2003 GMC ENVOY Complaints

DT*: THE CONTACT STATED WHILE DRIVING 35 MPH ON NORMAL ROAD CONDITIONS, THE CHECK ENGINE LIGHT ILLUMINATED, AND A WARNING SIGNAL DISPLAYED ON THE VEHICLE'S PANEL. ALSO, THE CONTACT SMELLED GAS FUMES IN AND AROUND THE VEHICLE. IT WAS TAKEN TO A DEALERSHIP, WHO DETERMINED THAT THE FUEL TANK HAD A LEAK; THE FILLER NECK WAS DETACHED FROM THE TANK. THE FUEL TANK WAS REPLACED WHICH CORRECTED THE PROBLEM. UPDATED 12/1/2006 - THE FILLER NECK DID NOT CONNECT PROPERLY TO THE TANK WHICH WAS FOUND WHEN THE TANK PRESSURIZED. THE CONSUMER FELLS THAT THE CONNECTION OF THE NECK AND TANK IS A DESIGN FLAW. *NM

DT*: THE CONTACT STATED WHILE DRIVING 5 MPH DURING NORMAL ROAD CONDITIONS IN A SCHOOL ZONE, THE GAS LIGHT ILLUMINATED AND A GAS ODOR FUMIGATED THE VEHICLE. IT WAS TAKEN TO THE DEALER, WHO DETERMINED THAT THERE WAS A CRACK IN THE GAS TANK WHICH LEAKED VAPORS AND THE GAS TANK NEEDED TO BE REPLACED. NO REPAIRS WERE MADE. UPDATED 12/01/06. *JB

AIR CONDITIONING RUNS HOT- THERE IS A TECHNICAL SERVICE BULLETIN OUT FOR THIS BUT IT NEEDS TO BE AN OPEN RECALL TO BE FIXED--- NEEDS REFLASH FOR CONTROL HEAD-THAT'S WHAT MY MECHANIC SAID. *NM

THERE IS A RECALL ON ERRATIC WIPER OPERATION IN MY 2003 GMC ENVOY. BUT BECAUSE MY VIN NUMBER WASN'T INCLUDED IN THE RECALL, THEY WILL NOT FIX IT. I HAVE TO PAY FOR IT, IF I WANT FIXED. SOMETIMES THE WIPERS DON'T SHUT OFF IF TOO MUCH MOISTURE GETS IN THE WIPER MODULE. SHOULD BE AN OPEN RECALL. *NM

WHEN I FILL MY ENVOY WITH GAS, IT WILL NOT STOP WHEN IT IS FULL. THE GAS THEN SPILLS OVER ONTO THE SIDE OF THE SUV AND CAUSES ME TO CLEAN IT IMMEDIATELY AND SMELL LIKE GAS. I KNOW THAT IT IS THE SUV AND NOT THE PUMP BECAUSE IT DOESN'T HAPPEN WITH MY OTHER VEHICLE AT THE SAME PUMP. *JB

DT*: THE CONTACT STATED WHILE DRIVING 70 MPH ON THE HIGHWAY THE BRAKE LIGHT ON TOP OF THE REAR WINDOW FELL OFF. THE DEALER WAS ALERTED. UPDATED 9/20/2006 - *NM

A PLASTIC GAS TANK THAT WAS INSTALLED NEW ON MY 2003 GMC ENVOY CRACKED AND IS RELEASING FUEL FUMES. *NM

(1) EVENTS LEADING UP TO THE FAILURE, - (A) REGULATOR IN DRIVER SIDE MIDDLE SEAT DOOR WINDOW REGULATOR FAILED PRIOR TO 36000 AND - (B) PASSENGER SIDE MIDDLE SEAT DOOR WINDOW REGULATOR FAILED AT 43000 MILES (2) A- WINDOW FAILED TO OPERATE AT NO CHARGE B- NEW REGULATOR INSTALLED - $200 + CHARGE (3) PARTS REPLACED FOR PRIOR TO WARRANTY CHARGE OVER $200 FOR SECOND FAILURE. *NM

GAS TANK BACK SPITS WHEN FILLING AT STATION...GOES ALL OVER GROUND REAR ACCESS WINDOW POPS OPEN WHEN DRIVING PASSENGER WINDOW MECHANISM BROKEN AND GLASS PIECES FORMED IN DOOR. MECHANISM FAILED TO RAISE AND LOWER THE WINDOW...CAUSING A GRINDING SOUND. REPLACEMENT WAS COSTLY AND UNECESSARY FOR ME THE CAR OWNER. SHOULD WORK FOR YEARS WITHOUT FAILURE. *JB

DT*: THE CONTACT STATED WHILE DRIVING 10 MPH THE VEHICLE STALLED AND WAS MANEUVERED OFF THE ROAD. WHEN THE VEHICLE WAS BEING PREPARED TO BE TOWED THE TOWMAN NOTICED GAS LEAKING. THE DEALER CONFIRMED THE LEAK AND DETERMINED THE TANK SHIFTED CAUSING THE GAS LINE TO CRACK. THE DEALER REPLACED THE ENTIRE GAS TANK WHICH CORRECTED THE PROBLEM.