2020 FORD RANGER Complaints

The contact owns a 2020 Ford Ranger. The contact stated while starting the vehicle, the heating system became inoperable. The contact stated that the heater would not function properly. The vehicle was taken to the dealer where it was diagnosed that the HVAC blower motor failed and needed to be replaced. The vehicle was not repaired. The contact was referred to the NHSTA Hotline for assistance. The approximate failure mileage was 86,000.

The blend door for HVAC controls sticks, makes clicking noises. From time to time it will stick in one position, for example cabin, when I need defrost, making it difficult to see safely potentially.

Early model 2019-2020 Ford Rangers have a known defect where the blend door actuator fails. The assembly was redesigned mid 2020 and is now the common fix for all who are affected by this issue. During this failure the blend door cannot and will not actuate as it should causing in ability to defrost the windshield causing visibility issues. Additionally, it causes unbearable heat to be released inside the vehicle with no warning causing additional safety issues for drivers and passengers. The issue is widely observed for all owners of early generations. Even though ford has known about the issue that forced an entire redesign they are unwilling to recall the defective component. I have contacted their corporate office and was informed there is no support for this issue. Today, while driving the system on its own changed to defrost, half of the windshield could be seen through, the other half could not due to variations on both sides which also caused condensation to form.

Transmission has rough and erratic shifts at lower speeds. Bucking and bouncing of the vehicle occurs do to the shifting.

The contact owns a 2020 Ford Ranger. The contact stated while driving at an undisclosed speed, the vehicle stalled with the check engine warning light illuminated. The vehicle was able to restart; however, the failure recurred. The vehicle was taken to the dealer where it was diagnosed with coolant intrusion into the engine, which caused a failure with the spark plugs. The contact was informed that the spark plugs needed to be replaced. Additionally, the contact was informed that an engine appearance shield needed to be installed over the engine. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 50,000.

The contact owns a 2020 Ford Ranger. The contact stated that while driving at undisclosed speeds, there was an abnormal squeaking and humming sound coming from the vehicle. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, who determined that the failure was due to the carrier bearings and there was no grease or scratches. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 64,000.

December 2024 experienced loss of power, was able to have a Certified Ford maintenance facility look at it, but found nothing, codes cleared. Codes presented were Hill Start Assist Warning, pre-collision Assist Warning, power train malfunction/reduced power. Drove the vehicle 3 hours in below zero temp. The next day after the vehicle sat in freezing temps, drove approximately 5 miles on snow covered roads when experienced loss of power. Went from 55 miles an hour to less than 10 MPH in about 200 feet. No traffic behind me, drove the remainder of the distance (another 5 miles) at 5-10 mph. Had to have the vehicle tow to a dealership where I was informed that there is a service bulletin on the throttle body. They ended up dumping approximately 2 cups of water from the throttle body. Ford replaced the throttle body at no charge. I called Ford Customer service to share my concern. The fact that the vehicle speed fell off so quickly was what prompted me to call.

At about 40,000 miles truck started jumping and hesitating under 30mph and has now gotten worse and jumping and hesitating at 65mph had it in the shop 3 times and they can't find the problem they came up with driveshaft and pinion flange. It came from Detroit and I believe it is a problem with the transmission.

1.) Ford motor company (ford) is recalling certain 2020 ranger and f-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 expedition vehicles equipped with a 'police' package. The transmission shift cable lock clip may not be fully seated, allowing the transmission to actually be in a different gear than the gear shift position selected by the driver. 2.) Ford motor company (ford) is recalling certain 2020 ford f-150, f-250, f-350, f-450, f-550, explorer, mustang, transit, expedition, escape, ranger and edge, and lincoln nautilus and corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 111, 'rear visibility.' 3.)Ford motor company (ford) is recalling certain 2020-2021 ranger super cab vehicles equipped with rear seats containing fixed head restraints. The fixed head restraints may interfere with proper installation of certain types of child seats. Additionally, the child seat may not attach properly to the lower-rear anchors. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard number 225, 'child restraint anchorage system.' 4.) Ford motor company (ford) is recalling certain 2022-2023 bronco, 2023 super duty f-250, and 2019-2023 ranger vehicles. The tire and loading information (tread) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard number 110, 'tire selection and rims.' NHTSA# FOR REPORTING 21V811000 21V765000 20V575000 20V197000

The contact owns a 2020 Ford Ranger. The contact stated that on several occasions while driving between 40-45 MPH, the vehicle began jerking and the transmission was skipping. Additionally, the vehicle lost power and was consuming an excessive amount of fuel. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 55,900.