1997 FORD TAURUS Complaints

1997 FORD TAURUS WAGON. OVER THE PAST TWO MONTHS, THE VEHICLE STOPPED DEAD IN TRAFFIC 5 TIMES AT VARIOUS SPEEDS WITH NO ADVANCE WARNING. IT WOULD NOT RESTART. THE FUSE TO THE FUEL PUMP REPEATEDLY BLEW, BUT NO OTHER PROBLEMS WERE EVIDENT EACH TIME THE CAR WAS TOWED TO THE GARAGE. THE ENGINE WOULD RUN ROUGHLY, STALL, AND SURGE, BUT THE PROBLEM WAS INTERMITTENT, AND GRADUALLY BECAME WORSE. THE MECHANIC SUSPECTED A PROBLEM WITH THE FUEL SYSTEM. AN INVESTIGATION REVEALED THAT A WIRE TO THE FUEL PUMP INSIDE THE FUEL TANK HAD ITS INSULATION WORN OFF DOWN TO THE BARE WIRE, AND HAD SHORTED OUT. OTHER WIRES ALSO SHOW SIGNS OF WEAR, BUT ARE NOT YET WORN THROUGH. I HAVE DIGITAL PICTURES OF THE WIRES. THE WIRES WERE DAMAGED DUE TO THE WAY THE FUEL PUMP WAS ASSEMBLED WITHIN THE GAS TANK. THIS IS AN OBVIOUS MANUFACTURING DEFECT AND IS NOT LIMITED TO ONLY OUR CAR. FORD HAS ISSUED 3 TSB'S RELATING TO THIS PROBLEM (98251, 5226, AND 12189) AND I HAVE ALSO FOUND SEVERAL RELATED COMPLAINTS IN THE NHTSA DATABASE (ODI ID 549996, 707889, 713208, 807546, 838030, 853283, 879245, 10018293, AND 8012733). I AM CONCERNED THAT THIS PROBLEM COULD NOT ONLY CAUSE COMPLETE VEHICLE FAILURE (LOSS OF POWER STEERING AND BRAKES) AT ANY SPEED, BUT ALSO THAT THE POSSIBILITY OF A SPARK INSIDE THE GAS TANK IS NOT OUT OF THE QUESTION. THIS WIRING PROBLEM SHOULD BE INVESTIGATED AS A POSSIBLE CAUSE FOR ANY FORD TAURUS FIRES, OR ACCIDENTS INVOLVING LOSS OF POWER. WE ARE CONVINCED THAT THIS IS A MANUFACTURING DEFECT AND THAT THE POSSIBILITY OF MORE RELATED ACCIDENTS INCREASES AS CURRENT VEHICLES AGE. FORD EVIDENTLY IS AWARE OF THIS PROBLEM, OR THEY WOULD NOT HAVE REVISED THE WIRING HARNESS AND GIVEN SPECIAL INSTALLATION INSTRUCTIONS TO THEIR TECHNICIANS. *NLM

TRANSMISSION FAILURE,KEEPS SLIPPING AND SHIFTING UP AND DOWN WHILE DRIVINGAT 65MPH. IT WILL SHIFT DOWN TO SECOND GEAR.*AK

THE AUTOMATIC TRANSMISSION FAILED TO SHIFT PROPERLY. *JB WHEN COMING TO A COMPLETE STOP AT A STOP LIGHT, ETC., THE TRANSMISSION DISENGAGES, ESPECIALLY TO THE OVERDRIVE POSITION. THE VEHICLE WON'T MOVE UNLESS THE VEHICLE REVVED. THE PROBLEM CAN IMMEDIATELY BE CORRECTED BY TURNING OFF THE ENGINE IN PARK AND RESTARTING. THIS PROBLEM USUALLY WILL OCCUR 3-4 TIME PER DAY. THE DEALER CANNOT DUPLICATE. *SCC

WHILE TRAVELING AT HIGHWAY SPEEDS, ALL THE DASH LIGHTS ILLUMINATED AND THE ENGINE SHUT OFF. THE MECHANIC STATED THE WIRING HARNESS WAS ROUTED IN A WAY WERE IT CAUSED FRICTION AND WORE OUT THE INSTALLATION WHICH CAUSED THE WIRES TO BE EXPOSED. *JB

A TICKING NOISE COULD BE HEARD FROM THE ENGINE COMPARTMENT ESPECIALLY WHEN THE CAR WAS IN IDLE. I TALKED TO A FORD DEALER AND WAS TOLD THAT THE CAMSHAFT PROBLEM WAS AFFECTING MY CAR. I WAS QUOTED AROUND $6000.00 FOR THE REPAIRS. I DID SOM RESEARCH AND FOUND THAT THE SECONDARY DRIVE GEARS FOR THE CAMSHAFTS WERE THE SOURCE OF THE NOISE. *TT

PREMATURE ENGINE AND COMPONENT FAILURE DUE TO FAULTY HEAD GASKETS. ENGINE AND TRANSMISSION FAILED AT LESS THAN 55,000 MILES.

WHILE PARKING AND APPLYING THE BRAKES THE VEHICLES AIRBAGS DEPLOYED WITHOUT WARNING. THE DEALER WAS NOTIFIED. *NLM

MY AIR BAGS DEPLOYED WITHOUT IMPACT CAUSING MY WINDSHIELD TO SMASH AND PASSENGER WINDOW TO BLOW OFF THE TRACK. MY INSURANCE WILL NOT COVER IT BECAUSE THERE WAS NO ACCIDENT. FORD MOTOR COMPANY WILL NOT STAND BEHIND THEIR PRODUCT EVEN THOUGH IT IS VERY EVIDENT THAT IT WAS A MALFUNCTION. *JB

THE VEHICLES INTERIOR LIGHTS AND DOOR AJAR CHIME CAME ON AND STAYED ON AFTER THE VEHICLE WAS STARTED. *NLM

THE TRANSMISSION LEAKED A LIQUID SUBSTANCE WHICH CAUSED THE VEHICLE TO JERK AND MADE THE GEARS DIFFICULT TO SWITCH. *JB