2003 GMC ENVOY XL Complaints

GAS TANK FAILED. HAD TO REPLACE AT A COST OF OVER $1000 ON 2003 GMC ENVOY. HAVE GAS TANK WHICH FAILED - WAS RETRIEVED FROM DEALER WHEN CAR WAS PICK UP IF NHTSA IS INTERESTED. SHOULD NOT HAVE TO REPLACE A GAS TANK. *NM

GASOLINE ODOR OUTSIDE AND INSIDE VEHICLE. DEALER FOUND SEVERE CORROSION OF FUEL PUMP MODULE, REQUIRING REPLACEMENT. THEY STATED IT WAS A COMMON FAILURE AND HAD MANY PRIOR EXAMPLES. *JB

I HAVE A 2003 GMC ENVOY XL. MY CHECK ENGINE LIGHT CAME ON. I HAD A MECHANIC HOOK HIS COMPUTER UP TO THE VEHICLE. THE CODE IT GAVE WAS A BAD GAS CAP. HE REPLACED THE GAS CAP AND RESET THE COMPUTER. TWO WEEKS LATER THE CHECK ENGINE LIGHT CAME BACK ON. I ALSO SMELLED GAS AFTER FILLING THE GAS TANK AND NOTICED GAS ON MY GARAGE FLOOR. I AM HAVING THE GAS TANK DROPPED AND CHECKED THIS WEEKEND. I WONDER HOW MANY OTHERS ARE HAVING THE SAME PROBLEM? *JB

THE PLASTIC GAS TANK ON MY 2003 ENVOY XL IS CRACKED AT THE NECK GOING INTO THE TANK RELEASING GAS AND GAS FUMES. GAS IS LEAKING FROM THE CRACK AND COULD CAUSE THE VEHICLE TO CATCH FIRE AND/OR EXPLODE. *NM

DT*: THE CONTACT STATED WHILE TRAVELING VARIOUS SPEEDS IN RAINY WET ROAD CONDITIONS, THE WINDSHIELD WIPER SYSTEM WOULD NOT TURN OFF, ONCE ACTIVATED. THE VEHICLE MUST BE STOPPED AND TURNED OFF, IN ORDER TO TURN OFF THE WIPERS. THE PROBLEM ONLY OCCURRED DURING RAINY CONDITIONS. THERE WAS A NHTSA RECALL, #04V046000, REGARDING THE VISIBILITY: WINDSHIELD WIPER/WASHER. THE SERVICE DEALER AND THE MANUFACTURER WERE CONTACTED, AND DETERMINED THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE CONTACT EXPRESSED CONCERN THAT THE WIPER PROBLEM COULD WORSENED AND POSE A RISK TO SAFETY.

DT*: THE CONTACT STATED THE BRAKE LIGHTS WERE LOOSE AND BECAME INOPERABLE. A NHTSA RECALL, #04V527000 WAS PERFORMED ON THE VEHICLE CONCERNING, THE EXTERIOR LIGHTING; BRAKE LIGHTS HOWEVER; THE RECALL DID NOT REMEDY THE PROBLEM. THE DEALERSHIP WOULD NOT OFFER A SECOND REPAIR UNDER THE RECALL.

IN THE PAST THREE WEEKS I HAVE SMELLED GAS AND STARTED GETTING A CHECK ENGINE LIGHT DID ALL THE NECESSARY STEPS TO CORRECT THE PROBLEM COME TO FIND OUT THE FILLER NECK IS BROKEN AWAY FROM THE TANK THAT HAS A HUGE POTENTIAL OF A FIERY REAR-END CRASH. CURSING THE NET IT SEEMS I AM NOT THE ONLY ONE AND FROM SOME OF THE COMMENTS HAVE LEAD ME TO BELIEVE THAT IT IS A COMMON PROBLEM OUT THERE . IS THERE SOME WAY TO GET GM TO FIX THEIR PROBLEM WITH THEIR GAS TANK? *JB

I SMELLED SOMETHING BURNING AFTER I PARKED MY 2003 GMC ENVOY XL IN THE GARAGE. AFTER INSPECTING, NOTICED TRANSMISSION FLUID LEAKING ON GROUND. TOWED TO MECHANIC. TOLD TRANSMISSION COOLER HOSE WAS LAYING NEXT TO CATALYTIC CONVERTER - NOT SECURED. HEAT FROM CC RUBBED HOLE IN TC HOSE AND THEREFORE COULD HAVE IGNITED VEHICLE. SINCE I HAD PARKED IN THE GARAGE, IT ALSO COULD HAVE BURNED MY OTHER VEHICLE AND OUR HOUSE. MECHANIC REPLACED HOSE AND SECURED. GMC WILL NOT ACKNOWLEDGE THIS IS A PROBLEM SINCE I DID NOT TAKE IT TO A DEALER FOR REPAIR AND THEY CANNOT FIND ANY RECALL OR BULLETIN ON THIS PROBLEM. *JB

SPEEDOMETER PEGGED OUT, ACTING ERRATIC...NO WARNING; JUST STARTED WHILE DRIVING AROUND 35 MPH. SPEEDOMETER DOES NOT WORK ! RECALL PLEASE ! *JB

CHECK ENGINE LIGHT HAS BEEN ON, TOLD TO GET NEW GAS CAP, MONTHS LATER SAME PROBLEM, ALTHOUGH THIS TIME MECHANIC FOUND A CRACK IN THE NECK OF THE HOSE THAT GOES INTO GAS TANK. AS I SEE IN THIS SECTION, APPEARS TO BE A COMMON PROBLEM. $800 LATER, I HOPE GMC WILL ACKNOWLEDGE THE FLAW AND ISSUE A RECALL? WILL THIS HAPPEN WITH MY NEW TANK TOO? *NM