2001 FORD WINDSTAR Complaints

TL* THE CONTACT OWNS A 2001 FORD WINDSTAR. THE DEALER (RUSS MILNE FORD, 24777 HALL RD, MACOMB, MI 48042, (877) 821-8648) INDICATED THAT A RECALL REMEDY WAS PROVIDED FOR THE REPLACEMENT BRACKETS BEFORE THE CONTACT OWNED THE VEHICLE. WITHIN A YEAR OF OWNING THE VEHICLE, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT A RECALL HAD ALREADY BEEN PROVIDED. ALTHOUGH THE CONTACT INFORMED THE MANUFACTURER THAT THE RECALL REMEDY FAILED TO CORRECT THE FAILURE, THEY STATED THAT THE CONTACT WOULD NEED TO REPAIR THE VEHICLE. IN ADDITION, THE ENGINE CRADLE WAS COMPLETELY RUSTED TO THE POINT OF FRACTURING, CAUSING SHAKING AND A STRONG VIBRATION. THE FAILURE MILEAGE WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2001 FORD WINDSTAR. WHILE STATIONARY, THE CONTACT NOTICED THAT THE FRONT ENGINE CRADLE OF THE VEHICLE WAS SEVERELY RUSTED AND CORRODED. THE CONTACT STATED THAT THERE WERE HOLES IN THE ENGINE CRADLE. MATTHEWS FORD OREGON IN OREGON, OHIO WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS 190,000.

TL* THE CONTACT OWNS A 2001 FORD WINDSTAR. WHILE DRIVING 35 MPH, THE AXLE FRACTURED. THE VEHICLE WAS TOWED TO RICART FORD (4255 S HAMILTON RD, GROVEPORT, OH 43125) WHERE IT WAS DIAGNOSED THAT THE REAR AXLE NEEDED TO BE REPLACED. THE REPAIR WAS NO LONGER COVERED UNDER NHTSA CAMPAIGN NUMBER: 15V608000 (SUSPENSION). THE LOCAL DEALER CONTACTED THE MANUFACTURER AND WAS INFORMED THAT THEY WOULD COVER THE INSPECTION; HOWEVER, THE VEHICLE REPAIRS WOULD BE THE CONTACT'S RESPONSIBILITY. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2001 FORD WINDSTAR. THE CONTACT RECEIVED NOTIFICATION OF AN UNKNOWN RECALL REGARDING THE REAR AXLE. THE CONTACT TOOK THE VEHICLE TO BLACKWELL FORD INC (41001 PLYMOUTH RD, PLYMOUTH, MI 48170; 734-453-1100) WHERE IT WAS DETERMINED THAT A REPAIR WAS NOT NEEDED. THE RECALL WAS DEEMED COMPLETED. APPROXIMATELY TWO YEARS AFTER THE RECALL, THE VEHICLE UNDERWENT ROUTINE INSPECTION AND IT WAS DIAGNOSED THAT THE REAR AXLE FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO INFORMED THE CONTACT THAT, DUE TO THE VEHICLE PASSING INSPECTION FOR THE RECALL, THEY WERE UNABLE TO PROVIDE THE REPAIR. THE APPROXIMATE FAILURE MILEAGE WAS 113,628.

REPLACED FUEL PUMP AND GAS GAUGE IS SHOWING EMPTY WHEN THERE IS 10 GALLONS OF GAS IN THE TANK. I HAVE TRIED TO RESET IT BUT THAT DOESN'T WORK. PLEASE RECALL THIS AND FIX THEM. I DO A LOT OF TRAVELING AND I DO NOT WANT TO TAKE THE CHANCE OF RUNNING OUT OF GAS.

OVER DRIVE FLASHING OFF AND ON WILL NOT GO OFF. FUSES BLOW OUT RIGHT AFTER YOU START UP THE VAN. IT STARTED WHEN I MADE A TURN AT A GREEN LIGHT. ON THE BACK ROADS.

2001 FORD WINDSTAR REAR AXEL CRACKED WHILE DRIVING ON THE CITY STREETS . I SEE RECALLS FOR OTHER SIMILAR VEHICLES FOR THE SAME PROBLEM.

I WAS DRIVING AT AROUND 30 MPH, 2 CARS IN FRONT SLAMMED ON BRAKES, I WAS APPROXIMATELY 1 1/2 CAR LINKS BACK AND HIT THE BRAKES. ABS FAILED, AIRBAGS FAILED, AND SLID INTO CAR IN FRONT OF ME. I WAS ON A CITY STREET GOING STRAIGHT.

TL* THE CONTACT OWNS A 2001 FORD WINDSTAR. WHILE DRIVING 5 MPH, THE SUBFRAME COMPLETELY FRACTURED AND FELL APART WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC (SPIELMANN SERVICE CENTER MN; 952-546-0508) WHERE IT WAS CONFIRMED THAT FORD WOULD NOT PAY FOR THE DAMAGE. THE VEHICLE WAS TOWED TO THE DEALER (LUTHER NORTH COUNTRY FORD, LOCATED AT 10401 WOODCREST DR NW, COON RAPIDS, MN 55433; (612) 424-7648) WHERE IT WAS DIAGNOSED THAT THE ENGINE, TRANSMISSION, AND DRIVE TRAIN NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AT 800-392-3673 AND STATED THAT ONLY THE SUBFRAME COULD BE REPAIRED FOR FREE, BUT THE DAMAGE FOR THE ENGINE, TRANSMISSION, AND DRIVE TRAIN WOULD HAVE TO BE PAID FOR BY THE CONTACT. A CASE NUMBER WAS NOT PROVIDED. THE APPROXIMATE FAILURE MILEAGE WAS 184,500.

A MAJOR CRACK IN THE REAR AXLE BEAM WAS DISCOVERED DURING ROUTINE MAINTENANCE RENDERING THE VEHICLE UNSAFE FOR USE. FORD HAD A RECALL TO FIX THIS PROBLEM, BUT MY VEHICLE WAS NOT INCLUDED IN THE RECALL BECAUSE THE VEHICLE WAS NOT SOLD IN A STATE THAT USED SALT ON THE ROADS IN WINTER (I LIVE IN FLORIDA WHERE THERE IS A LOT OF SALT IN THE AIR - ALL THE TIME!) I BELIEVE THAT ALL WINDSTARS SHOULD HAVE BEEN INCLUDED IN THE RECALL BECAUSE IT IS OBVIOUSLY A MAJOR DESIGN FLAW AND THEREFORE A MAJOR SAFETY ISSUE.