GEO Complaints

AIR BAG LIGHT STAYS ON. AIR BAGS DEACTIVATED WITHOUT WARNING. VEHICLE WAS NOT IN A COLLISION. CONTACT DEALER.*AK

WHEN IT RAINS WATER GETS INTO THE VEHICLE AND SATURATES FLOOR AND THE WIRES. VEHICLE HAS A MILDEW SMELL WHICH CAUSES THE CONSUMER TO GET SICK. CONTACTED DEALER. *AK

DEFROSTER WAS INOPERATIVE. WHEN TURNING ON DEFROSTER IT WOULD FOG UP WINDOWS. CONTACTED DEALER.*AK

WHILE BUCKLING DRIVER IN SEAT BEL SEAT BELT BOLT BECAME UNDONE, AND CONSUMER WAS NOT RESTRAINT. PLEASE PROVIDE FURTHER INFORMATION. *AK

HEADLIGHT SWITCH ON TURNSIGNAL ARM GOES OFF CAUSING LIGHTS TO GO OUT. BAD SWICTH AND BRIGHT LIGHT SWITCH CAUSE BLACKOUT WHILE DRIVING.*AK

HEADLIGHTS WOULD GO OUT WHILE DRIVING. DEALER AND MANUFACTURER WERE NOTIFIED AND INFORMED THAT NO RECALL IS OPEN FOR THAT PROBLEM, FEEL FREE TO PROVIDE ANY FURTHER DETAILS ON THIS MATTER.*AK

DEAR SIR OR MADAM: I OWN A 1993 GEO PRIZM. TWICE, I HAVE HAD THE EXHAUST MANIFOLD REPAIRED BY A WELDER BECAUSE IT WAS CRACKED AND LEAKING EXHAUST FUMES INTO THE VEHICLE. DESPITE THE WELDER'S BEST EFFORTS, THE MANIFOLD KEEPS DEVELOPING MORE CRACKS. I WANTED TO REPLACE IT WITH A USED MANIFOLD. HOWEVER, A CALL TO SEVERAL SALVAGE YARDS REVEALED THAT IT'S VERY HARD TO OBTAIN A GOOD, USED MANIFOLD FOR THAT VEHICLE. THE REASON IS THAT SO MANY OF THE 1993 PRIZMS THAT ARE IN SALVAGE YARDS ALREADY HAVE CRACKED MANIFOLDS. IT SEEMS TO BE COMMON AMONG THAT MAKE AND MODEL. SHOULDN'T YOUR ORGANIZATION BE CONCERNED WITH WHAT MAY BE A SERIOUS SAFETY ISSUE IN THESE VEHICLES? I THOUGHT SO, AND THAT'S WHY I'M WRITING, TODAY.*AK

FOR THE LAST 4YRS. I HAVE HAD TROUBLE AT START-UP,IDLE,DRIVABILITY OF THE ENGINE. ALL SENSORS RELATED TO THE IGNITION HAD BEEN CHECKED OR REPLACED. NOW ON 12/1/01 THE ALTERNATOR OVER CHARGED THE ELECTRICAL SYSTEM CAUSING A COMPLETE BURN-UP OF THE ECM,MAIN CIRCUIT PANEL AND SOME OF THE WIRING HARNESS. NEITHER THE 50AMP MAIN FUSE OR THE 30AMP ECM FUSE BLEW (LIKE THEY SHOULD HAVE) STOPPING THE 160 AMPS FROM THE ALTERNATOR. *AK

TRANSMISSION ON 4DR, 4X4 MODEL DOES NOT SEEM TO SHIFT ALL THE TIME. WHEN ACCELERATING (HARD OR GENTLE) TRANSMISSION REFUSES TO SHIFT UNLESS FOOT IS LIFTED OFF GAS AND THEN RETRY.*AK

THE DATE & MILEAGE ARE ONLY FOR THE MOST RECENT OCCURENCE. IT STARTED LATE APRIL 2001 AT ABOUT 70,000 MILES; I'D BOUGHT THE CAR USED THE PREVIOUS SEPTEMBER & IT HAD DRIVEN OK THROUGHOUT THE WINTER. THE PROBLEM HAS BEEN HAPPENING OFF & ON EVER SINCE. THE CAR WILL BE GOING 55 MPH OR MORE; ABOUT 5 OR MORE MINUTES AFTER STARTUP (IT VARIES), THE RPM GAUGE/IDLE SUDDENLY DROPS TO 0, THE CAR MIGHT BUCK SLIGHTLY,THE ENGINE LIGHT COMES ON, & THE CAR STALLS. PRESSING THE GAS PEDAL HAS NO EFFECT; ALL I CAN DO IS COAST TO A STOP. SO FAR, I'VE BEEN LUCKY; I'VE BEEN ABLE TO COAST TO THE SHOULDER W/NO INCIDENT. USUALLY AFTER A COUPLE MINUTES, I CAN START THE CAR AGAIN,BUT THIS PAST SATURDAY, I WAS STRANDED FOR OVER AN HOUR BEFORE THE CAR WOULD START. THE PROBLEM HAPPENS IRREGULARLY, USUALLY WHEN IT'S WARM OUTSIDE. THE IDLE ALSO REVS ON ITS OWN; WHENEVER I TAKE MY FOOT OFF THE GAS & THE SPEED DROPS BELOW 30 MPH, IT REVS & JUMPS FORWARD UNLESS I IMMEDIATELY HIT THE BRAKES -- VERY DANGEROUS WHEN I'M HEADING TOWARDS A STOPLIGHT! THE CAR HAS HAD BOTH ITS IGNITION COIL & FUEL INJECTORS REPLACED, AND ALL BELTS ARE NEW; ALL MAINTENANCE IS KEPT UP, & THERE ARE NO OTHER PROBLEMS WITH THE CAR THAT WOULD CAUSE EITHER OF THESE ISSUES. AFTER DRIVING OUR MECHANIC & US NUTS FOR SEVERAL MONTHS, WE FINALLY FOUND OUT THAT THE PROBLEMS WERE DUE TO SHORTS CAUSED BY BAD INSULATIVE SPRAY ON THE ECU/COMPUTER CIRCUIT BOARD (THE ORIGINAL FACTORY INSTALLED UNIT), & WE ALSO FOUND OUT THAT WE WEREN'T ALONE IN HAVING THESE PROBLEMS -- THAT OTHER STORM & ISUZU OWNERS WERE HAVING THE SAME TROUBLE. THE FAULTY ECU IS WHAT GM/ISUZU REFUSE TO RECOGNIZE. ISUZU CLAIMS THE PROBLEMS ARE "NORMAL" -- I'VE YET TO DRIVE ANY CAR WHERE STALLING & DYING AT HIGH SPEED ON THE HIGHWAY IS CONSIDERED "NORMAL". *AK