2007 GMC CANYON Complaints

MY FRAME HAS A MAJOR RUST ISSUE ON THE DRIVERS SIDE UNDER TH GAS TANK. I HAVE READ SIMILAR COMPLAINTS ON THE INTERNET WITH THE RUST BEING ON THE DRIVER SIDE UNDER THE GAS TANK.

LOSS OF POWER STEERING, SLOW BREAKING AND UNABLE TO ACCELERATE. PROBLEM FIXES TEMPORARILY WHEN SHUTTING THE VEHICLE OFF AND THEN BACK ON.

VEHICLE WON'T START AFTER IT SHUT OFF WHILE DRIVING ON FRWY . PULL OVER AND STARTED AFTER A FEW MINUTES LIKE NOTHING HAD HAPPENED

THE VEHICLE HAS 9 BOLTS HOLDING THE EXHAUST MANIFOLD TO THE ENGINE. THE OWNER SMELLED STRONG EXHAUST SMELL IN THE CABIN. HE REMOVED THE EXHAUST MANIFOLD FROM VEHICLE AND FOUND THAT 4 OF THE 9 BOLTS HAD FAILED AND WERE BROKEN OFF FLUSH WITH THE ENGINE BLOCK. THERE WAS EXHAUST RESIDUE IN THE IMMEDIATE AREA OF THE 1ST AND 5TH CYLINDER PORT INDICATING THAT EXHAUST GAS WAS BEING DISCHARGED INTO THE ENGINE BAY. THE FAILURE IS AN ALARMING SAFETY EVENT BECAUSE OF THE POTENTIAL FOR HOT EXHAUST TO CAUSE A FIRE IN THE ENGINE COMPARTMENT AND THE POTENTIAL FOR ASPHYXIATION DUE TO CONTAMINATED CABIN AIR. THIS IS ALSO AN ENVIRONMENTAL CONTROL FAILURE BECAUSE A PORTION OF THE EXHAUST GAS ISS BYPASSING THE CATALYTIC CONVERTERS. THE OWNER IS THE ORIGINAL OWNER AND ALL EQUIPMENT IS ORIGINAL. HE IS A DEGREED MECHANICAL ENGINEER AND HAS WORKED IN AUTOMOTIVE COMPONENT MANUFACTURING. GM WAS CONTACTED DIRECTLY AND THE OWNER DIRECTED TO SEE THE DEALERSHIP. THE OWNER PROVIDED THE DEALERSHIP WITH THE ATTACHED PHOTOS BUT THEN REFUSED TO INSPECT THE VECHICLE WITHOUT FIRST COLLECTING A "DIAGNOSTIC FEE." THE OWNER REFUSED.

HEATER CONTROLS QUIT WORKING. UPON FURTHER INVESTIGATION, THE FACTORY WIRING HARNESS MAIN HVAC CONNECTOR IS BURNT.

VEHICLE IS A SMALL PICK UP EXTENDED CAB WITH HALF DOORS THAT HAVE REAR SIDE HINGES. AIR BAG SERVICE LIGHT WAS SET. UPON REPAIR DIAGNOSIS, IT WAS DISCOVERED THAT WIRES THAT TRAVEL BETWEEN THE BODY AND THE LEFT SIDE HALF DOOR -BEHIND THE DRIVERS DOOR WERE BROKEN FROM THE DOOR OPENING AND CLOSING. SINCE THIS HALF DOOR IS USED VERY LITTLE, THERE IS A DEFECT WITH THE QUALITY OF WIRE THAT CANNOT WITHSTAND FLEXING BY OPENING AND CLOSING THE DOOR. THESE WIRES CONTROL THE PRE TENSIONER ASSEMBLY IN THE HALF DOOR. WHEN THE WIRES ARE BROKEN IT DISABLES THE ENTIRE AIR BAG RESTRAINT SYSTEM. WIRES WERE NOT PHYSICALLY DAMAGED BY ANY OTHER MEANS. THESE WIRE SHOULD NOT BE BROKEN ON THIS AGE VEHICLE WITH LITTLE USE.

THE TRUCK'S SECURITY SYSTEM AND REMOTE START STOPPED WORKING. IT CONSISTENTLY HAS TO BE RESET FOR 10 MINUTES EVERY FAILED ATTEMPT AT TRYING TO GET THE VEHICLE STARTED. HAVE ALTOGETHER STOPPED USING THE SECURITY SYSTEM (WHICH IS NOT A GOOD IDEA IN AN APARTMENT COMPLEX). NOW THE AUXILIARY SYSTEM STILL REMAINS ON IF THE ONLY DOOR USED IS THE DRIVER'S SIDE DOOR. THE PASSENGER DOOR HAS TO BE OPENED AND CLOSED TO TURN THIS OFF. THIS IS NOT SAFE (ESPECIALLY WHEN PARKED IN A PARKING GARAGE, A COLD NIGHT, OR PARKING AWAY FROM A LIGHT). *TR

TL* THE CONTACT OWNS A 2007 GMC CANYON. THE CONTACT STATED THAT THE TIRE PRESSURE GAUGE REMAINED ILLUMINATED. THE DEALER STATED THAT THE FAILURE WAS DUE TO ELEVATION. THE TIRE PRESSURE GAUGE SENSOR WAS RESET, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 5. UPDATED 11/14/14*CN UPDATED 4/29/2015 *JS

VEHICLE CRANKS BUT DOES NOT START. SECURITY LIGHT FLASHING. AFTER 10 MINUTES WITH KEY ON AND SECURITY LIGHT OFF AFTER TURNING OFF THEN CRANK ENGINE STARTS. HAPPENED AT LEAST 15 TIMES. NOW, ENGINE SOMETIMES WILL CRANK ITSELF IN THE "ON" POSITION AND WILL NOT START AND SECURITY LIGHT FLASHING. HAPPENED THREE TIMES AND FINALLY AFTER THREE 10 MINUTE KEY ON WAIT CYCLES IN A DARK PARKING LOT SECURITY LIGHT STOPPED FLASHING AND STARTED AND MADE IT HOME. VEHICLE VERY UNRELIABLE NOW. I AM TIRED OF HAVING A VEHICLE THAT THINKS THE OWNER IS TRYING TO STEAL OWNED VEHICLE. AND AUTO CRANK IN THE ON - NOT START- POSITION WITHOUT RUNNING. HOW DO I BYPASS THIS AWFUL SYSTEM WITHOUT ANOTHER CAR PAYMENT TO ANOTHER AUTOMAKER? THIS DEFECT IS DANGEROUS AND HAZARDOUS WHEN STOPPING FOR FUEL AND HAVE TO LEAVE ENGINE ON OR HOLDING UP CUSTOMERS UNTIL ENGINE STARTS. ALSO HOLDING UP VEHICLES ON A FERRY BOAT. VERY EMBARRASSING WHEN FRIENDS AND CO WORKERS HAVE TO WAIT TILL VEHICLE DECIDES TO START AND RUN. AND BEING LATE TO WORK. I DO NOT WANT NEW PARTS THAT WILL FAIL AGAIN, I WANT IT BYPASSED. SEND ME A KIT WITH DIRECTIONS ASAP! *TR

TL* THE CONTACT OWNS A 2007 GMC CANYON. THE CONTACT STATED THAT WHILE STARTING THE IGNITION, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE AIR BAG WIRING HARNESS NEEDED TO BE PATCHED UP. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER, WHO STATED THAT THE WIRING HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.