1991 FORD THUNDERBIRD Complaints

LOSS OF HYDRAULIC BRAKE ASSIST ON SUPER COUPE. PEDAL BECAME HARD TO PRESS. BOTH BRAKE AND ABS ANNUNCIATORS ILLUMINATING. TROUBLESHOOTING INDICATES BRAKE PRESSURE SWITCH FAILING TO SIGNAL PUMP TO CHARGE SYSTEM OR ACCUMULATOR HAS FAILED. MASTER CYLINDER AND ABS SYSTEM ARE ORIGINAL EQUIPMENT AND THUS 24 YEARS OLD.

WHILE THE CONSUMER WAS DRIVING ON THE HIGHWAY THE ACCELERATOR BECAME STRUCK. AS A RESULT THE VEHICLE CONTINUED TO ACCELERATE UNTIL THE BRAKE PEDAL AND EMERGENCY BRAKE WERE APPLIED. *AK *NM

PLASTIC BUSHINGS IN BOTH ENDS OF WINDSHIELD WIPER TIE-ROD COMPONENT HAVE WORN. CAUSES WIPERS TO MOVE LESS, SKIP, AND LOSE ABILITY TO CLEAR ENTIRE WINDSHIELD. TIE-ROD MAY BECOME DISCONNECTED FROM MOTOR END OR FROM WIPER END. CAR HAS LESS THAN 57000 MILES.*AK

DEFECTIVE HEADLAMP CIRCUIT BREAKER CAUSES HEADLIGHTS TO FLASH OFF AND ON REPEATEDLY. FIRST FAILURE OCCURRED WHEN CAR WAS 2 YEARS OLD, SECOND FAILURE IN THE LAST YEAR. CAR HAS LESS THAN 57,000 MILES. 1991 SUPERCOUPE MODEL HAS FOGLAMPS AS DO THE 1992 AND LATER THUNDERBIRD MODELS FOR WHICH A RECALL EXISTS.*AK

3.8L V6 ENGINE OVER-HEATED DUE TO HEAD GASKET FAILURE IN #4 CYLINDER. BOTH HEADS WERE REWORKED AND GASKETS REPLACED. AFTER REPAIR ENGINE STARTED STALLING. IDLE AIR CONTROL VALVE WAS THEN REPLACED. NOW THERE IS A FLUCTUATION IN OIL PRESSURE. PRIOR TO HEAD GASKET FAILURE, POWER STEERING PUMP HAS TO BE REPLACED.*AK

OVERHEATING AT FIRST THEN AFTER THE HEADGASKETS WERE REPLACED THE ROD BEARINGS FAILED WHICH ADDED ANOTHER 1200.00 TO THE 1645.00 OF THE FIRST REPAIR AND THE POWER STEERING PUMP WAS REPLACED AT THE TIME OF THE FIRST REPAIR.

HEAD GASKET FAILURE AT 73,000 ON MY 1991 TBIRD WITH THE 3.8 V6. LOOKS LIKE FORD IS TRYING TO COVER THIS UP! *NLM

WINDSHIELD WIPERS FREEZE UP WHEN WIPERS ARE TURNED ON HIGH. THIS IS A SIMILAR DEFECT TO THE "NHTSA CAMPAIGN ID NUMBER: 91V076000" PROBLEM I CAN NOT USE THE MY CAR WIPERS ON HIGH IN THE RAIN. *AK

ENGINE HAS BEEN REPLACED TWICE ALREADY AND NEEDS TO GO IN AGAIN BECAUSE OF HEAD GASKET BLOWING OUT. CONTACTED DEALER. *AK

WHILE DRIVING HEARS A LOUD BEEP COMING FROM FRONT OF VEHICLE. CAN'T ACTUALLY TELL WHERE BEEP IS COMING FROM. PLEASE ADD VIN. *AK