FREIGHTLINER Complaints

Cruise control will shut off and then engage again on its own. It will have a hard time to disengage at times. Lane departure goes off when there is nothing there. The collision warning system goes off a lot. Locked up the brakes in the rain causing a slide. Locked up on ice almost causing a jackknife. Then this summer it has locked up when nothing is around. Came to a complete stop, then not releasing the brakes for a few seconds. Luckily, no one was around. It has been in for repair several times. It is in the shop now. I lease this vehicle from Penske. They refuse to give me a safe truck.

TIRE SIZE: 275/80 R22.5 MICHELIN ENERGY LINE Z Component that failed is drivers side steer front tire. The tire blew out and resulted in loss of vehicle control. This failure DID cause an accident putting others safety at risk. Both Freightliner Corp. and Michelin Tire Co. are aware of this failure. No one has inspected the tire. I DO NOT have the tire in my possession yet. There are/were no warning, messages or symptoms of this problem prior to. This truck had a right side tire failure at the decoupling groove on May 11, 2022. The tire was replaced at that time with a new tire tire. This truck returned to Toledo Ohio to our terminal. The 4X4X4 air fairings were then removed at the request of DTNA. On 8-5-22 with 52,742 miles on the tire, it blew out resulting in an accident.

TIRE SIZE: 275/80 R22.5 MICHELIN ENERGY LINE Z Component that failed is passenger side steer front tire. The inside edge decoupling groove/sidewall failed. Risks include potential tire blow resulting in loss of vehicle control. This failure could cause an accident putting others safety at risk. Both Freightliner Corp. and Michelin Tire Co. are aware of this failure. No one has inspected the tire. I have the tire in my possession. There are/were no warning, messages or symptoms of this problem prior to. This truck was built with a 6X4X6 front air fairing. Mileage on tire at the time of failure was 68,686 miles. This truck is a test with Con Met Corp. and Freightliner Corp. New tires were installed at 474,452 miles along with heat sensors to monitor the heat temperature under the truck. At 526,168 miles I reported the passenger side, inside edge steer was starting to wear a decoupling groove. This was very slight. Tire was not changed. Pursuant to the Michelin Technical Bulletin of 1-2-2022 the tire was inspected every Monday when truck returns to our terminal. On July 13, 2022 the tire psi was checked to verify 110 psi as recommended by Michelin Corp. At 543,148 miles the tire failed. 2 new steer tires installed and the air fairings were removed as recommended by DTNA engineers. Side wall of tire shows excessive heat. Tire was close to blowing. Please review pictures.

I am experiencing cold start hesitation and unresponsive throttle at high elevation. The vehicle takes up to 20-30 seconds to accelerate, and puts me in a dangerous situation (in a highway intersection, for example). Once the engine temperature is warm, this issue goes away.

______________________________________________________________________________ Last October 2021 I bought truck Freightliner Cascadia 2016. Vin # [XXX]. Mileage: 477400. Last my trip I made in May 2022 from Nogales, AZ to Boise, ID When I approaching Ely, NV about 5-8 miles I drive down from the mountain hill . I used speed 25-30 MPH, suddenly my steering wheel was locked and did not made right turn. I used hardly brake because my truck was out of control and pulled forward shoulder out of highway. Only because I hardly used brake I save my lives. When I stopped before roll over from highway I lightly make right turn steering wheel and left turn steering wheel was unlocked. When I reach Loves truck Stop in Ely, NV it is repeated 3 times. I just lightly made right turn steering wheel and left turn wheel unlocked again. Now I want to inform You Freightliner Cascadia 2016 is very danger truck to use on road in the USA. Inventors from freightliner must recall this truck and fined out mistakes in steering Column Why steering Column? Because from 2004 I used Volvo 780. Now my Volvo truck pass 2 000 000. ( two million miles) About after 950 000 I fined out power steering pump not working correctly. When I used steering wheel on low RPM , steering wheel unable made right or left, but when I increase RPM it worked correctly. I install new steering pump and forgot for this problem. In my case on low RPM Freightliner steering Wheel working good, and it happened because something wrong with steering column. In Ely, NV I made exchanged steering oil. After exchanged steering Oil I safety reached Boise, ID. In my Volvo truck I exchanged steering oil about 11-12 times just when my steering wheel worked tight on low RPM I checked Steering Oil filter and Chengde Oil, and Volvo steering wheel never locked steering wheel like on Freightliner Cascadia. I send N INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

TIRE SIZE: 275/80 R22.5 MICHELIN ENERGY LINE Z Component that failed is passenger side steer front tire. The outside edge decoupling groove/sidewall failed. Risks include potential tire blow resulting in loss of vehicle control. This failure could cause an accident putting others safety at risk. Both Freightliner Corp. and Michelin Tire Co. are aware of this failure. No one has inspected the tire. I have the tire in my possession. There are/were no warning, messages or symptoms of this problem prior to. Michelin Tire Co. sent us 2 new tires and requested we remove the air fairing to see if this could resolve the problem. At the time we proceeded with this request the truck had 315,805 miles on it. On 6-20-22 Michelin Tire Co. supplied Freightliner Corp. with a tech bulletin regarding the decoupling groove failure. At 455,485 miles this tire was showing signs of decoupling failure. This failure appeared to be within the guide lines of the tech bulletin. At 465,523 miles the tire showed excessive decoupling groove failure in multiple spots. Mileage on tire at the time of failure was 149,718 miles.

TIRE SIZE: 275/80 R22.5 MICHELIN ENERGY LINE Z Component that failed is passenger side steer front tire. The inside edge decoupling groove/sidewall failed. Risks include potential tire blow resulting in loss of vehicle control. This failure could cause an accident putting others safety at risk. Both Freightliner Corp. and Michelin Tire Co. are aware of this failure. No one has inspected the tire. I have the tire in my possession. There are/were no warning, messages or symptoms of this problem prior to. This truck was built with a 4X4X4 front air fairing that was removed after this failure by the request of Freighliner Corp. Mileage on tire at the time of failure was 85,982 miles.

TIRE SIZE: 275/80 R22.5 MICHELIN ENERGY LINE Z Component that failed is the passenger steer front tire. The outside edge decoupling groove/sidewall failed. Risks include potential tire blow resulting in loss of vehicle control. This failure could cause an accident putting others safety at risk. Both Freightliner Corp. and Michelin Tire Co. are aware of this failure. No one has inspected the tire. I have the tire in my possession. There are/were no warning, messages or symptoms of this problem prior to. This truck was built with a 4X4X4 front air fairing that was removed after this failure by the request of Freighliner Corp. Mileage on tire at the time of failure was 71,000 miles.

TIRE SIZE: 275/80 R22.5 MICHELIN ENERGY LINE Z Component that failed is drivers side steer front tire. The outside edge decoupling groove/sidewall failed. Risks include potential tire blow resulting in loss of vehicle control. This failure could cause an accident putting others safety at risk. Both Freightliner Corp. and Michelin Tire Co. are aware of this failure. No one has inspected the tire. I have the tire in my possession. There are/were no warning, messages or symptoms of this problem prior to. This truck was built with a 4X4X4 front air fairing that was removed after this failure by the request of Freighliner Corp. Mileage on tire at the time of failure was 165,782 miles.

TIRE SIZE: 275/80 R22.5 MICHELIN ENERGY LINE Z Component that failed is the passenger side steer front tire. The inside edge decoupling groove failed. Risks include a potential tire blow resulting in loss of vehicle control. This failure could cause an accident putting others safety at risk. Both Freightliner and Michelin Tire Co. are aware of this failure. Michelin tire representative has visually inspected the tire and asked to have the tire returned to the Michelin Company for further inspection. I have not released the tire to them yet. There are/were no warnings, messages or symptoms of this problem prior to. This truck was built with 4X4X4 front air fairing that was removed after this failure by the request of the Freightliner Corp. The mileage on the tire at the time of failure was, 89,490 miles.