2003 GMC ENVOY Complaints

1. The air bag dummy light is on 2. The relay switch keeps going bad on my regular headlights, but the brights will turn on 3. Rear driver side door popped open on the highway while driving with my 12 year old nephew in the backseat. Will not latch shut.

HEADLIGHTS AND BRAKE LIGHTS WENT OUT AT SAME TIME. HIGH BEAMS WORK, VEHICLE RUNS, HAS ALL POWERS. THIS HAPPENED WHEN I LEFT THE HOUSE, WHILE DRIVING, NOTICED WHEN IT BEGAN TO TURN INTO EARLY EVENING.

CHECK ENGINE LIGHT STAYS ON. HAD A DIAGNOSTIC DONE AND THEY SAID THERE'S A GAS LEAK COMING FROM THE GAS TANK FUEL INLET VALVE. COMMON PROBLEM FOR THE GMC ENVOY AND CORRECTION INVOLVES REPLACING THE WHOLE FUEL TANK COSTING AN AVERAGE $1,400. DANGEROUS TO DRIVE IF LEFT UNTREATED. CALLED GMC CORPORATE AND I DIDN'T GET ANY HELP. THEY SAID MY ENVOY WAS NOT UNDER ANY RECALLS. THEY SHOULD BE HELD RESPONSIBLE FOR THIS DEFECT.

SHIFT CABLE BROKE BETWEEN THE SHIFTER AND THE TRANSMISSION WHILE SHIFTING FROM DRIVE TO REVERSE TO PARK ON A STREET. IF THIS HAD HAPPEN WHILE SHIFTING DOWN GEAR TO LOWER SPEED WHILE DRIVING DOWN A HILL, A LOSS OF CONTROL OF THE VEHICLE WOULD HAVE HAPPEN THAT WOULD HAVE LED TO A CRASH WITH EXTREME PROPERTY DAMAGE AND MOST LIKELY DRIVER AND PASSENGER INJURY AND POSSIBLE DEATH. THE VEHICLE WAS TOWED TO OURISMAN CHEVROLET IN MARLOW HEIGHTS MARYLAND FOR REPAIR AFTER THE TOW TRUCK DRIVER MANUALLY SHIFTED THE TRANSMISSION INTO DRIVE FROM UNDERNEATH THE VEHICLE THAT WOULD'VE BEEN EXTREMELY DANGEROUS FOR THE TOW DRIVER TO DO IF THE VEHICLE HAD BEEN FACING DOWN HILL OR IN A HEAVY TRAFFIC SITUATION. FOR SOME REASON, HOWEVER, MY VEHICLE STILL HASN'T BEEN REPAIRED NOR HAVE I'VE BEEN GIVEN A REASON AS TO WHY.

MY WIFE WAS SITTING IN THE BACKSEAT AND THE BACK DOOR FLEW OPEN ON THE HIGHWAY. I HAVE ALSO NOTICED THE OTHER BACK DOOR IS NOT CLICKING SHUT AND THIS IS A VERY DANGEROUS SITUATION. *TR

U GUYS ISSUED RECALLED ALL GMC VEHICLES FOR A LEAKING GAS CK VALVE ON GAS TANK NO MATTER HOW LONG IN SERVICE STATIONARY OR ON MOTION CK WITH MY LOCAL DEALER KARL CHEVROLET ANKENY IOWA THEY SAY EXPIRED I'M 2017 AT 150000 YOUR RECALLED AS LONG AS IN SERVICE. *TR

WHEN TRAILER IS CONNECTED TO THE 7 WAY TO BOX TRAILER CONNECTION TRAILER TAIL LAMPS DO NOT LIGHT CORRECTLY. BRAKE AND LEFT TURN SIGNAL LAMPS WORK PROPERLY. THE RIGHT TURN TRAILER LAMP IS PARTIALLY LIT WHEN TURN SIGNAL IS NOT ENGAGED. WHEN RIGHT TURN SIGNAL IS ENGAGED THE LEFT AND RIGHT TURN SIGNALS START FLASHING, BRAKE LIGHTS WORK NORMAL. THIS TURN SIGNAL ISSUE APPLY ONLY WHEN TRAILER ELECTRIC CIRCUIT IS PLUNGED IN TO THE TRAILER CIRCUIT. MY UNDERSTANDING THERE WAS A RECALL REGARDING THE FLASHER UNIT FOR THE 2003 ENVOY VEHICLE TURN SIGNALS. IT APPEARS THE TRAILER CIRCUIT HAS A SIMILAR ISSUE. BOTH THE VEHICLE AND TRAILER WORK OFF THE SAME FLASHER MODULE. SEE RECALL 05V198000. I PLAN TO REPLACE THE FLASHER UNIT TO CORRECT THIS DEFECT. IF YOU NEVER TOWED A TRAILER THIS ISSUE WOULD NOT BE DISCOVERED. WHEN TOWING A TRAILER DRIVER COULD BECOME CONFUSED WHEN YOUR MAKING A RIGHT TURN. THIS POTENTIALLY COULD RESULT IN AN ACCIDENT. THE TRAILER USED WAS A 5X10 FOOT SINGLE AXLE BOX TRAILER WITH FOUR WIRE ELECTRICAL CIRCUIT. I HAD NO ISSUES WHEN TOWED WITH A DIFFERENT MAKE OF TRUCK. I DID REPLACED BOTH TRAILER TAIL LIGHT ASSEMBLY AND ISSUE DID NOT CHANGE.

WHILE DRIVING THE VEHICLE A STRONG ODOR OF GAS ENTERING THE CABIN. FILL VEHICLE UP AND LARGE AMOUNT OF GAS POURS ON THE GROUND FROM UNDER THE VEHICLE. CLOSER INSPECTION REVEALS THE PART THAT ATTACHES TO THE GAS TANK IS BROKEN OFF CAUSING VAPORS TO ESCAPE AND NOT PROVIDING A SEAL TO CONTAIN THE SMELL. WHILE DRIVING ON THE INTERSTATE AT NORMAL OPERATING SPEED VEHICLE LOSES OIL PRESSURE CAUSING IT TO DROP TO 0 AND MESSAGE APPEARS TO STOP ENGINE. BOTH INCIDENTS ARE SAFETY HAZARDS AND CAN CAUSE SERIOUS LIFE AN DEATH INCIDENTS IF ISSUES ARE NOT ADDRESSED BY THE CORPORATION. THIS OCCUR ON INTERSTATE 66 IN WASHINGTON, DC. IMMEDIATE RECALL OF ALL VEHICLES FROM GMC NEEEDS TO BE INITIATED.

THE FUEL FILL LINE IS BROKEN FROM THE GAS TANK. I WAS FILLING THE TANK FOR HOLIDAY TRAVEL AND THE THE TANK BEGAN TO LEAK. EVERY TANK THAT IS ORDERED BY THE REPAIR SHOP IS DAMAGED IN THE SAME PLACE

BULLETIN NO.:14423 DATE: NOVEMBER 2015 PART NUMBER: 15077622 TANK, FUEL (18.7 GAL.) THE ICV IS LOCATED ABOVE THE FULL FUEL LEVEL. A FRACTURED ICV COULD ALLOW FUEL VAPORS TO PASS THROUGH AND DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK AS IT PASSES OVER THE FRACTURE DURING REFUELING. IF THE ICV FRACTURES, THE VEHICLE'S SERVICE ENGINE SOON (SES) LIGHT MAY ILLUMINATE, AND YOU MAY NOTICE A FUEL ODOR AND/OR A FEW DROPS OF FUEL ON THE GROUND WHEN REFUELING THE VEHICLE. THIS HAS HAPPEN TO ME AND NOW MY TANK NEEDS TO BE REPLACED. THIS IS A KNOWN ISSUE WITH GMC ENVOY REGARDLESS OF YEAR OR HOW LONG THEY ARE IN SERVICE. THE COMPANY NEEDS TO BE HELD ACCOUNTABLE FOR POOR QUALITY OF PARTS ESPECIALLY WHEN IT IS A SAFETY CONCERN AND HAZARD WITH FUEL ODOR COMING INTO THE CAB OF THE VEHICLE AND SPILLING OUT WHEN GOING UP A HILL. BEING TOLD TO ONLY FILL MY GAS TANK UP HALF TO THREE QUARTERS FULL DUE TO THAT PART BEING BROKEN IS THE WRONG ANSWER. IN MOTION WHEN I SMELL GAS AND THEN NOTICE IT WHEN I FILL THE VEHICLE UP AND IT STARTED POURING OUT.