILEAGES WERE 62,000.

ROT HAS APPEARED IN BED OF TRUCK. ROT HAS COME FROM UNDERSIDE OF BED, SEEMINGLY DUE TO A FABRIC THAT HOLDS MOISTURE AND WATER, THAT IS IN DIRECT CONTACT WITH UNDERSIDE OF BED, CAUSING RUST TO FORM AND EVENTUALLY ROT THROUGH THE BED. IN THE PAST 4 MONTHS, ONE HOLE APPROXIMATELY 5 INCHES IN DIAMETER, ANOTHER 2 INCHES IN DIAMETER AND THIRD HOLE IS FORMING. I AM CONCERNED THAT THERE IS ROT FORMING ON THE FRAME MEMBERS, AND IF THIS WILL LEAD TO AN UNSAFE CONDITION DURING DRIVING OR IN THE EVENT OF AN ACCIDENT. *TR

MY WIFE SAT ON THE TAILGATE OF THE VEHICLE, AND BOTH TAILGATE SUPPORT CABLES SNAPPED AT THE SAME TIME CAUSING HER TO BE DROPPED ONTO THE GROUND, AND INJURING HER KNEE. NEITHER OF THE CABLES HAD SHOWN ANY PHYSICAL DAMAGE, AND THE RUBBER EXTERIOR COATING OF THE CABLES WAS STILL FULLY INTACT. UPON MY INSPECTING THE CABLES AFTER THEY HAD BROKEN, BOTH STEEL CORES WERE IN FACT CORRODED. *TR

REAR BRAKES RUSTED, HOLDING SPRINGS RUSTED, SUPPORT PINS FELL OUT AND CAUSED BRAKES TO DRAG AND BECOME WORN AND OVERHEATED WAY BEFORE THEIR TIME CAUSING REPLACEMENT ABOUT 30,000 MILES BEFORE THEY SHOULD HAVE BEEN. COULD HAVE CAUSED BRAKES TO LOCK WHILE DRIVING. *TT

TL* THE CONTACT OWNS A 2004 FORD RANGER. THE CONTACT STATED THAT THE VEHICLE WOULD INTERMITTENTLY SURGE FORWARD WHILE DRIVING AT VARIOUS SPEEDS. THE FAILURE ALSO OCCURRED WHEN THE CRUISE CONTROL WAS ENGAGED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON NUMEROUS OCCASIONS IN WHICH THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 77,000 AND THE CURRENT MILEAGE WAS 80,000. UPDATED 07/20/11*LJ THE DEALER REPLACED THE CRUISE CONTROL SWTICH. UPDATED 02/06/12

TL - THE CONTACT OWNS A 2004 FORD RANGER WITH DUNLOP RADIAL ROVER TIRES, LINE SIZE 255/70/R16. THE CONTACT STATED THAT WHILE DRIVING 40 MPH SHE HEARD A BANGING NOISED, SHE REALIZED THAT THE FRONT PASSENGER TIRE TREAD AND PART OF THE WIRES SEPARATED WHICH LATER THAT DAY EXPLODED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 170,030. PM

2004 FORD RANGER - FUEL CUTOFF INERTIA SENSOR ENGAGES SPORADICALLY AND REQUIRES RESET TO RESTART THE VEHICLE. THIS HAS OCCURRED AT HIGHWAY SPEEDS, AND REQUIRED THE DRIVER TO PULL TO THE SHOULDER. POWER STEERING IS LOST WHEN THIS OCCURS. DEPENDING ON CONDITIONS AND SURROUNDING TRAFFIC THIS COULD BE VERY DANGEROUS. THIS ISSUE HAS OCCURRED ON NUMEROUS OCCASIONS, UNDER A VARIETY OF CONDITIONS. HAVING A FUEL SYSTEM CUTOFF THAT CAN ENGAGE AT-SPEED DURING NORMAL DRIVING IS A TERRIBLE DESIGN FLAW. *TR

TL*THE CONTACT OWNS A 2004 FORD RANGER EQUIPPED WITH B.F GOODRICH LONG TRAIL TA TIRES, LINE SIZE 235/70/R16. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THERE WAS AN ABNORMAL THUMPING FROM THE FRONT PASSENGER SIDE TIRE. THE CONTACT STOPPED TO CHECK THE TIRES AND FOUND AN ABNORMAL BULGING ON THE TREAD BELT. THE TIRE FAILURE WAS NOT IMPACTED BY A POTHOLE OR ANY OTHER ROAD HAZARD TO CAUSE THE FAILURE. THE REMAINING TREAD DEPTH WAS 1/4 INCHES. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE FAILURE MILEAGE WAS 81,000. UPDATED 05/03/11*LJ UPDATED 06/03/11

HORN AND WINDSHIELD WIPERS COME ON WHEN I TURN ON HEADLIGHTS ON 2004 FORD RANGER XLT. *TR