2014 FORD TRANSIT CONNECT Complaints

MY FORD TRANSIT CONNECT REAR LIFT-GATE WOULD NOT OPEN. STATIONARY. ALL DOOR LOCKS WORKED WITH THE KEY FOB EXCEPT THE REAR LIFT-GATE. THE LIFT-GATE WOULD NOT WORK WITH THE INTERIOR DOOR LOCK ELECTRIC SWITCHES. I WAS UNABLE TO OPEN THE LIFT-GATE IN ANY MANNER. THE LIFT-GATE DOES NOT HAVE A LOCK OPERATED BY A KEY, JUST AN ELECTRONIC SWITCH. I CHECKED THE 10AMP FUSE FOR THE REAR LIFT-GATE LOCK AND IT WAS DEFECTIVE. I REPLACED THE FUSE AND THE DOOR WORKED FOR ABOUT A WEEK BEFORE BREAKING AGAIN. I REPLACED THE 10 AMP FUSE 4 MORE TIMES, EACH TIME IMMEDIATELY BLOWING THE FUSE. AFTER READING 2 SIMILAR ONLINE ISSUES ABOUT THIS, MY OPERATIONAL THEORY WAS THAT THE ELECTRICAL WIRES POWERING THE REAR LIFT-GATE SWITCH WERE "SHORTING OUT". THE MOST LIKELY PLACE WAS THE AREA WHERE THE WIRES PASSED FROM THE CAR BODY TO THE REAR LIFT-GATE. HOWEVER, SINCE I WAS UNABLE TO OPEN THE LIFT-GATE, I WAS NOT ABLE TO ACCESS THE WIRES. I TOOK THE TRANSIT CONNECT TO THE CLOSEST FORD SERVICE FACILITY, AND THEY FIXED THE PROBLEM. THE SERVICE PERSON REMOVED THE PROTECTIVE RUBBER SLEEVE COVERING THE WIRES EXITING FROM THE RIGHT SIDE OF THE TRANSIT CHASSIS TO THE RIGHT SIDE OF THE LIFT-GATE. ONE COULD EASILY SEE A NUMBER OF BLACK WIRES WITH INSULATION MISSING AND EXPOSED COPPER WIRE. THE WIRES WERE CONTACTING EACH OTHER AND/OR THE METAL WHERE THE WIRES EXIT THE CHASSIS. I DO NOT KNOW WHAT THE OTHER WIRES OPERATE, BUT THE REARVIEW CAMERA HAD BEEN INTERMITTENTLY MALFUNCTIONING FOR MONTHS. (CAR IN MOTION, BACKING UP) I FEEL THIS TO BE A DANGEROUS SITUATION, FOR THE SHORTING WIRES ARE IN THE APPROXIMATE VICINITY OF THE GAS FILL SPOUT INSIDE THE CHASSIS. GAS VAPORS COULD IGNITE. THIS IS POTENTIALLY A DANGEROUS SITUATION.

MOTOR HAS A KNOCKING / TAPPING NOICE THAT SOUNDS LIKE IT'S COMING FROM BETWEEN THE CYLINDERS 2 AND 3. THE CAR HAD LOW COOLANT ALSO WHICH IS A LINK TO A CRACK IN THE BLOCK. HTTPS://YOUTU.BE/N0JYS2TEXDK

AT 76K MILES THE TRANSMISSION BEGAN SLIPPING AND MISSING SHIFTS FROM BOTH REVERSE AND DRIVE SELECTIONS, EITHER HOT OR COLD. 1ST AND 2ND GEAR ARE WHERE THIS ISSUE IS MOST ACUTE. IT OCCURS WHEN ACCELERATING FROM A STOP AND ALSO WHEN DECELERATING. GATOR FORD STATED TRANSMISSION NEEDED TO BE REPLACED AT CONSIDERABLE COST. ALSO STATED FLUID WAS BURNT AND METAL FOUND IN PAN. ALL SERVICE WITH EXCEPTION OF LAST OIL CHANGE WAS CONDUCTED AT DEALER SINCE PURCHASED NEW. AT NO TIME WERE WE INFORMED OF ANY TRANSMISSION FLUID BREAK DOWN. DEALER PROVIDED LIST OF FAULT CODES WHICH DID NOT TRIGGER DASH INDICATOR OF ANY KIND.

TL* THE CONTACT OWNS A 2014 FORD TRANSIT CONNECT. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SUDDENLY STALLED AND SHUT OFF. THE VEHICLE WAS TOWED TO STAR LAKE FORD (1212 MAIN ST, BURGESS TOWN, PA) WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP WAS FAULTY. THE FUEL PUMP WAS REPLACED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO KENNY ROSS FORD (3200 LIBRARY RD, CASTLE SHANNON, PA) WHERE THE FUEL PUMP WAS REPLACED, BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES AND PROVIDED CASE* NUMBERS:[XXX] AND [XXX]). THE FAILURE MILEAGE WAS 26,000. *PM CONSUMER STATED 3 TIMES ENGINE STOPPED RUNNING TWICE ENGINE WOULD NOT START. VEHICLE WAS TOWED AWAY 5 TIMES. ('PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'),*JB

AFTER OWNING THIS VEHICLE THE HORN QUIT, AT 49865 MILES. I CHECKED THE INTERNET AND FOUND SEVERAL OTHER PEOPLE WHO HAD THIS PROBLEM ON A FORD VEHICLE SIMILAR TO MINE. THE REPAIR SEEMS SIMPLE BUT I FEEL THAT THIS IS A SAFETY ISSUE WITHOUT AN HORN. THE HORN STARTED NOT WORKING ON AND OFF THEN QUIT COMPLETELY. THE HORN WOULD NOT WORK WHETHER MOVING OR STATIONARY.

TL* THE CONTACT OWNS A 2014 FORD TRANSIT CONNECT. WHILE DRIVING 60 MPH, THE LOW BEAM HEADLIGHTS FAILED TO PRODUCE ADEQUATE LIGHTING PAST SIXTY FEET. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO IRISH HILLS FORD (10405 BROOKLYN RD, BROOKLYN, MI 49230, (517) 592-2112) WHERE IT WAS DIAGNOSED THAT THE VEHICLE WAS OPERATING AS DESIGNED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 50,000.

THE MIDDLE ROW SEATS ARE DEFECTIVE. THEY FOLD DOWN BUT WILL NOT COME BACK UP. THEY ARE STUCK IN THE DOWN POSITION. I BROUGHT THE CAR IN TO A FORD DEALER'S SERVICE DEPARTMENT, AND THEY'VE NOW HAD IT FOR 3 DAYS TRYING TO FIGURE OUT HOW TO FIX THE PROBLEM. AT THIS POINT THEY HAVE TOLD ME THAT THERE IS SOMETHING WRONG WITH THE MANUFACTURE OF THE MECHANISM IN THE SEATBACK THAT CONTROLS THE SEAT FOLDING FUNCTION, AND THAT THE ONLY WAY THEY CAN FIX IT IS TO INSTALL A NEW SEAT. THE DEALERSHIP'S SERVICE DEPT HAS QUOTED $2000 FOR IT AS AN OUT-OF-WARRANTY REPAIR. IN SEARCHING ONLINE, I SEE THAT THIS IS A COMMON PROBLEM WITH THIS VEHICLE MODEL. I'VE SEEN THAT THERE ARE TSBS ISSUED FOR THIS PROBLEM. BUT WHEN THE DEALER PUTS MY VIN INTO THEIR SYSTEM, MY VEHICLE DOESN'T SHOW UP AS PART OF THE RECALL. I BELIEVE THIS SHOULD BE A NEW RECALL, OR AN EXPANDED RECALL, TO FIX A PROBLEM THAT FORD SEEMS TO ALREADY KNOW IT HAS -- THEY JUST HAVEN'T ACKNOWLEDGED EVERY MODEL OR YEAR THAT IT EFFECTS. ADDITIONALLY, THERE IS AN ISSUE WITH THE SOFTWARE RUNNING THE CAR'S CLOCK -- WHEN THE CAR BATTERY IS LOW, THE CLOCK STOPS WORKING, AND WILL NOT ALLOW THE USER TO RESET IT TO THE CORRECT TIME. THE DEALER SAID THAT THE ONLY WAY THEY CAN FIX IT IS TO DO A SOFTWARE UPGRADE AT A COST OF $140 - $280 EACH TIME. THIS IS ALSO A WELL-KNOWN PROBLEM ACCORDING TO MANY FORD CONSUMER MESSAGE BOARDS. I'M NOT SURE IF THIS QUALIFIES FOR A RECALL AS WELL, BUT IT SEEMS LIKE A KNOWN DEFECT THAT PUTS THE VEHICLE OWNER AT A FINANCIAL DISADVANTAGE.

THE WINDOW VISORS WILL NOT STAY UP. YOU PULL THEM DOWN TO USE AND PUT UP AFTERWARDS AND THEY FALL BACK DOWN WHILE DRIVING.

MY FAMILY ENTERED VEHICLE THRU REAR SLIDING DOORS. CLOSED DOORS AND PUT ON THEIR SEAT BELTS. WE DROVE APPROX 1/3 OF A MILE AND THE REAR DRIVER SIDE SLIDER FLEW OPEN IN A CORNER.COMPLETE LATCH FAILURE! THESE LATCHES WERE REPLACED AS PART OF THE 2016 RECALL.

POSSIBLE BCM ISSUE. THE BATTERY DRAINS WITH THE BCM FUSE INSTALLED. THE FUSE PULLED STOPS THE BATTERY DRAIN ISSUE. THE BATTER WAS REPLACED AND SAME ISSUE OCCURS. BATTERY DRAIN OCCURS OVERNIGHT. SECOND ISSUE. THE TRANSMISSION SHIFTS ROUGH BETWEEN FIRST AND SECOND GEAR, AND BUMPS AT HIGHWAY SPEEDS WHEN ACCELERATING. HAVE TAKEN THE VEHICLE TO THE DEALER FIVE TIMES. TRANSMISSION OVERHAULED, BUT ISSUE CONTINUES. HAVE GOTTEN TRANSMISSION FAILURE WARNING SIGN.