2003 GMC ENVOY Complaints

NOTICED PERIODIC INSTRUMENT CLUSTER FAILURE/ACCURACY PROBLEMS. SPEEDOMETER WILL SOMETIMES WORK OR WORK ERRATICALLY SO I HAVE NO IDEA HOW FAST I AM GOING. I RESEARCHED ON THE WEB AND FOUND THIS IS VERY TYPICAL FOR THIS MODEL. I CALLED MY DEALERSHIP AND WAS TOLD THAT THEY WILL ONLY REPAIR (NO COST) THE GMC PICKUPS AND NOT MY SUV MODEL EVEN THOUGH THEY HAVE SAME PROBLEM WITH THE SAME PART. THIS PRESENTS A VERY DANGEROUS CONDITION REGARDLESS OF WHAT VEHICLE THIS IS IN. WINTER DRIVING CONDITIONS IN MN REQUIRE DILIGENCE IN SPEED AND BRAKING, THIS IS A HUGE AND DANGEROUS PROBLEM FOR GMC AND THEY ARE JUST IGNORING CERTAIN MODELS FOR WARRANTY REPAIR AND FORCING THE CONSUMER TO SPEND $500.00 (EST.) TO FIX THERE PROBLEM! *TR

TL*THE CONTACT OWNS A 2003 GMC ENVOY. THE CONTACT NOTICED THAT THE SPEEDOMETER IN HIS VEHICLE WOULD REGISTER HIGHER SPEEDS THAN WHAT WAS ACTUALLY BEING DRIVEN. WHILE DRIVING APPROXIMATELY 70 MPH WITH THE CRUISE CONTROL ACTIVATED, THE SPEEDOMETER WENT ALL THE WAY PAST THE HIGHEST SPEED INDICATOR AFTER DRIVING FOR 30 MINUTES. WHEN THE CONTACT PARKED THE VEHICLE, THE SPEEDOMETER DISPLAYED 70 MPH. THE DEALER AND MANUFACTURER HAVE NOT BEEN NOTIFIED. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS APPROXIMATELY 81,000 AND FAILURE MILEAGE WAS APPROXIMATELY 79,000.

TL*THE CONTACT OWNS A 2003 GMC ENVOY. WHEN THE CONTACT TURNED THE IGNITION ON, THE DRIVER AND FRONT PASSENGER SIDE AIR BAGS DEPLOYED WITHOUT WARNING. THERE WAS NO INJURIES. THE VEHICLE WILL BE TAKEN TO THE DEALER FOR A DIAGNOSIS. THE CURRENT AND FAILURE MILEAGES WERE 78,000. UPDATED 3/5/09 *CN THERE WAS AN INTERNAL FAILURE OF THE AIR BAG MODULE. UPDATED 03/10/09. *JB

1/17/09 GMC ENVOY 2003 I MADE A SHARP U-TURN IN A SNOWY YARD WHILE VEHICLE WAS IN TRACTION ASSIST. THEN I PULLED INTO THE DRIVEWAY AND PARKED, TURNED OFF THE VEHICLE AND WENT IN THE HOUSE. I WAS IN THERE APPROXIMATELY 30 MINUTES THEN GOT BACK IN THE VEHICLE TO LEAVE AND THE POWER STEERING WAS GONE. EXCESSIVELY STIFF.I PULLED FORWARD GOT OUT, LOOKED AT THE GROUND AND THERE WAS A PUDDLE OF BLUISH LIQUID LOCATED NEAR WHERE THE LEFT FRONT SIDE OF THE VEHICLE WAS SITTING. *TR

I HAVE A 2003 GMC ENVOY, THAT IS RUSTING BADLY. RECENTLY THIS CAUSED THE TRANSMISSION COOLER TO FAIL. ALSO THE REAR BRAKE SHOE BACKING PLATES, THE SPARE TIRE CARRIER, THE TAIL GATE, ALONG WITH OTHER PARTS. GMC HAS RECOGNIZED THE FUEL FILLER NECK CORROSION, BUT NOT THE ENTIRE VEHICLE. *TR

TL*THE CONTACT OWNS A 2003 GMC ENVOY. WHILE DRIVING APPROXIMATELY 60 MPH ON NORMAL ROAD CONDITIONS, THE CONTACT SMELLED A STRONG ODOR OF FUEL COMING FROM OUTSIDE OF THE VEHICLE. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL AND REMAINED LIT UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING AND THE TECHNICIAN STATED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE HAS NOT BEEN REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS UNKNOWN AND CURRENT MILEAGE WAS 90,000.

MY SERVICE ENGINE LIGHT CAME ON AND THEN I STARTED DETECTING A ODOR OF GASOLINE. THE ORDER GREW STRONGER AND THEN I GOT THE "SPECIAL NOTICE", BUT NOT A RECALL ABOUT THE CORROSION IN THE FUEL TANK. WHEN I TOOK THE CAR INTO THE DEALER, I WAS TOLD THAT THIS WAS NOT THE PROBLEM AND THAT IT WAS A CRACK AT THE FILLER PIPE ON THE GAS TANK AND THAT THIS WAS NOT COVERED. I ASKED WHAT COULD CAUSE THIS AND THEY COULD NOT GIVE ME AN ANSWER. MY CAR ONLY HAS 49,000 MILES AND IS IN EXCELLENT SHAPE, EXCEPT FOR ALL THE RECALL ITEMS. I BELIEVE THAT GMC SHOULD FIX THIS PROBLEM, NOT ONLY IT IS COSTLY TO FIX, BUT IT IS VERY DANGEROUS TO BE DRIVING LIKE THIS. AND READING THE COMPLAINTS, IT SOUNDS LIKE SEVERAL OTHERS HAVE THE SAME ISSUE. *TR

TL*THE CONTACT OWNS A 2003 GMC ENVOY. WHILE DRIVING APPROXIMATELY 65 MPH, THE SPEEDOMETER DISPLAYED INACCURATE READINGS. THERE WERE NO WARNINGS PRIOR TO THIS FAILURE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING, WHICH INDICATED THAT THE FAILURE WAS RELATED TO THE ODOMETER STICKING. THE DEALER RECOMMENDED THAT THE INSTRUMENT PANEL BE REPLACED. THE VEHICLE HAS NOT BEEN REPAIRED. THE CONTACT WAS CONCERNED OF THE SAFETY RISK INVOLVED. THE FAILURE MILEAGE WAS 53,028 AND CURRENT MILEAGE WAS 60,200. UPDATED 12/08/08. *LJ UPDATED 12/09/08.*JB

THE REAR DRIVER DOOR POPPED OPEN AND WON'T CLOSE. THE FAN CLUTCH FAILED 2 WEEKS AFTER I PURCHASED THE VEHICLE. I THOUGHT THE TRANSMISSION WENT OUT BECAUSE IT WAS WINDING REALLY HIGH AND NOT DRIVING NORMALLY. ALSO THE REAR PASSENGER DOORS ON BOTH SIDES HAVE MALFUNCTIONED. THE WINDOW ON THE PASSENGER REAR WENT OUT. I HAVE NOT CORRECTED THE FAILURES AS OF NOW. *TR

MY WIFE WAS IN THE PROCESS OF CLOSING THE REAR HATCH ON OUR 2003 ENVOY XL (80,000 MILES) AFTER REMOVING SOME ARTICLES FROM THE BACK. SHE HAD MOVED THE DOOR ABOUT 1-2 INCHES DOWNWARD USING THE MOLDED HANDLE ON THE BOTTOM OF THE LIFT GATE TO CLOSE THE DOOR WHEN THE REAR GLASS SHATTERED OVER HER HEAD. LUCKILY SHE WAS NOT INJURED BUT WAS COVERED IN SAFETY GLASS. THE GLASS WAS NOT DAMAGED YESTERDAY WHEN I DROVE THE VEHICLE AND UNLOADED SUITCASES FROM THE REAR. AMBIENT TEMPERATURE WAS ABOUT 70 DEGREES. I DID NOTICE THAT THE REAR BRAKE LIGHT ASSEMBLY IS NOW ANGLED UPWARDS IN THE 'GATE RAISED' POSITION, EVEN AFTER CLOSING THE HATCH. ALSO NOTICED THE TOP, RIGHT SIDE RUBBER GROMMET ON THE STAMPED BRACKET ATTACHING THE GLASS IS VERY WORN, ALLOWING SIGNIFICANT MOVEMENT. I PLAN ON TAKING THE VEHICLE TO A DEALER TO DETERMINE ROOT CAUSE IF POSSIBLE AND WILL HAVE THE GLASS AND ALL TOUCH POINTS REPLACED IF POSSIBLE. I HAVE NO CONFIDENCE THAT THIS WILL NOT HAPPEN AGAIN IF THERE IS A DESIGN INTERFERENCE ISSUE WITH THE GLASS AND THE SURROUNDING COMPONENTS THAT HAPPENS OVER TIME. THERE APPEAR TO BE NUMEROUS CASES ON THE AUTOMOTIVE FORUMS WEBSITE REGARDING ENVOY XL REAR HATCH GLASS SHATTERING FOR NO APPARENT REASON (SOME MULTIPLE OCCURRENCES). I AM SURPRISED MORE COMPLAINTS HAVE NOT BEEN REGISTERED TO NHTSA OFFICIALLY (ONLY FOUND ONE-10081011). IT IS ONLY A MATTER OF TIME BEFORE SOMEONE IS SERIOUSLY HURT. I HAVE BEEN A BRAKE ENGINEER FOR 10+ YEARS AND TAKE SAFETY VERY SERIOUSLY. *TR