1997 FORD TAURUS Complaints

THE REAR CAMSHAFT SPROCKET BROKE REQUIRING THE ENGINE TO BE REPLACED. THE COST OF THE USED ENGINE WAS $2000 AND THE COST TO REPLACE THE ENGINE WAS $2100. FORD WAS CONTACTED AND REFUSED TO REPAIR OR CONTRIBUTE TO THE REPAIR COST. I UNDERSTAND THIS PROBLEM IS BECOMING WIDESPREAD.

FOOT HAD SLIPPED OFF ACCELERATOR PEDAL, AND VEHCLE HIT A TRAILER. UPON IMPACT WITH TRAILER, AIR BAGS FAILED TO DEPLOY. TOOK VEHICLE TO DEALERSHIP, AND WAS INFORMED BY MECHANIC THAT AIR BAGS WERE FAULTY. *AK

WHENEVER BRAKING BRAKE PEDAL LINKAGES WOULD FAIL TO STOP VEHICLE WHEN NEEDED.*AK

THIS PROBLEM IS WITH TAURUS, SABLE & WINDSTAR, IT CAN NOT BE REPAIRED...NOW WHAT? NO SAFETY DEFECT LISTED. *AK TSB 98-9-4 WAS ISSUED REGARDING THIS PROBLEM, THE CORRECTIVE ACTION BEING TO REPLACED THE FRONT END ACCESSORY DRIVE BELT. *SLC

THE REAR CENTER SEAT IS SUPPOSED TO BE THE SAFEST PLACE FOR A CHILD. UNFORTUNATLY THAT IS NOT THE CASE WHEN THE REAR CENTER SEAT BELT FAILS. THANKFULLY THIS INCIDENT HAPPENED WHEN OUR CAR WAS SAFELY PARKED IN OUR DRIVEWAY. MY HUSBAND HAD NOTICED THE CAR SEAT WAS LOOSE (WHICH IN ITSELF IS A DANGEROUS SITUATION CREATED BY THIS INPROPERLY FUNCTIONING SEATBELT BUCKLE) & HE TRIED TO TIGHTEN THE BELT. THE BUCKLE FELL TO PIECES ALL OVER MY BACK SEAT. IT IS GOING TO COST ME NEARLY $100 TO REPAIR THIS FAULTY SEATBELT. A SMALL PRICE FOR KEEPING MY SON SAFE (UNTIL THIS BREAKS AS WELL) . . . . BUT THIS IS GOING TO COST FORD EVEN MORE IF SOME UNSUSPECTING FAMILY IS INJURED BY THE VERY DEVICE THAT CLAIMS TO SAVE LIVES. *AK

VEHICLE WOULD NOT ACCELERATE FROM A STOPPED POSITION WITHOUT SHAKING VIOLENTLY. 57500 MILES AT THE TIME, $1900 TO FIX IT. *AK ****DIMS 11 IVOQ ENTRY POSTED AFTER 12/12/02 CUT-OVER TO ARTEMIS*****749177.

THE CAR HAD ABOUT 35,000 MILES ON IT WHEN PURDHASED IT, FACTORY WARRANTY WAS CARRIED OVER TO US AS THE NEW OWNERS. SOON AFTER THE SALE OF THE CAR TO US, FORD CAME OUT WITH A BROWN COOLANT RECALL, WHICH RAN UNTIL SEPTEMBER 1999. ALL OWNERS OF THESE 1997 TAURUS WERE SUPPOSED TO BE NOTIFIED OF THE RECALL BY MAIL. IF NOTIFIED CAR OWNERS BROUGHT THEIR CARS IN DURING THIS TIME PERIOD, THE FORD DEALERS WOULD CORRECT THE PROBLEM AT NO COST TO THE OWNER. FORD MOTOR COMPANY NEVER INFORMED US OF THIS RECALL. IT WAS NOT UNTIL SHE BROUGHT THE CAR INTO NORTH BAY FORD (IN SANTA CRUZ, CA) TO REPAIR A CRACKED COOLANT HOLDING TANK ON JULY 19, 2000, THAT SHE WAS TOLD OF THE REQUIRED RECALL WORK NEED ON HER FORD TAURUS, BUT THE WORK WAS NO LONGER COVERED UNDER A WARRANTY PAYMENT PROGRAM AND THE COST WAS NOW THE OWNERS PROBLEM AND THERE WAS NOTHING THE FORD DEALER COULD DO ABOUT IT. AT THIS TIME WE PAID THE BILL, WHICH WAS OVER $500. THE BROWN COOLANT RECALL PROGRAM WAS REQUIRED BECAUSE OF A DESIGN ERROR IN THE ROUTING OF THE COOLING SYSTEM HOSES INTO AND OUT OF THE DASH HEATER COIL AND THE PROXIMITY OF THE HOSES AROUND THE ENGINE EXHAUST MANIFOLD. THE RESULT WAS THAT THIS PROBLEM CAUSED THE COOLANT TO TURN INTO BROWN MUD FROM EXCESSIVE RUSTING OF THE ENGINE BLOCK. WE NEVER EXPERIENCED ANY OVER HEATING PROBLEMS WITH THE CAR UNTIL THE COOLANT TANK BEGAN LEAKING. NOW, BECAUSE OF THE EXCESSIVE RUST IN THE COOLANT, A GALVANIC REACTION DEVELOPS WITH FREEZE PLUGS IN THE ENGINE BLOCK. THE DEALER INSISTED ON CHANGING THE PLUGS, BUT HE ONLY CHANGED 2 OF THE 4 PLUGS. THE JOB ALSO INCLUDED A COMPLETE ENGINE FLUSHING TO REMOVE ALL THE OLD RUSTY COOLANT. ON JULY 7, 2001, BROWN COOLANT BEGAN RUNNING OUT ONTO THE GROUND FOR THE SECOND TIME WHICH REQUIRED ANOTHER $500 TO REPAIR. FORD MOTORS WILL NOT DO ANYTHING TO COVER THE COST OF THERE ENGINEERING ERROR. *AK

A RECALL FOR BROWN COOLANT HAD BEEN PERFORMED ON THE CAR IN DECEMBER OF 1998. THE BROWN COOLANT FROM WHAT I UNDERSTAND NOW WAS RUST. THE DEALERSHIP REPLACED TWO FREEZE PLUGS, HOWEVER THE PLUGS USED ARE NOT THE SAME AS THE ORIGINAL. THE NEW PLUGS WERE HELD ON WITH A CLAMP. IT TURNS OUT THAT THE RUST WAS ALREADY IN THE COOLANT SYSTEM AND AFTER TWO AND A HALF YEARS AND APPROXIMATELY 30,000 MILES LATER THE CLAMP RUSTED OUT AND THE COOLANT POORED OUT OF THE CAR WHICH IN TURN CAUSED THE CYLINDER TO CRACK AND BURN TWO HEAD GASKETS. APPARENTLY THEIR RECALL WAS A BANDAID THAT DIDN'T HEAL THE WOUND AND ONLY CAUSED FURTHER DAMAGE OVER TIME.*AK

CONSUMER HAS PROBLEMS WITH ENGINE WHEN VEHICLE REACHES SPEEDS ABOVE 35-MPH ENIGNE WILL STALL. THIS IS AN INTERMITTENT PROBLEM. HAS NOT CONTACTED DEALER.*AK

ERRATIC LOSS OF POWER ASSSITED STEERING AFTER A FEW MINUTES OF DRIVING, SOMETIMES WITH SEAT BELT LIGHT ON AND POWER WINDOW CONTROL INOPERATIVE. CHATTERING NOISE SUGGESTS AN ELETRICAL PROBLEM. DEFINITELY DANGEROUS IF LOSS OR REGAIN OF POWER ASSISTED STEERING HAPPENS DUE TO OVER OR UNDER STEERING. *AK