2002 GMC ENVOY Complaints

THE OUTSIDE AUTOMATIC ADJUSTING MIRROR HAVE A MIND OF THEIR OWN AND HAVE TO BE RESET EACH TIME FOR EACH DRIVER THEY ARE PROGRAMMED TO. ONCE ADJUSTED, YOU MAY LOOK TO CHANGE LANES AND FIND THEY ARE NOT ANYWHERE NEAR WHERE THEY WERE ADJUSTED. I HAVE COME CLOSE TO HAVING A NUMBER OF ACCIDENTS DUE TO THIS PROBLEM. THE DEALER REPROGRAMMED THE MIRRORS AND THEY CONTINUE TO DO THE SAME THING.*JB

2002 GMC ENVOY HAS AN SES ILLUMINATION ACCOMPANIED BY A FUEL ODOR, AND/OR A FEW DROPS OF FUEL ON THE GROUND WHEN REFUELING THE VEHICLE. THIS IS CAUSED BY A FRACTURE OF A WELD ON THE FUEL TANK INLET CHECK VALVE (ICV). THE ICV IS LOCATED ABOVE THE FULL FUEL LEVEL. A FRACTURE IN THIS AREA MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK AS IT PASSES OVER THE FRACTURE DURING REFUELING. *JB

ENGINE TENDED TO REV AT A HIGH LEVEL UNTIL WARMED UP. FINALLY WOULD NOT COME DOWN TO A NORMAL LEVEL DUE TO A FAILED FAN CLUTCH. VEHICLE WAS OUT OF WARRANTY, AND DEALER QUOTED $800 FOR REPAIRS. HAD THE FAN CLUTCH REPLACED INDEPENDENTLY, WHICH NOW HAS US BACK TO THE ORIGINAL HIGH LEVEL OF REVVING FOR SEVERAL MINUTES BEFORE RUNNING NORMAL. DISAPPOINTED TO SEE THE NUMBER OF SIMILAR FAILURES, AND YET THE DEALER ACTS LIKE THIS IS AN UNHEARD OF EVENT. *JB

MY REAR HIGH MOUNT STOP LAMP ATTACHED TO THE LIFT GATE WINDOW HAS BECAME DETACHED YESTERDAY ON IT'S OWN. IT SEEMS THAT IT'S FASTENING HOLDING IT DOWN HAD LOOSENED AND BROKE. IT IS NOW HANGING FROM IT'S WIRING AND NEEDS TO BE REPLACED, REWIRED, AND MOUNTED. I BELIEVE THIS IS SIMILAR TO NHTSA CAMPAIGN NUMBER: 04V527000, WHERE VIBRATION AND HEAT FROM NORMAL DRIVING USE PLAYED A FACTOR IN UNCOVERING ANOTHER DEFECT IN THE EXTERIOR LIGHTING:BRAKE LIGHTS. *JB

LEAKY GAS TANK ON 2002 GMC ENVOY XL. 48,000 MILES. FOUND BY DEALERSHIP, RECOMMENDED NEW GAS TANK FOR APPROX $500 PLUS LABOR. SERVICE BULLETIN EXISTS TO LOOK FOR CRACK IN TANK PER SERVICE DEPARTMENT. *NM

I HAVE HAD A INTERMITTENT RUMBLING SOUND IN THE DRIVERS COMPARTMENT LIKE THE DOORS ARE NOT CLOSED PROPERLY. I HAVE CHECKED DOORS CLOSED BUT YET IT STILL HAPPENS. TOOK BACK TO DEALERSHIP AND THEY COULD NOT FIND A PROBLEM. THE FUEL GAUGE IS READING INCORRECTLY, AT A HALF A TANK OF FUEL THE GAS HAND WILL INTERMITTENTLY MOVE UP OR DOWN. ALSO NOV. 2006 A HIGH PITCH SQUEAL FROM THE FRONT OF VEHICLE WHILE DRIVING BETWEEN 1 AND 40 MPH. *JB

I AM WRITING THIS COMPLAINT ON A RECALL THAT ALREADY EXIST AND HAS NOT BEEN RESOLVED PROPERLY. I AM THE OWNER OF A GMC ENVOY 2002. IN 2004 THERE WAS A SAFETY RECALL THAT BECAUSE OF WATER GETTING INTO THE WIPER MOTOR THAT THE MOTOR WOULD FAIL AND CAUSE AN ACCIDENT. WELL THE FIX FOR THIS WAS TO PUT A COVER OVER THE WIPER MOTOR IN MOST CASES. WELL MY SELF AND OTHER TRAILBLAZER AND ENVOY OWNERS NOW ARE SEEING THE EFFECTS OF THE DAMAGE THAT WAS DONE TO OUR WIPER MOTORS SINCE 2002. THE MOTOR IS BEGINNING TO SKIP OR SOMETIMES FAIL BECAUSE IT IS SLOWLY RUSTING FROM BEFORE. GM NEED TO COME UP WITH A REAL SOLUTION TO THIS PROBLEM AND ACTUALLY MAKE THESE VEHICLES SAFE. *NM

DT*: THE CONTACT STATED WHILE TRAVELING 25 MPH, THE VEHICLE LUNGED, A WHIRRING NOISE OCCURRED, AND THE VEHICLE WOULD NOT ACCELERATE. IT WAS DRIVEN HOME WITH HIGH RPM'S AND LOW ACCELERATION. AT THE CONTACT'S RESIDENCE, IT WAS NOTICED THAT REVERSE DID NOT OPERATE. THE VEHICLE WAS DRIVEN TO THE DEALERSHIP, BUT WOULD NOT OPERATE ABOVE FIRST OR SECOND GEAR. THE DEALERSHIP DETERMINED THE SUN SHELL INSIDE THE TRANSMISSION FAILED AND THE TRANSMISSION NEEDED TO BE REBUILT.

MID JUNE 2006, WIFE DROVE TO WORK AND STOPPED AT A GAS STATION TO GET GAS. WHEN SHE RESTARTED THE CAR, THE INSTRUMENT POWER PANEL DID NOT WORK NOR ANY OF THE INSTRUMENTS SUCH AS SPEEDOMETER. SHE CONTINUED TO HER JOB AND PARKED THE CAR. WHEN SHE LEFT WORK AND STARTED THE CAR, EVERYTHING WAS WORKING AGAIN. SHE TOOK THE CAR TO A GMC DEALER ABOUT THE PROBLEM. THEY SAID THEY COULD NOT DO ANYTHING BECAUSE EVERYTHING APPEARS TO BE WORKING. I HAVE DONE A SEARCH ABOUT RECALLS AND FOUND THAT A RECALL NHTSA 03V096000 APPEARS TO AFFECT ME. I AM TOLD BY GMC THAT MY VIN NUMBER DOES NOT APPLY TO THIS RECALL. *NM

DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, THE 4-WHEEL DRIVE INDICATOR LIGHT ILLUMINATED, AND THE VEHICLE STOPPED AS IF THE BRAKE WAS APPLIED WHEN THE ACCELERATOR PEDAL WAS RELEASED. ALSO, A SMELL WAS COMING FROM THE BRAKES AND THE VEHICLE ACCELERATED WITHOUT WARNING. THE VEHICLE WAS DRIVEN TO THE DEALER WHO DETERMINED THE TRANSFER CASE CONTROL MODULE NEEDED TO BE REPLACED.