2004 GMC CANYON Complaints

ON OCTOBER 5, 2016, I TOOK MY TRUCK OVER TO MY MECHANIC TO HAVE MY BRAKE LINES BLED AS I REPLACED THE RIGHT FRONT CALIPER. WHEN THEY TOOK THE RIGHT FRONT TIRE OFF, THEY HAD SHOWN ME THAT THE LOWER LEFT CONTROL ARM MOUNT WAS GOING TO FAIL. THERE WAS NO FAILURE AS OF YET AND THE VEHICLE WAS STATIONARY WHEN THE PROBLEM WAS FOUND. IT WAS SEVERELY RUSTED OUT AND CRACKED, AS WELL AS THE FRAME AND AREA AROUND IT WAS SEVERELY RUSTED AND HOLES WERE VISIBLE. SO I DROVE IT HOME AND TOOK IT OVER TO A WELDER THAT HAS DONE REPAIRS ON THE TRUCK BEFORE AND HE SAID THAT IT WAS TOO CLOSE TO THE SUSPENSION COMPONENTS AND HE WASN'T GOING TO FIX IT. SO, AS OF NOW, I AM LOOKING FOR SOMEONE WHO SPECIALIZES IN AUTOMOTIVE WELDING, BUT THERE NOT TOO MANY PEOPLE HERE IN MY AREA WHO SPECIALIZE IN THIS KIND OF WORK. INSPECTION IS COMING UP AND I DOUBT IT PASSES. MECHANICALLY, I HAVE HAS FEW PROBLEMS WITH THIS TRUCK AND WOULD MUCH RATHER FIX IT THAN GET RID OF IT. PICTURES I AM POSTING SHOW THE SEVERITY OF THE DAMAGE.

GOT RECALL NOTICE IN LATE 2014 EARLY 2015 NOTICE OF RECALL ON TRUCK FOR IGNITION SWITCH. I HAVE OWNED THE TRUCK SINCE I BOUGHT IT IN 2004. I GOT A RECALL NOTICE IN THE TIME FRAME ABOVE TO BRING IT IN. I TOOK IT TO THEN STANLY GMC IN SHERMAN TEXAS, NOW PARKWAY GMC. THE PARTS MANAGER SAID BECAUSE I WAS OUTSIDE THE MILEAGE THERE WAS NOTHING THEY COULD DO. TO DAY I SAW AN ARTICLE IN OUR NEWSPAPER ABOUT THE POOR RECALL PERCENTAGE ON YOUR NOTICES. I TOOK MINE IN AS THE ARTICLE SAID YOU WOULD LIKE ME TO DO. THE SERVICE MANAGER AT THAT TIME MADE ME FEEL LIKE I WAS A NUISANCE. I HAVE HAD NO PROBLEM YET AND INTEND TO KEEP THE TRUCK FOR ANOTHER 10 YEARS OR SO. IF I DO EVER DECIDE TO TRADE FOR A NEW TRUCK I'LL KEEP THIS EVENT IN MIND. I'M 72 AND WOULD LIKE TO KNOW WHY YOU PUT A LIMIT ON THE TIME BEFORE THE RECALL EXPIRES. A PROBLEM CAN BE A PROBLEM NO MATTER HOW OLD THE TRUCK OR CAR IS AS LONG AS THE ORIGINAL OWNER HAS IT. THANK YOU [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNED A 2004 GMC CANYON. WHILE DRIVING 45 MPH, THE CONTACT'S VEHICLE WAS REAR ENDED. AS A RESULT, THE CONTACT'S VEHICLE CRASHED INTO THE PRECEDING VEHICLE. THE AIR BAGS DID NOT DEPLOY AND THE SEAT BELT PRE-TENSIONER FAILED TO SECURE THE CONTACT, WHICH CAUSED HER FACE TO STRIKE THE STEERING WHEEL. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND CARRIED OUT AN INVESTIGATION. THE FAILURE MILEAGE WAS UNKNOWN.

I JUST READ A JALOPNIK ARTICLE ON A RECALL OF THE G3 HUMMER AND THE QUESTION WHY THE CANYON/COLORADO WAS NOT INCLUDED. A FEW YEARS BACK THE BLOWER FAN QUIT WORKING ON LOW SETTINGS. I FOUND A TECH TIP THAT SUGGESTED I REPLACE THE FAN RESISTOR, WHICH I DID. I REMEMBER WHEN I REPLACED IT THERE WAS BROWN MARKS ON THE RESISTOR AND PLUG AT THE ELECTRICAL CONNECTORS. WHILE I DID NOT SUFFER A FIRE LIKE SOME OTHERS, THIS IS A REAL PROBLEM WITH THESE RIGS. THOUGHT YOU SHOULD KNOW...

HAD AN ACCIDENT WHERE I REAR ENDED A CAR AT ABOUT 25 MPH AND MY AIRBAG DIDNOT DEPLOY HOWEVER THE AIRBAG LIGHT CAME ON. *TR

TL* THE CONTACT OWNS 2004 GMC CANYON. THE CONTACT STATED THAT THE IGNITION FAILED TO START. THE CONTACT MENTIONED THAT THE IGNITION HAD TO BE TURNED LIGHTLY AND RELEASED QUICKLY IN ORDER TO START THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 129,000. UPDATED 9/11/14*CN UPDATED 1/20/2015 *JS

REDUCED POWER LIGHT CAME ON THE DASHBOARD AND I HAD NO POWER. THIS HAS HAPPENED 4 TIMES SINCE JULY 2013. IT HAS HAPPENED 2 TIMES IN APRIL AND NOW AGAIN. IT IS GOING BACK TO THE GARAGE ON TUES. GETTING RIDICULOUS AND EXPENSIVE! WHEN IT IS PUT ON THE SCOPE IT KEEPS COMING UP WITH THE THROTTLE POSITION SENSOR FAULT. *TR

REFERENCE RECALLS ON REPORT RECEIPT DATE: APR 27, 2006 NHTSA CAMPAIGN NUMBER: 06V139000 COMPONENT(S): EXTERIOR LIGHTING REPORT RECEIPT DATE: JUL 29, 2009 NHTSA CAMPAIGN NUMBER: 09V310000 COMPONENT(S): EXTERIOR LIGHTING MY 2004 GMC CANYON BRAKE LIGHT WENT OUT ON ME ON 8/8/2013. THE BRAKE LIGHT OUT WAS A SAFETY CONCERN FOR TAILGATERS. SO I TOOK TO MARK CHRISTOPHER GMC DEALER, ONTARIO CA FOR REPAIR BECAUSE OF TWO SAME RECALLS ON THE VEHICLE PLUS TRANSMISSION OIL CHANGE. ORIGINAL ESTIMATION OF COST WAS 305. THE DEALER DECIDED TO CHARGE ME 155 FOR TRANSMISSION OIL CHANGE AND LABOR, $16.75 FOR A DEFECTIVE/MALFUNCTION BRAKE SWITCH AND $200 ON LABOR. THEY TOLD ME THE RECALLS WAS DONE ALREADY ON THE VEHICLE AND THERE IS NO WARRANTY ON THE SECOND ATTEMPT. THE FINAL ESTIMATION OF COST WAS $377. I DON'T RECALL THE DATE THAT IT WAS SERVICED. HOW CAN GMC ASSURES THAT THE VEHICLE RECALLS WAS DONE PROPERLY? I'M VERY DISAPPOINTED WITH GMC AND IT RECALLS. I FELT LIKE I GOT RIP OFF BY THE DEALER. BESIDE, I DON'T KNOW IF THEY EVER CHANGE MY TRANSMISSION OIL FILTER AND CASKET ALONG WITH THE TRANSMISSION OIL CHANGE. *TR

I WENT TO WORK THIS MORNING AND MY 2004 GMC CANYON TRUCK WAS RUNNING FINE, ABOUT 2 HOURS LATER I RAN AN ERRAND, STILL NO ISSUES WITH THE TRUCK. AROUND 2:00PM I WENT TO RUN ANOTHER ERRAND AND SMELT SOMETHING LIKE BURNING PLASTIC, I OPENED MY TRUCK TO FIND THAT MY FRONT PASSENGER SIDE DOOR WAS SMOLDERING. THE TRUCK WAS FULL OF SMOKE AND THERE IS NOW A HOLE IN THE SIDE OF MY DOOR FROM WHERE THE PLASTIC MELTED! I HAVE NO IDEA HOW THIS COULD HAVE HAPPENED, BUT THIS IS MY ONLY SOURCE OF TRANSPORTATION AND I OFTEN TAKE MY GRANDDAUGHTERS ON TRIPS WITH ME. I PLAN TO TAKE IT TO A GMC DEALERSHIP AND HAVE THEM LOOK AT IT SO MAYBE THEY CAN TELL ME WHAT CAUSED THIS PROBLEM. ALSO, THE BACK SEATS IN THIS TRUCK BLOCK A LOT OF THE VIEW OUT OF THE REAR WINDOW CAUSING MAJOR BLIND SPOTS. SINCE I HAVE ONLY HAD THIS TRUCK ABOUT 2 MONTHS I PLAN TO ADDRESS THESE ISSUES AND SELL THE DARN TRUCK! *TR

MY 2004 GMC CANYON HAS, FOR THE PAST YEAR, QUIT STARTING DUE TO ANTI THEFT PASSLOCK SYSTEM INSTALLED ON TRUCK. I HAVE ON TWO SEPARATE OCCASIONS THUS FAR BEEN INVOLVED IN AN EMERGENCY SITUATION THAT COULD HAVE BEEN FURTHER PREVENTED BUT THE ANTI THEFT PASSLOCK STOPPED ME FROM STARTING THE VEHICLE. THIS SPECIFICALLY IS A WIDESPREAD PROBLEM THAT GM IS AWARE OF AND HAS MADE NO RECALL TO DATE ON THE ISSUE. THERE ARE SAFETY AND EMERGENCY SITUATIONS BEING CAUSED BY THIS DEFECT. PLEASE RESEARCH AND ASSIST ANY WAY POSSIBLE. *TR