1994 GEO METRO Complaints

ALTERNATOR BELT KEEPS POPPING OFF, CAUSING VEHICLE TO STALL POSSIBLY DUE TO A DEFECT IN PULLEY , CONSUMER HAS REPLACED BELT 4 TIMES.*AK

CAR HAS GREAT GAS MILEAGE BUT HAS DEADLY STRUCTURAL,SAFETY AND COMFORT DESIGN FLAWS

TURN SIGNALS BEGAN TO WORK INTERMITTENTLY EVEN THOUGH I CLEANED SOCKETS AND REPLACED BULBS. THEN HEADLIGHTS FAILED AT 2AM 0N 11/15/99 AND I TOOK THE CAR TO THE DEALER THAT AFTERNOON. THEY FOUND THE HARNESS SHORTING OUT INTERMITTENTLY AND THEY REPLACED IT. LOOKING AT THE PLUG-INS ONE OF THEM LOOKED DISCOLORED FROM THE SHORTING OUT. *AK

THE METAL ATTACHMENT ON THE UNDERSIDE OF THE HOOD THAT LOCKS INTO THE HOOD LATCH IS RIPPING LOOSE FROM THE HOOD. THE PROBLEM HAS BEEN REPORTED TO THE DEALERSHIP. THE DEALERSHIP WOULD NOT REPAIR THE PROBLEM BECAUSE OF LIABILITY. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK

CONSUMER WAS REAR ENDED AT VERY HIGH SPEED IN WHICH DRIVER'S AND PASSENGER'S SEATBACKS COLLAPSED FROM THE UPRIGHT POSITION. PLEASE GIVE ANY FURTHER DETAILS. *AK

REAR DRIVER'S AND PASSENGER'S DOOR LOCKS ARE INOPERABLE. PASSENGERS CANNOT ENTER OR EXIT THE VEHICLE FROM THE REAR DOORS. CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS. *AK

VEHICLE CAUGHT ON FIRE IN THE ENGINE COMPARTMENT WITHOUT PRIOR WARNING. NO ONE HAS INSPECTED THE VEHICLE YET. PLEASE PROVIDE FURTHER INFORMATION AND VIN#. *AK

THE ENGINE OF THE 1994 GEO METRO HAVE FAILED 3 TIMES AT A TOP SPEED OF 60MPH. EACH TIME THERE IS ENGINE FAILURE, IT LOOSES DECOMPRESSION. ONCE THE ENGINE LOOSES DECOMPRESSION, THE VALVES BURN AND/OR TWIST. THREE TIMES WE HAVE HAD THE BLOCK HEAD REMOVED, THE VALVES REDONE AND EACH TIME THE ENGINE FAILS AGAIN. THE LAST TIME THE ENGINE FAILED, TOP SPEED WAS 55MPH AFTER 10 MINUTES OF DRIVING. THE CHEVROLET MANUFACTURER SAYS THERE HAVE BEEN NO RECALLS OF THIS ENGINE OR MAKE/MODEL. EVEN THOUGH WE PURCHASED IT USED WITHOUT WARRANTIES, WE HAVE SPENT THOUSANDS OF DOLLARS FOR THIS VEHICLE THAT CONTINUOUSLY FAILS TO OPERATE. THE DEALER REFUSED TO REPLACE THE UNIT AFTER OUR REPEATED REPORTING OF OTHER PROBLEMS PRIOR TO OUR EXPERIENCE WITH ENGINE FAILURE. CAN YOU HELP US?

IN DRIVING THE CAR 30.000 MILES, I HAVE PUT ON FOUR SETS OF ROTORS, SOMETHING THAT IS WRONG WITH THE CAR KEEPS MAKING THEM "RUT OUT"....A NEW SET OF ROTORS ONLY WORKS FOR ABOUT 3 MONTHS....I KNOW THERE HAS TO BE SOME TYPE OF DEFECT WITH THE FRONT END BRAKING SYSTEM, BUT CHEVY REFUSED TO CHECK INTO IT FOR ME

WHILE DRIVING APPROX. 15MPH, THE FRONT AXLE FELL OUT OF THE HOLE. THIS CAUSED THE VEHICLE TO SLAM TO THE GROUND DUE TO A DEFECTIVE BOLT IN THE AXLE. THE MECHANIC SAID IT SHOULD NOT HAVE FALLEN OUT & DID NOT KNOW WHAT HAD HAPPENED. *AK